MATERIAL SAFETY DATA SHEET
(SIMILAR TO OSHA 174)
SECTION 1-MANUFACTURER/DISTRIBUTOR INFORMATION
Supplier鈥檚 Name: INSCO, INC. Product Identification: FORMULA 20
Supplier鈥檚 Address: 1611 Ralston Street 飩? Wilson, NC 27893 Built Alkaline Cleaner
Emergency Phone #: Chemtel 800-255-3924 Vehicle and Truck Wash
HMIS Rating: Health 2 鈼? Flammability 0 鈼? Reactivity 0 Date: 06/04/02
SECTION 2-HAZARD INGREDIENTS
ACHIH TLV
CHEMICAL NAME CAS NO.
2-Butoxethanonol 111-76-2 25 ppm
Sodium Hydroxide (Caustic Soda) 1310-73-2 *C-1 MG/M3
The exact composition of this formulation is considered to be proprietary, however this product contains no other hazardous components at a
level of 1% greater and no known or suspected carcinogen at a level of 0.1% or greater.
*Denotes ceiling limits
Section 313: Supplier Information
This product contains the following toxic chemicals subject to the reporting requirements of section 313 of the emergency planning and
community Right-to-Know Act of 1986 and of 40 CFR 372:
CAS NO. CHEMICAL NAME % BY WIGHT
111-76-2 2-BUTOXETHANOL 4-6
This information must be included in all MSDS that are copied and distributed for this material.
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION DATA
Boiling Point (F): 212飩? Specific Gravity: (Water=1):1.02 Flash Point:(Method Used): No flash @ boil, (C.C)
Vapor Pressure: 25-28MM % Volatile By Weight: 88 Flammable Limits: N.A.
Vapor Density: (Air =1): Unkown Evaporation Rate:(Water =1): >1 Extinguishing Media: All types as determined by
Solubility In Water: Infinite pH: 12.0 鈥? 13.0 primary cause of combustion.
Appearance: Clear Red Liquid Special Fire Fighting Procedures: None
Odor: Cherry Unusual Fire & Explosion Hazards: None
SECTION 5-HEALTH HAZARD DATA
Threshold Limit Value: Has Not Been Determined
Carcinogen: This product contains non known carcinogen or potential carcinogen as defined by OSHA, the NTP, or the IRAC monographs.
Effects of Overexposure: Eye Irritant, Skin Irritant.
Emergency & First Aid Procedures: Eyes: Flush with water (minimum 15 min.). If irritation apparent, call physician.
Skin: Flush with water, if irritation apparent, call physician.
Ingestion: Drink large volumes of milk or water, call physician.
SECTION 6-REACTIVITY DATA SECTION 7-SPILL OR LEAK PROCEDURES
Stability: (Stable/Unstable) Stable Small Spills: Wipe up product, rinse soiled area with
Conditions to Avoid: None water down drown
Incompatability: None Large Spills: Stop leak at the source and collect into a
Hazardous Decomposition Products: None a suitable container, then treat as a small
Hazardous Polymerization: Will not occur spill. Follow state and local regulations
For disposal of large non-reclaimable spills.
SECTION 8-SPECIAL PROTECTION INFORMATION SECTION 9-SPECIAL PRECAUTIONS
Respiratory Protection: None Precautions to be taken in a handling and storage:
Ventilation: (Local/Mechanical/Special): Local or Mechanical Keep lid sealed when not in use. Do not transport in open
Provide clean work room air container. Thoroughly wash all contaminated clothing before
Protective Gloves: For prolong use or direct contact reuse. Keep out of reach of children. For sale to use and
Eye Protection: Safety glasses storage by service personnel only.
Other Protective Equipment: None
The information contained in this MSDS was obtained from current and reliable sources, however the data is provided without any warranty, expressed or
implied, regarding its correctness or accuracy. Since the conditions or handling, storage and disposal of this product are beyond the control of this company, it
is not responsible for loss, injury and expense arising out of the product鈥檚 improper use. No warranty, expressed or inferred, regarding the product described in
this MSDS shall be created or inferred by any statement in the MSDS. Various government agencies may have specific regulations regarding the
transportation, handling, storage, use or disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.
PREPARED BY: S.B.
|