===================== Product Identification =====================
MSDS NAME:6210 SEARS MINERAL SPIRITS PAINT THINNER
NIIN:00F039680
MSDS Number: BWXKX
=== Responsible Party ===
Company:STAR BRONZE COMPANY
Box:2206
City:ALLIANCE
State:OH
ZIP:44601-5000
Country:US
Info Phone Num:216-823-1550
Emergency Phone Num:216-823-1550
CAGE:OO282
=== Contractor Identification ===
Company:STAR BRONZE COMPANY
Box:2206
City:ALLIANCE
State:OH
ZIP:44601
Phone:(216) 823-1550
CAGE:OO282
============= Composition/Information on Ingredients =============
Name:STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: >95%
Other REC Limits:525 MG/CUM
OSHA PEL:500 PPM
ACGIH TLV:100 PPM
Name:VOLATILE ORGANIC COMPOUNDS: 772 G/L
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPORS CAN CAUSE NASAL &
RESPIRATORY IRRITATION, CENTRAL NERVOUS SYSTEM EFFECTS/DEATH. SKIN:
PROLONGED/REPEATED CONTACT CAN CAUSE MODERATE IRRITATION &
DERMATITIS. EYES: SEVERE IRRITATION. INGESTION: GI IRRITATION.
ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL.(SUPP
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, POSSIBLE UNCONSCIOUSNESS, DEFATTING, REDNESS,
TEARING, BLURRED VISION, VOMITING, DIARRHEA.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
KEEP WARM & QUIET. SKIN: THOROUGHLY WASH EXPOSED AREA W/SOAP &
WATER. EYES: IMMEDIATELY FLUSH THOROUGHLY W/LARGE AMOUNTS OF WATER.
INGESTION : ASPIRATION HAZARD. DON'T INDUCE VOMITING. KEEP WARM &
QUIET. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:100F
Lower Limits:1
Extinguishing Media:REGULAR FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA W/A FULL FACE PIECE OPERATED IN THE
POSITIVE PRESSURE DEMAND MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS ARE > THAN AIR & MAY TRAVEL ALONG
GROUND/MORE BY VENTILATION & IGNITE BY DISTANT SOURCES. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL: ABSORB ON PAPER ABSORBENT & TRANSFER TO
VENT HOOD/CLOSED CONTAINER. LARGE: ELIMINATE IGNITION SOURCES.
CONTAIN , STOP AT SOURCE. VENTILATE AREA, AVOID BREATHING VAPORS.
CLEAN UP W/ABSORBENT & P LACE IN CLOSED CONTAINER.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE IN COOL DRY AREA. STORE UPRIGHT
TO PREVENT LEAKS. KEEP CONTAINER TIGHTLY CLOSED. KEEP AWAY FROM
HEAT/SPARKS & OTHER IGNITION SOURCES.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING THE CONTENTS MAY BE HARMFUL/PROVE FATAL. AVOID CONTACT
W/EYES, SKIN & CLOTHING. AVOID BREATHING VAPORS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORK PLACE EXPOSURE LIMITS OF PRODUCTS ARE
EXCEEDED A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED,
ALSO OSHA PERMITS OTHER NIOSH/MSHA RESPIRATORS (NEGATIVE PRESSURE
TYPE) UNDER SPECIFIED CONDITIONS.
Ventilation:MECHANICAL (GENERAL) &/LOCAL EXHAUST TO MAINTAIN EXPOSURE <
PEL & TLV.
Protective Gloves:NITRILE RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES/SAFETY GLASSES
Other Protective Equipment:IMPERVIOUS CLOTHING, BOOTS, APRONS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/DRINKING/SMOKING.
Supplemental Safety and Health
HLTH HZRD CONT'D: EXCESSIVE EXPOSURE MAY CAUSE PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. LARGE SPILLS CONT'D: VENTILATE AREA, AVOID
BREATHING VAPORS. CLEAN UP W/ABSORBENT MATERIAL & PLACE IN CLOSED
CON TAINER FOR DISPOSAL.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:310-390F
Vapor Pres:2
Vapor Density:4.9
Spec Gravity:0.773
Evaporation Rate & Reference:(ETHER = 1): 70
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID W/TYPICAL HYDRO CARBON ODOR
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, FLAMES & OTHER SOURCES OF
IGNITION.
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL: ALLOW VOLATILE PORTION TO EVAPORATE AWAY
FROM INHABITED AREAS/IN VENTILATED HOOD & DISPOSE OF REMAINING
MATERIAL. LARGE: DISPOSE OF BY SENDING TO LICENSED
RECLAIMER/PERMITTED INCINERATOR. DISPO SE IAW/FEDERAL, STATE &
LOCAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|