===================== Product Identification =====================
MSDS NAME:0089 ZEPELEC II
NIIN:00F039724
MSDS Number: BWXMX
=== Responsible Party ===
Company:ZEP MFG CO
Box:2015
City:ATLANTA
State:GA
ZIP:30301-5000
Country:US
Info Phone Num:404-351-2952/404-432-2873
Emergency Phone Num:404-352-1680/404-435-2973
CAGE:0990Y
=== Contractor Identification ===
Company:ZEP MFG CO
Box:2015
City:ATLANTA
State:GA
ZIP:30301-5000
Country:US
Phone:404-351-2952/404-432-2873
CAGE:0990Y
Company:ZEP MFG CO
Box:UNKNOW
CAGE:27677
============= Composition/Information on Ingredients =============
Name:1,1-DICHLORO-1-FLUOROETHANE, FREON 141
CAS:1717-00-6
RTECS #:KI0997000
Fraction by Wt: >90%
Ozone Depleting Chemical:2
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: LOW LEVELS LEAD TO MILD
CNS EFFECTS. EXTREME EXPOSURE TO HIGH LEVELS CAN RESULT IN CNS
DEPRESSION, CARDIAC ARRHYTHMIA W/POSSIBLE CARDIAC SENSITIZATION TO
EPINEPHRINE/POSSIBLE DEATH & ASPHY XIATION. SKIN: CAN CAUSE
IRRITATION & DERMATITIS. EYES: IRRITATION & CONJUNCTIVITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA, LOSS
OF CONCENTRATION, INTOXICATION, STUPOR, DEFATTING.
======================= First Aid Measures =======================
First Aid:SKIN/EYES: IMMEDIATELY FLUSH W/PLENTY OF WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED, GIVE CPR
IF NEEDED. INGESTION: DON'T INDUCE VOMITING. IF VOMITING OCCURS,
KEEP HE AD BELOW HIP LEVEL. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:NONFLAMMABLE
Lower Limits:7.6
Upper Limits:17.7
Extinguishing Media:CO2, DRY CHEMICAL, & WATER FOG.
Fire Fighting Procedures:WEAR SCBA.
Unusual Fire/Explosion Hazard:MAY FORM TOXIC/CORROSIVE GASES. CONTAINER
MAY BURST IF HEATED > 120F.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB ON AN INERT ABSORBENT MATERIAL
(ZEP-O-ZORB) & PLACE IN A SUITABLE CONTAINER FOR DISPOSAL. WASH
AREA THOROUGHLY W/A DETERGENT SOLUTION & RINSE WELL W/WATER.
====================== Handling and Storage ======================
Handling and Storage Precautions:DON'T STORE AT TEMPS > 120F/IN DIRECT
SUNLIGHT. STORE & USE AWAY FROM HEAT/SPARKS/OPEN FLAME/ANY SOURCE
OF IGNITION. KEEP PRODUCT AWAY FROM SKIN/EYES.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T BREATHE SPRAY
MISTS/VAPORS. AVOID EXTENDED CONTACT W/ALUMINUM & ACTIVE METALS.
VAPORS ARE > THAN AIR & WILL ACCUMULATE AT LOW POINTS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE, WEAR A PROPERLY
FITTING MSHA/OSHA APPROVED RESPIRATOR.
Ventilation:EXHAUST FANS &/EXHAUST HOOD IN ENCLOSED SPACES.
Protective Gloves:NITRILE
Eye Protection:TIGHT FITTING SAFETY GLASSES
Work Hygienic Practices:CONTACT LENSES SHOULD NOT BE WORN WHEN WORKING
W/THIS MATERIAL.
Supplemental Safety and Health
WASTE CON'TD: IN MOST STATES TOTAL HAZARDOUS WASTE QUANTITIES LESS THAN
220 LBS PER MONTH MAY ALLOW DISPOSAL IN A CHEMICAL/INDUSTRIAL WASTE
LANDFILL. DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:89.6F
Vapor Pres:7600
Vapor Density:4.1
Spec Gravity:1.24
Evaporation Rate & Reference:(ETHER = 1): >1
Solubility in Water:SLIGHT
Appearance and Odor:A CLEAR, THIN LIQUID W/A FAINT SWEETISH ODOR
Percent Volatiles by Volume:100%
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & ALKALIS, OXIDIZERS & ACTIVE METALS, ALUMINUM.
Stability Condition to Avoid:TEMPS > 120F, HEAT, SPARKS, OPEN FLAME &
OTHER IGNITION SOURCE.
Hazardous Decomposition Products:HYDROGEN CHLORIDE, HYDROGEN FLUORIDE,
CARBONYL HALIDES SUCH AS PHOSGENE, CHLORINE & FLUORINE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DON'T CRUSH, PUNCTURE/INCINERATE SPENT
CONTAINERS. LARGE NUMBERS OF AEROSOL CONTAINERS MAY REQUIRE
HANDLING AS A HAZARDOUS WASTE, BUT IN MOST STATES TOTAL HAZARDOUS
WASTE QUANTITIES < 220 LBS PER MONT H MAY ALLOW DISPOSAL. (SEE
SUPP)
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|