===================== Product Identification =====================
MSDS NAME:T/D PACK FOR SAVIN 760,765,790,895 COPIER
NIIN:00N011449
MSDS Number: BHZDR
=== Responsible Party ===
Company:REPEAT-O-TYPE MFG CORPORATION
Address:665 STATE HIGHWAY 23
City:WAYNE
State:NJ
ZIP:07470
Country:US
Info Phone Num:201-696-3330
Emergency Phone Num:201-696-3330
Preparer's Name:SUSAN P ONTAWAR
CAGE:94664
=== Contractor Identification ===
Company:REPEAT-O-TYPE MFG CORP
Address:665 STATE HWY 23
Box:City:WAYNE
State:NJ
ZIP:07470-6833
Country:US
CAGE:94664
============= Composition/Information on Ingredients =============
Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <2%
Other REC Limits:N/K
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192
Name:ISOPAR (PETROLEUM HYDROCARBON).EVAP RATE:0.3 (BUTYL
ACETATE=1).LEL:0.8.UEL:7.0.
CAS:8001-60-3
Fraction by Wt: >90%
Other REC Limits:300 PPM
OSHA PEL:N/K
ACGIH TLV:N/K
Name:COMPLEX MIXTURE OF ACRYLIC POLYMERS
Fraction by Wt: <5%
Other REC Limits:N/K
OSHA PEL:N/K
ACGIH TLV:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED SKIN CONTACT
REMOVES SKIN OIL LEADING TO DERMATITIS.MINUTE AMOUNTS ASPIRATED
INTO LUNGS DURING INGESTION MAY CAUSE SEVERE PULMONARY INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.SKIN:PROLONGED OR REPEATED
CONTACT REMOVES OIL LEADING TO IRRITATION &
DERMATITIS.INGESTION:MINUTE AMOUNTS ASPIRATED INTO LUNGS MAY CAUSE
SEVERE PULMONARY INJURY.INHALATION:IRRITATION OF RESPIRATORY
TRACT.HIGH VAPOR CONCENTRATION MAY CAUSE HEADACHE & DIZZINESS & MAY
AFFECT CENTRAL NERVOUS SYSTEM.
======================= First Aid Measures =======================
Eyes:FLUSH WITH WATER AT LEAST 15 MINUTES,UNTIL IRRITATION
SUBSIDES.IF IRRITATION PERSISTS CALL A PHYSICIAN.SKIN:WASH
THOROUGHLY WITH SOAP AND WATER.INGESTION:CALL PHYSICIAN
IMMEDIATELY,DO NOT INDUCE VOMITING.INHALATION:REMOVE TO FRESH
AIR;IF OVERCOME,CALL PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:FOAM,DRY CHEMICALS,CO*2,WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .COOL EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:USED CONTAINERS RETAIN RESIDUES.DO NOT
PRESSURIZE,CUT,WELD OR EXPOSE CONTAINERS TO
HEAT,FLAME,SPARKS.HAZARDOUS DECOMP
PRODUCTS:FUMES,SMOKE,CO,ALDEHYDES.
================== Accidental Release Measures ==================
Spill Release Procedures:SHUT OFF ELECTRICITY & ELIMINATE ALL IGNITION
SOURCES.RECOVER FREE LIQUID.ADD SUITABLE ABSORBENT TO SPILL
AREA.KEEP PRODUCT OUT OF SEWERS AND WATERCOURSES.
Neutralizing Agent:N/K
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN
USE.DO NOT HANDLE OR STORE NEAR HEAT,SPARKS,OR STRONG OXIDIZERS.USE
ONLY WITH ADEQUATE VENTILATION.
Other Precautions:GROUND PRODUCT TRANSFER SYSTEM TO PREVENT FIRE OR
EXPLOSION RISK FROM STATIC ACCUMULATION AND DISCHARGE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:N/K
Work Hygienic Practices:MINIMIZE BREATHING VAPOR OR MIST.
Supplemental Safety and Health
BP RANGE:315-348F,157-176C.VP:<10 @ 25C,77F.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:SEE SUPP
Decomp Temp:Decomp Text:N/K
Vapor Pres:SEE SUPP
Vapor Density:5.0,AIR=1
Spec Gravity:0.75 (WATER=1)
Evaporation Rate & Reference:N/K
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK MOBILE LIQUID,PARAFFINIC HYDROCARBON ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,LIQUID CHLORINE,CONCENTRATED OXYGEN.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:FUMES,SMOKE,CARBON MONOXIDE,ALDEHYDES.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .COMBUSTIBLE PRODUCT.DISPOSE OF
MATERIAL IN APPROVED DISPOSAL SITE.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|