===================== Product Identification =====================
MSDS NAME:SPARVAR PRODUCTS-3, S-311 RED ORANGE
NIIN:00N083643
MSDS Number: CGRCC
=== Responsible Party ===
Company:SHERWIN-WILLIAMS CO
Address:31500 SOLON RD
City:SOLON
State:OH
ZIP:44139
Country:US
Info Phone Num:800-777-2966
Emergency Phone Num:216-566-2917
CAGE:DO642
=== Contractor Identification ===
Company:SHERWIN-WILLIAMS CO THE SPECIALTY DIV.
Address:6830 COCHRAN RD.
Box:6709
City:SOLON
State:OH
ZIP:44139-3908
Phone:216-292-7400
CAGE:DO642
Company:SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC.
Address:26300 FARGO AVENUE
Box:City:BEDFORD HEIGHTS
State:OH
ZIP:44146
Country:US
Phone:216-292-7400 OR 216-595-8634
CAGE:09800
============= Composition/Information on Ingredients =============
Name:PROPANE. VP: 760.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 14%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
Name:BUTANE. VP: 760.
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 6%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM
Name:HEXANE (CERCLA). VP: 127.
CAS:110-54-3
RTECS #:MN9275000
Fraction by Wt: 11%
OSHA PEL:500 PPM
ACGIH TLV:50 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:PENTANE, 2-METHYL-; (ISOHEXANE ISOMERS). VP: 250.
CAS:107-83-5
RTECS #:SA2995000
Fraction by Wt: 4%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:VM & P NAPHTHA. VP: 12.
CAS:64742-89-8
Fraction by Wt: 18%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:XYLENE (SARA 313) (CERCLA). VP: 5.9.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM; 150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:ACETONE (SARA 313) (CERCLA). VP: 180.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 12%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM; 1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:CARBONIC ACID, CALCIUM SALT (1:1); (CALCIUM CARBONATE)
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 3%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:BARIUM SULFATE (CONTAINING INGREDIENT 10)
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 18%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST
Name:BARIUM (SARA 313)
CAS:7440-39-3
RTECS #:CQ8370000
Fraction by Wt: 11%
OSHA PEL:0.5 MG/M3
ACGIH TLV:N/K
Name:VOLATILE ORGANIC COMPOUND BY WT PER BAAQMD RULE 49: 52.9%;
VOC TOTAL: 3.79 LBS/GAL
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Name:SUPDAT: REPORTS HAVE ASSOCIATED RPTD & PRLNGD OVEREXPOSURE
TO SOLVENTS W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
RTECS #:9999999ZZ
Name:HNDLG/STOR PRECS: NOT SMOKE - EXTING ALL FLAMES, PILOT
LIGHTS & HEATERS - TURN OFF STOVES, ELEC TOOLS & (ING 14)
RTECS #:9999999ZZ
Name:ING 13: APPLIANCES & ANY OTHER SOURCES OF IGNIT. CONSULT
NFPA CODE. USE APPRVD BONDING & GROUNDING PROCEDURES. (ING 15)
RTECS #:9999999ZZ
Name:ING 14: CONTENTS UNDER PRESS. DO NOT PUNCTURE, INCINERATE
OR EXPOSE TO TEMPS ABOVE 120F. HEAT FROM SUNLIGHT, (ING 16)
RTECS #:9999999ZZ
Name:ING 15: RADIATORS, STOVES, HOT WATER & OTHER HEAT SOURCES
COULD CAUSE CNTNR TO BURST. DO NOT TAKE INTERNALLY. (ING 17)
RTECS #:9999999ZZ
Name:ING 16: KEEP OUT OF THE REACH OF CHILDREN.
RTECS #:9999999ZZ
Name:OTHER PRECS: PARTICULATES LISTED "AS DUST" IN INGRED
SECTION WHICH MAY BE PRESENT AT HAZ LEVELS ONLY DURING (ING 19)
RTECS #:9999999ZZ
Name:ING 18: SANDING/ABRADING OF DRIED FILM. IF NO SPECIFIC
DUSTS ARE LISTED, APPLIC LIMITS FOR NUISANCE DUSTS ARE (ING 20)
RTECS #:9999999ZZ
Name:ING 19: ACGIH TLV 10 MG/M3 (TDUST), OSHA PEL 15 MG/M3
(TDUST), 5 MG/M3 (RESPIRABLE FRACTION).
RTECS #:9999999ZZ
Name:RESP PROT: GENERATED FROM THIS PROD, UNDERLYING PAINT OR
THE ABRASIVE.
RTECS #:9999999ZZ
Name:VENT: REFER TO OSHA STANDARDS 1910.94, 1910.107, 1910.108.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRIT OF EYES, SKIN &
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
OVEREXP MAY RESULT IN UNCON & POSS DEATH. HDCH, DIZZ, NAUS & LOSS
OF COORD ARE INDICATIONS OF EXCESS EXPOS TO VAPS/SPRAY MISTS.
REDNESS & ITCHINGOR BURNING SENSATION MAY INDICATE EYE/EXCESS SKIN
EXPOS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: CHRONIC: PRLNGD & RPTD EXPOS TO
HEXANE MAY CAUSE DAMAGE TO NERVE TISSUE OF ARMS & LEGS (PERIPHERAL
NEUROPATHY) RESULTING IN MUSCULAR WEAKNESS & LOSS OF SENSATION.
THIS EFFECT MAY BE INCREASE D BY THE PRESENCE OF METHYL ETHYL
KETONE. PRLNGD OVEREXPOSURE TO SOLVENT INGREDIENTS LISTED MAY CAUSE
ADVERSE (SUPDAT)
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.
======================= First Aid Measures =======================
First Aid:INHAL: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE BRTHG. KEEP
WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER.
REMOVE CONTAMD CLTHG & LAUNDER BEFORE REUSE. EYES: FLUSH EYES
W/LARGE AM TS OF WATER FOR AT LEAST 15 MIN. GET MED ATTN. INGEST:
NEVER GIVE ANYTHING BY MOUTH TO AN UNCON PERSON. DO NOT INDUCE
VOMIT. GIVE CONSCIOUS PATIENT SEVERAL GLASSES OF WATER. SEEK MED
ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:<0F,<-18C
Lower Limits:0.7%
Upper Limits:12.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP. WATER
SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZS ARE PREF. WATER
MAY BE USED TO COOL CLSD CNTNRS (SUPDAT)
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPKS &
OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATN TO HOT SURFS REQS SPEC PRECS. DURING (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPKS & OPEN
FLAME. VAPS WILL ACCUM READILY & MAY IGNITE EXPLO. DURING USE &
UNTIL ALL VAPS ARE GONE:KEEP AREA VENTD - DO (ING 13)
Other Precautions:INTENTIONAL MISUSE BY DEBLIB CONC & INHAL CONTENTS
CAN BE HARMFUL/FATL. USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY
MIST. AVOID CNTCT W/SKIN & EYES. WASH HANDS AFTER USING. THIS
COATING MAY CNTN MAT LS CLASSIFIED AS NUISANCE (ING 18)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT, WEAR PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESP APPRVD BY NIOSH. WHEN SANDING/ABRADING DRIED FILM, WEAR
DUST/MIST RESP APPRVD BY N IOSH FOR DUST WHICH MAY BE (ING 21)
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOS TO MATLS LISTED IS MAINTAINED BELOW EXPOS LIMITS. (ING 22)
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: TO PVNT PRESS BUILDUP & POSS AUTOIGNIT OR EXPLO WHEN
EXPOS TO EXTREME HEAT. EXPLO HAZ: EMER CNDTNS OVEREXP TO DECOMP
PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT. OBTAIN
MED ATTN. EFTS OF OVEREXP: EFFECTS TO LIVER, URINARY,
BLOOD-FORMING, CARDIOVASCULAR & REPRODUCTIVE SYSTEMS. (ING 12)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:<395F,<202C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.861
Evaporation Rate & Reference:FASTER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE, OXIDES OF METALS LISTED IN INGREDIENT SECTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER
RCRA 40 CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY TO DETERMINE
APPLIC EPA HAZ WASTE NUMBERS. DO NOT INCIN. DEPRESSURIZE CNTNR.
DISPOSE OF I/A/W FE DERAL, STATE & LOCAL REGS REGARDING POLLUTION.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|