PRODUCT NAME: FORMULA 815 MX
PRODUCT NUMBER: 111005
PAGE 1 of 2
MATERIAL SAFETY DATA SHEET
Per 29 CFR 1910.1200 DATE PREPARED : 5/21/03
SECTION I.
P.O. BOX 270, INDIANAPOLIS, IN 46206-0270 (317) 923-3211
BRULIN & COMPANY. INC.
WEST COAST FACTORY
Richmond, California
24 HOUR EMERGENCY NUMBER
CHEMTREC 1-800-424-9300
Health: 1
IDENTITY (As listed on label): HMIS HAZARD RATINGS: Flammability: 0
Reactivity: 0
FORMULA 815 MX
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Components ACGIH OTHER LIMITS
(Specific Chemical Identity: Common Name(s) CAS # OSHA PEL TLV-TWA RECOMMENDED PERCENT
Ethanolamine, 2-Aminoethanol, Monoethanolamine 141-43-5 3 PPM 3 PPM STEL 6 PPM 1-5
SECTION 313 SUPPLIER NOTIFICATION
The toxic chemical(s) listed above which are marked with an (*) are subject to the reporting requirements of Section 313 of the Emergency Planning and
Community Right-To-Know Act of 1986 and of 40 CFR 372. Not all chemicals subject to Section 313 of EPCRA appear on the OSHA Floor List of
Hazardous Chemicals.
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: 212 F Specific Gravity (H2O=1): 1.076
Vapor Pressure (mm Hg): Ethanolamine 0.2@68F Melting Point: Approx. 30 F
Vapor Density (Air=1): Ethanolamine 2.1 Evaporation Rate (water=1): 1.0
Solubility in Water: Complete
Appearance and Odor: Blue green liquid, citrus odor.
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): None
Flammable Limits LEL NA UEL NA
Extinguishing Media: Not Applicable
Special Fire Fighting Procedures: None
Unusual Fire and Explosion Hazards: None
PRODUCT NAME: FORMULA 815 MX
PRODUCT NUMBER: 111005
PAGE 2 of 2
SECTION V - REACTIVITY DATA
Stability Unstable Stable X
Conditions to Avoid: Freezing
Incompatibility (Materials to Avoid): Strong oxidizers and acids.
Hazardous Decomposition or Byproducts: Thermal decomposition can produce carbon monoxide, carbon
dioxide, nitrogen oxides.
Hazardous Polymerization: May Occur May Not Occur X
Conditions to Avoid: None
SECTION VI - HEALTH HAZARD DATA
Route(s) of Entry: Ingestion? Yes Skin? Yes Inhalation? Yes Eyes?
Health Hazards (Acute and Chronic): Eye - Direct contact may cause irritation. Ingestion - May cause
gastrointestinal irritation and irritation of mouth and throat. Skin -
Prolonged or repeated contact may cause irritation. Inhalation -
Excessive exposure may cause respiratory irritation.
Carcinogenicity: NTP? No IARC Monographs? No OSHA Regulated? No
Signs and Symptoms of Exposure: Eye contact may cause irritation, seen as redness and swelling. Prolonged
skin contact may cause irritation, seen as redness. Excessive inhalation of
mists may be irritating and cause coughing and discomfort in the nose throat
and chest. Ingestion may cause pain or discomfort in the mouth, throat, and
stomach.
Medical Conditions Generally Aggravated by Exposure: Ethanolamine may aggravate asthma and inflammatory or
fibrotic pulmonary disease. May also aggravate an
existing dermatitis.
Emergency & First Aid Procedures:
Eye Contact: Flush with large amounts of water for at least 15 minutes lifting upper & lower lids occasionally.
Get medical attention.
Inhalation: If affected, remove to fresh air.
Skin Contact: Wash with mild soap and water. Remove contaminated clothing and launder before reuse.
Ingestion: If conscious, dilute by giving at least two glasses of water. Call a physician or local poison
control center immediately.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to be Taken in Case Material is Released or Spilled: Absorb on solid absorbent and shovel into containers
for disposal.
Waste Disposal Method: Dispose of according to Federal, State and Local Laws and 40 CFR.
Precautions to be Taken in Handling and Storing: Store between 40 and 120 F.
SECTION VIII - CONTROL MEASURES
Respiratory Protection (Specify Type): Not normally required. Use NIOSH-MSHA approved respirator if TLV of
Ethanolamine is exceeded.
Ventilation: Mechanical (General): Normally Sufficient
Protective Gloves: Neoprene or butyl rubber on prolonged contact.
Eye Protection: Goggles or safety glasses when handling concentrate
Other Protective Clothing or Equipment:None
Work/Hygienic Practices: Avoid breathing spray mist.
|