===================== Product Identification =====================
MSDS NAME:CIDEX OPA SOLUTION
Status Code:A
MSDS Number: CKZKR
=== Responsible Party ===
Company:ADVANCED STERILIZATION PRODUCTS A JOHNSON & JOHNSON CO.
Address:33 TECHNOLOGY DR
City:IRVINE
State:CA
ZIP:92618-2346
Country:US
Info Phone Num:800-755-5900/888-783-7723
Emergency Phone Num:(800)424-9300
Resp. Party Other MSDS Num.:MS-09588-0-001
Chemtrec Ind/Phone:(800)424-9300
CAGE:04ES7
=== Contractor Identification ===
Company:ADVANCED STERILIZATION PRODUCTS A JOHNSON & JOHNSON CO.
Address:33 TECHNOLOGY DR
Box:City:IRVINE
State:CA
ZIP:92618-2346
Country:US
Phone:800-755-5900/888-783-7723
CAGE:04ES7
============= Composition/Information on Ingredients =============
Name:ACTIVE INGREDIENTS
= Wt:.55
Name:INACTIVE INGREDIENTS
= Wt:99.45
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: ORAL, RAT: > 2000 MG/KG
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: SKIN, EYES, RESPIRATORY
TRACT. ACUTE: THE MOST LIKELY SYMPTOM OF ACUTE OVEREXPOSURE WOULD
BE SLIGHT IRRITATION OF CONTAMINATED SKIN, OR EYE IRRITATION AFTER
CONTACT WITH MISTS OF THIS PRODUCT. CHRONIC: PROLONGED OR
REPEATED CONTACT WITH THE SKIN MAY LEAD TO DERMATITIS.
Explanation of Carcinogenicity:THIS PRODUCTS COMPONENTS ARE NOT FOUND
ON THE FOLLOWING LISTS: US FEDERAL OSHA Z LIST, NTP, IARC, AND
CAL/OSHA AND THEREFORE ARE NEITHER CONSIDERED TO BE NOR SUSPECTED
TO BE CANCER-CAUSING AGENTS BY T HESE AGENCIES.
Effects of Overexposure:THIS PRODUCT IS PREDOMINATELY WATER & PRESENTS
MINIMAL HAZARDS. INHALATION-BREATHING MIST/SPRAY MAY MILDLY
IRRITATE THE NOSE, THROAT & RESPIRATORY SYSTEM. SYMPTOMS INCLUDE
COUGHING & SNEEZING. CONTACT WITH SKIN/EYES-PERSONS WITH POTENTIAL
EXPOSURE SHOULD NOT WEAR CONTACT LENSES. EYE CONTACT MAY CAUSE
STINGING, EXCESS TEARING, & REDNESS. SKIN CONTACT MAY CAUSE
STAINING & BE MILDLY IRRITATING. REPEA TED SKIN CONTACT MAY CAUSE
DERMATITIS (RED, CRACKED SKIN). INGESTION-INGESTION MAY IRRITATE
THE TISSUE OF THE MOUTH, ESOPHAGUS DIGESTIVE SYSTEM. SYMPTOMS MAY
INCLUDE VOMITING, DIARRHEA, & NAUSEA. INJE CTION-PAIN, MILD
IRRITATION, & SWELLING.
Medical Cond Aggravated by Exposure:PREEXISTING ASTHMA, BRONCITIS, OR
DERMATITIS AND OTHER SKIN DISORDERS CAN BE AGGRAVATED BY EXPOSURE
TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:SKIN: S28: AFTER CONTACT WITH CIDEX OPA SOLUTION, WASH
IMMEDIATELY WITH PLENTY OF WATER. IF A SKIN REACTION SHOULD OCCUR,
SEEK MEDICAL ADVICE. EYE: S26: IN CASE OF CONTACT WITH EYES, RINSE
IMMEDIATELY WITH PLENTY OF WATER AND SEEK MEDICAL ADVICE IF
IRRITATION OR DISCOMFORT PERSISTS. INHALATION: IF VAPORS OR MISTS
OF THIS PRODUCT ARE INHALED, REMOVE VICTIM TO FRESH AIR, AND SEEK
MEDICAL ADVICE. ING ESTION: S46: IF SWALLOWED, SEEK MEDICAL ADVICE
IMMEDIATELY AND SHOW PACKAGE OR LABEL. CALL PHYSICIAN OR YOUR LOCAL
POISON CONTROL CENTER FOR MOST CURRENT INFORMATION.
===================== Fire Fighting Measures =====================
Autoignition Temp:Autoignition Temp Text:NOT AP
Lower Limits:NOT APPLICAB
Upper Limits:NOT APPLICAB
Extinguishing Media:SELECT FIRE EXTINGUISHING MEDIA APPROPRIATE FOR THE
SURROUNDING AREA. WATER SPRAY, (FOR COOLING). CARBON DIOXIDE, FOAM,
HALON, DRY CHEMICAL, ANY "ABC" CLASS.
Fire Fighting Procedures:INCIPIENT FIRE RESPONDERS SHOULD WEAR EYE
PROTECTION. STRUCTURAL FIREFIGHTERS MUST WEAR SELF CONTAINED
BREATHING APPARATUS & FULL PROTECTIVE EQUIPMENT. MOVE FIRE-EXPOSED
CANS IF IT CAN BE DONE WITHOUT RISK. IF POSSIBLE, FIREFIGHTERS
SHOULD CONTROL RUNOFF WATER TO PREVENT ENVIRONMENTAL CONTAMINATION.
Unusual Fire/Explosion Hazard:MINIMAL RISK OF WATER EVAPORATING IN A
FIRE CAUSING REMAINING MATERIAL TO BURN AND PRODUCT CARBON MONOXIDE
AND/OR CARBON DIOXIDE. RINSE CONTAMINATED EQUIPMENT WITH SOAPY
WATER BEFORE RETURNING SUCH EQ UIPMENT TO SERVICE.
================== Accidental Release Measures ==================
Spill Release Procedures:SMALL RELEASES CAN BE CLEANED UP USING A DAMP
SPONGE OR POLYPAD. RESPONDERS SHOULD WEAR GLOVES, GOGGLES, &
SUTIABLE BODY PROTECTION DURING THE CLEAN UP OF SPILL. IN CASE OF
LARGE SPILL, CLEAR THE AFF ECTED AREA, RESPOND WITH TRAINED
PERSONNEL & CONTAIN THE SPILL. MINIMUM PERSONAL PROTECTIVE
EQUIPMENT SHOULD BE LEVEL D: (SAFETY GLASSES, GLOVES, APRON OR LAB
COAT). "SEE OTHER INFO"
Neutralizing Agent:SPRINKLE APPROXIMATELY 25 GRAMS OF GLYCINE (FREE
BASE) POWDER PER GALLON OF ESTIMATED CIDES OPA SOLUTION SPILL.
====================== Handling and Storage ======================
Handling and Storage Precautions:ALL EMPLOYEES WORKING WITH THIS
PRODUCT MUST BE PROPERLY TRAINED. STORE CONTAINERS IN A COOL, DRY
LOCATION (15 - 30 DEG C, 59 - 86 DEG F), AWAY FROM DIRECT SUNLIGHT,
OR SOURCES OF INTENSE HEAT. STORE AWAY FROM INCOMPATIBLE
MATERIALS. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:INSPECT ALL INCOMING CONTAINER BEFORE STORAGE TO
ENSURE CONTAINERS ARE PROPERLY LABELED & ARE NOT DAMAGED. EMPTY
CONTAINERS MAY CONTAIN RESIDUAL AMOUNTS OF THIS PRODUCT; & MUST BE
TRIPLE RINSED PRIOR TO DISPOSAL.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE NORMALLY REQUIRED FOR ROUTINE USE. IF
RESPIRATORY PROTECTION IS NEEDED, SUCH AS DURING THE USE OF THIS
PRODUCT WITH OTHER MATERIALS, OR DURING EMERGENCY RESPONSE TO
UNCONTROLLED RELEASES, USE ONL Y PROTECTION AUTHORIZED IN 29 CFR
1910.134 APPLICABLE U.S. STATE REGS, OR THE APPROPRIATE STANDARDS
OF CANADA & ITS PROVINCES OR EC MEMBER STATES (PER EN149).
Ventilation:USE WITH ADEQUATE VENTILATION. PRODUCT CAN BE USED WITH
LOCAL EXHAUST HOOD, DUCTLESS FUME HOOD/PORTABLE VENTILATION SYSTEM,
WHICH CONTAIN FILTER MEDIA.
Protective Gloves:LATEX OR NITRILE RUBBER GLOVES FOR ROUTINE USE.
Eye Protection:SAFETY GLASSES AS AUTHORIZED IN 29 CFR 1910.133.
Other Protective Equipment:LATEX GLOVES HOULD BE CHANGED FREQUENTLY
(EVERY 10-15 MINS) DURING USE OF PRODUCT. USE TRIPLE GLOVES FOR
SPILL RESPONSE. USE BODY PROTECTION APPROPRIATE FOR TASK (E.G.
FLUIS-RESISTANT GOWNS OR APRONS).
Work Hygienic Practices:AS WITH ALL CHEMICALS, AVOID GETTING THIS
PRODUCT ON YOU OR IN YOU. WASH THOROUGHLY AFTER HANDLING THIS
PRODUCT. DO NOT EAT, DRINK, SMOKE, OR APPLY CUSTMETICS WHILE
HANDLING THIS PRODUCT.
Supplemental Safety and Health
HYGIENE: AVOID BREATHING MISTS & SPRAYS OF THIS PRODUCT. USE IN A
WELL-VENTILATED LOCATION. REMOVE CONTAMINATED CLOTHING
IMMEDIATELY. *TRADE NAME: CIDEX OPA SOLUTION. CHEMICAL NAME/CLASS:
ALDEHYDE & INORGANIC SALT SOLUTION. PRODUCT USE: HIGH LEVEL
DISINFECTANT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:=0.C, 32.F
Spec Gravity:1.0003 G/CC (WATER=1)
pH:7.2-7.8 (0.1 M
Evaporation Rate & Reference:SIMILAR TO WATER(N-BUAC=1
Solubility in Water:SOLUBLE
Appearance and Odor:LIQUID; CLEAR, LIGHT BLUE; PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
MATERIALS THAT ARE INCOMPATABLE WITH WATER. STRONG ACIDS AND STRONG
OXIDIZERS. STRONGLY ALKALINE MATERIALS (> PH 10) WILL CATALYZE A
REDOX REACTION, WHICH IS EXOTHERMIC, BUT IS NOT EXPECTED TO BE OF A
VIOLENT NATURE.
Stability Condition to Avoid:AVOID EXPOSURE OR CONTACT TO EXTREME
TEMPERATURES, INCOMPATABLE CHEMICALS.
Hazardous Decomposition Products:PRODUCTS OF THERMAL DECOMPOSITION
INCLUDE CARBON OXIDES.
Conditions to Avoid Polymerization:WILL NOT OCCUR
=================== Toxicological Information ===================
Toxicological Information:CIDEX OPA SOLUTION: EYE EXPOSURE
(RABBIT)=SLIGHTLY IRRITATING, BUT REVERSIBLE IN SEVEN DAYS.
LD50(SKIN, RABBIT)>2000 MG/KG. IRRITANCY OF PRODUCT: THIS PRODUCT
MAY BE MILDLY IRRITATING TO CONTAMINATED TISSUE, ESPECIALLY AFTER
PROLONGED OR REPEATED EXPOSURE. SENSITIZATION TO THE PRODUCT:
O-PHTHALADEHYDE ( A COMPONENT OF THIS PRODUCT PRESENT IN < 1%
CONCENTRATION) IS A POTENTIAL SKIN & RESPIRATORY SE NSITIZER. DUE
TO THE LOW CNCENTRATION OF O-PHTHALADEHYDE (0.55%) IN THE PRODUCT,
THIS HAZARD IS GREATELY MINIMIZED. RECOMMENDATIONS TO PHYSICIANS:
PROBABLE MUCOSAL DAMAGE FROM ORAL EXPOSURE MAY CONTRA INDICATE THE
USE OF GASTRIC LAVAGE.
===================== Ecological Information =====================
Ecological:ALL WORK PRACTICES MUST BE AIMED AT ELIMINATING
ENVIRONMENTAL CONTAMINATION. ENVIRONMENTAL STABILITY: THE
COMPONENTS OF THIS PRODUCT WILL SLOWLY DECOMPOSE INTO INORGANIC &
ORGANIC COMPOUNDS. THE FOLLW ING ENVIRONMENTAL DATA ARE AVAILABLE
FOR THE COMPONENTS OF THIS PRODUCT: O-PHTHALADEHYDE: WATER
SOLUBILITY=53 G/L/20C.
==================== Disposal Considerations ====================
Waste Disposal Methods:WASTE DISPOSAL MUST BE IN ACCORDANCE WITH
APPROPRIATE U.S. FEDERAL, STATE, AND LOCAL REGULATIONS OR WITH
REGULATIONS OF CANADA OR EC MEMBER STATES. IF PERMITTED FOR
DISPOSAL TO THE SEWER BY LOCAL AND STATE AUTHORITIES, SPEND CIDEX
OPA SOLUTION MAY BE PUT DOWN THE DRAIN. SEE PRODUCT INSERT FOR
FURTHE R INFORMATION.
=================== MSDS Transport Information ===================
Transport Information:THIS MATERIAL IS NOT HAZARDOUS PER THE U.S.
DEPARTMENT OF TRANSPORTATION (49 CFR 172.101). PROPER SHIPPING
NAME: NOT APPLICABLE. HAZARD CLASS NUMBER AND DESCRIPTION: NOT
APPLICABLE. UN IDENTIFICATION NUMBER: NOT APPLICABLE. PACKING
GROUP: NOT APPLICABLE. DOT LABEL(S) REQUIRED: NOT APPLICABLE.
NORTH AMERICAN EMERGENCY RESPONSE GUIDEBOOK NUMBER, 1998: NOT
APPLICABLE. MARINE POLLUTANT: NO COMPON ENT OF THIS PRODUCT IS
DESIGNATED AS A MARINE POLLUTANT, PER APPENDIX B TO 49 CFR 172.101.
TRANSPORT CANADA, TRANSPORTATION OF DANGEROUS GOODS REGULATIONS:
THIS MATERIAL IS NOT CONSIDERED AS DANGEROUS GOODS.
===================== Regulatory Information =====================
SARA Title III Information:U.S SARA REPORTING REQUIREMENTS: THE
COMPONENTS OF THIS PRDUCT ARE NOT SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 302, 304, & 313 OF TITLE OF THE SUPERFUND
AMENDMENTS & REAUTHORIZATION ACT. U.S SARA THRESHOLD PLANNING
QUANTITY: NOT APPLICABLE. U.S. CERCLA REPORTABLE QUANTITY (RQ):
NOT APPLICABLE. U.S.
Federal Regulatory Information:U.S. TSCA INVENTORY STATUS: THE
COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
State Regulatory Information:CALIFORNIA SAFE DRINKING WATER AND TOXIC
ENFORCEMENT ACT (PROPOSITION 65): NO COMPONENT OF THIS PRODUCT IS
ON THE CALIFORNIA PROPOSITION 65 LISTS.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|