=====================  Product Identification  =====================

MSDS NAME:WILFLEX W-3109
NIIN:00N011341
MSDS Number: BHZCL
=== Responsible Party ===
Company:FLEXIBLE PRODUCTS COMPANY,VINYL DIVISION
Address:1007 INDUSTRIAL PARK DRIVE
City:MARIETTA
State:GA
ZIP:30061
Info Phone Num:404-428-2684
Emergency Phone Num:404-428-2684;800-424-9300(CHEMTREC)
Preparer's Name:GEORGE HART
CAGE:22289
=== Contractor Identification ===
Company:FLEXIBLE PRODUCTS CO
Address:1007 INDUSTRIAL PARK DR
Box:City:MARIETTA
State:GA
ZIP:30062
Country:US
Phone:770-428-2684
CAGE:22289

=============  Composition/Information on Ingredients  =============

Name:CALCIUM CARBONATE (MARBLE) (LIMESTONE)
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: 15%
Other REC Limits:N/K 
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST; 9192

Name:DI-SEC-OCTYL PHTHALATE (DI-2-ETHYLHEXYL-PHTHALATE)	(SARA
    III)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: 45%
Other REC Limits:N/K 
OSHA PEL:5 MG/M3/10 STEL
ACGIH TLV:5 MG/M3; 9192
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:MOST TOXIC COMPONENT ONLY (SEE SUP DATA)
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:NO
Health Hazards Acute and Chronic:CHRONIC HEALTH HAZARD:SILICOSIS.THIS
    PRODUCT IS MUTAGENIC AND A REPRODUCTIVE HAZARD (MFR).
Explanation of Carcinogenicity:DIOCTYL PHTHALATE:SUSP HUM CARC/KNOWN
    ANIM CARC (NTP,1985).NO ADEQ DATA TO EVAL HUM CARC/SUFF EVID IN
    ANIM (SEE SUPP)
Effects of Overexposure:EYES:MODERATE IRRITATION.SKIN:MODERATE
    IRRITATION.DEFATTING (DRYING OUT) OF SKIN OCCURS UPON REPEATED
    CONTACT.INGESTION:GASTROINTESTINAL IRRITATION,NAUSEA,VOMITING AND
    DIARRHEA.INHALATION:IRRITATION O F RESPIRATORY
    TRACT.SILICOSIS.PULMONARYIRRITANT.
Medical Cond Aggravated by Exposure:N/K 

=======================  First Aid Measures  =======================

Eyes:FLUSH WITH CLEAN,LUKEWARM WATER (LOW PRESSURE) FOR AT
    LEAST 15 MIN.GET PROMPT MED ATTN.SKIN:REMOVE CONTAM CLTHG.WASH
    THOROUGHLY WITH SOAP AND WATER.INGESTION:CONSULT MD
    IMMEDIATELY.INHALATION:REM OVE TO WELL VENTILATED AREA FREE FROM
    RISK OF FURTHER EXPOSURE.TREAT SYMPTOMATICALLY.

=====================  Fire Fighting Measures  =====================

Flash Point:N/K 
Lower Limits:N/K 
Upper Limits:N/K 
Extinguishing Media:DRY CHEMICAL (MONO AMMONIUM PHOSPHATE,POTASSIUM
    SULFATE & POTASSIUM CHLORIDE),CARBON DIOXIDE,CHEM FOAM OR WATER
    SPRAY.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
    PROTECTIVE EQUIPMENT .A COLD WATER STREAM SHOULD BE DIRECTED TO
    COOL FIRE EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:PRESS CAN BUILD UP IN DRUMS & OTHER CLSD
    CONTRS EXPOSED TO TEMP FOUND IN FIRES.HAZ DECOMP PROD:COMBUSTION
    WILL GENERATE ACRID FUMES,HCL,ACETIC ACID,CO,CO*2.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SMALL:MAY BE COLLECTED WITH ABSORBENT
    MATERIALS.LARGE:MAY BE SHOVELED INTO DRUMS AND DISPOSED OF IN
    COMPLIANCE WITH FEDERAL,STATE & LOCAL ENVIRONMENTAL CONTROL
    REGULATIONS.
Neutralizing Agent:N/K 

======================	Handling and Storage  ======================

Handling and Storage Precautions:RECOMMENDED STORAGE
    TEMPERATURE:<85F,29.44C.RECOMMENDED STORAGE CONDITIONS:DO NOT STORE
    NEAR FLAME,HEAT OR STRONG OXIDANTS.
Other Precautions:EDUCATE EMPLOYEES IN THE SAFE USE OF THIS PRODUCT AND
    RELATED SAFETY EQUIPMENT.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
    EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
    CONCENTRATION BELOW TLV .
Protective Gloves:CHEMICAL RESISTANT.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:SAFETY SHOWERS AND EYEWASH STATIONS SHOULD
    BE AVAILABLE AND CLEARLY MARKED.
Work Hygienic Practices:WASH CONTAM CLTHG THOROUGHLY BEFORE
    REUSE.DESTROY CONTAMINATED SHOES.WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPEC GRAV:1.25+/-0.03 (WATER=1).LD50-LC50 MIX:LD50 RAT ORAL 30
    ML/KG,RABBIT DERMAL 25 G/KG;LDLO RAT INTRATRACHEAL 10 MG/KG.EXPLAN
    OF CARC:(IARC,1987).LIVER CANCER (MFR).

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:N/K 
Melt/Freeze Pt:M.P/F.P Text:N/K 
Decomp Temp:Decomp Text:N/K 
Vapor Pres:N/K 
Vapor Density:N/K 
Spec Gravity:SEE SUPP DATA
Evaporation Rate & Reference:N/K 
Solubility in Water:NEGLIGIBLE
Appearance and Odor:N/K 

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE UNDER NORMAL CONDITIONS.
Hazardous Decomposition Products:ACETIC ACID,HYDROGEN CHLORIDE,CARBON
    MONOXIDE,CARBON DIOXIDE BY COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
    FEDERAL,STATE AND LOCAL REGULATIONS .IF INCINERATED,BE AWARE THAT
    CORROSIVE HYDROGEN CHLORIDE IS GENERATED.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***