=====================  Product Identification  =====================

MSDS NAME:BLACK CONDUCTIVE COATING, 463060014
NIIN:01-087-1397
Kit Part:Y
MSDS Number: BJFRM
=== Responsible Party ===
Company:AKZO COATINGS INC
Address:434 W MEATS AVE
City:ORANGE
State:CA
ZIP:92665
Country:US
Info Phone Num:213-855-7313  (AFTER HOURS)
Emergency Phone Num:213-589-3660  (8:00A.M.-4:15P.M.)
CAGE:98502
=== Contractor Identification ===
Company:AKZO COATINGS INC
Address:434 W. MEATS STREET
Box:City:ORANGE
State:CA
ZIP:92661
Country:US
Phone:714-637-1750; CHEMTREC 800-424-9300
CAGE:98502
Company:BOEING HELICOPTERS, DIV OF THE BOEING CO
Address:BOEING CENTER, INDUSTRIAL HWY BLDG 3-25
Box:City:RIDLEY PARK
State:PA
ZIP:19078
Country:US
Phone:215-591-3010
CAGE:77272

=============  Composition/Information on Ingredients  =============

Name:N-BUTYL ALCOHOL  (SARA III)
CAS:71-36-3
RTECS #:EO1400000
Fraction by Wt: 2.5%
OSHA PEL:100 PPM
ACGIH TLV:S, C 50 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 5-20%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3; 9192

Name:CYCLOHEXANONE  (SARA III)
CAS:108-94-1
RTECS #:GW1050000
Fraction by Wt: <5%
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Name:CALCIUM CHROMATE  (SARA III)
CAS:13765-19-0
RTECS #:GB2750000
Fraction by Wt: 8.8%
OSHA PEL:0.05 MG CR/M3
ACGIH TLV:0.001 MG/M3;A2, 9394
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS

Name:METHYL ETHYL KETONE (2-BUTANONE) (MEK)  (SARA III)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 31.3%
OSHA PEL:200 PPM/300 STEL
ACGIH TLV:200 PPM/300STEL 9192
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Name:METHYL ISOBUTYL KETONE  (SARA III)
CAS:108-10-1
RTECS #:SA9275000
Fraction by Wt: 5.9%
OSHA PEL:100 PPM/75 STEL
ACGIH TLV:50 PPM/75 STEL; 9293
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Name:XYLENES (O-,M-,P- ISOMERS)	(SARA III)
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 22.6%
OSHA PEL:100 PPM/150 STEL
ACGIH TLV:100 PPM/150STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRIT,CNTCT MAY CAUSE EYE
    BURNS/CORNEAL INJURY,SEVERE IRRIT,REDNESS,TEARING,BLURRED
    VIS.EXCESSIVE INHAL VAP CAN CAUSE NASAL/RESP
    IRRIT,DIZZ,WEAKNESS,FATIGUE,NAUSEA,HDACHE,SHORTNESS OF BRTH,P OSS
    UNCON,& ASPHY.MILD SKIN IRRIT,MAY CAUSE BURNS.INGEST:GI
    IRRIT,NAUSEA,VOMIT,DIARRHEA,DEPRESS.(SEE SIGNS & SYMPTOMS)
Explanation of Carcinogenicity:INGRED #4:LISTED BY IARC/NTP AS HUMAN
    CARCIN.ACGIH RECOM HNDLNG AS POTNTL HUMAN CARCIN.IARC LIST INGRED
    #2 AS CARCIN.
Effects of Overexposure:DRY PIGMNT MAY CAUSE NUISANCE DUST,CAN BE IRRIT
    TO RESP SYS.VAP & FUMES MAY BE IRRIT TO UPPER RESP TRACT.CAN BE
    ABSORBED THROUGH SKIN,ASPIRATION INTO LUNGS CAN CAUSE CHEM PNEUM &
    CAN BE FATAL.CHRONIC: EYE DAMAGE.LIVER & KIDNEY DAMAGE.CARDIAC
    ABNORMALITIES.ANEMIC CONDITION.
Medical Cond Aggravated by Exposure:NONE EXPECTED.

=======================  First Aid Measures  =======================

First Aid:INHAL:MOVE TO FRESH AIR, GIVE ART RESP IF NECESSARY.
    SKIN:WASH W/SOAP & WATER. EYE:FLUSH W/WATER AT LEAST 15 MIN, GET
    MD. INGEST:DRINK ONE OR TWO GLASSES OF WATER TO DILUTE. DO NOT
    INDUCE VOMIT. GET M D OR POISON CONTROL CENTER IMMEDIATELY.TREAT
    SYMPTOMATICALLY.

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.0
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS
Fire Fighting Procedures:WATER MAY BE INEFCTIVE.WATER SHOULD BE USED TO
    COOL CONTRS EXPSD TO FIRE.FIRE FIGHTING PERSONNEL SHOULD WEAR
    NIOSH/MSHA APPROVED SCBA AND FULL PROT EQUIPMENT.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY
    CLSD.ISOLATE/HEAT,SPRKS,ELEC EQUIP & OPEN FLAME.CLOSED CONTRS MAY
    EXPLODE WHEN EXPSD TO EXTREME HEAT.DECOMP PROD MAY CAUSE HEALTH
    HAZARD.

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
    BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT.
    REFER TO PROTECTIVE MEASURES LISTED THROUGHOUT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE CONTRS OUT OF SUN & AWAY FROM
    HEAT,SPARKS & OPEN FLAMES. CLOSE CONTRS AFTER EACH USE. CONSULT
    NFPA CODE FOR ADDITIONAL STORAGE REQUIREMENTS.
Other Precautions:DO NOT TAKE INTERNALLY.USE APPROVED BONDING &
    GROUNDING PROCEDURES.OBSERVE LABEL PRECAUTIONS.KEEP CLOSURES TIGHT
    AND CONTR UPRIGHT TO PREVENT LEAKAGE.NEVER USE PRESSURE TO
    EMPTY.AVOID BREATHING DUST.D O NOT WELD OR FLAME CUT EMPTY DRUM.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:ADEQUATE VENTILATION IS REQUIRED.USE NIOSH/MSHA
    APPROVED RESPIRATOR DEVICE.SEE SAFETY EQUIP SUPPLIER FOR EVALUATION
    & RECOMMENDATION.IN CONFINED AREAS, USE NIOSH/MSHA APPROVED AIRLINE
    RESPIRATOR OR HO OD.
Ventilation:SUFFICIENT TO KEEP VAP CONC BELOW TLV & LEL.FOR BAKING
    FINISHES,EXHAUST VAPORS.REMOVE DECOMP PROD FORMED DURING WELDING.
Protective Gloves:REFER TO SAFETY EQUIPMENT SUPPLIER.
Eye Protection:CHEM WORKERS GOGG,FACESHIELD OPTL.
Other Protective Equipment:EYE BATH & SHOWER.CHEM RESISTANT APRON,BOOTS
    OR OTHER CLOTHING TO AVOID REPEATED OR FREQUENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
    WASHROOM.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
    CONTENTS MAY BE HARMFUL OR FATAL.REPORTS HAVE ASSOCIATED REPEATED &
    PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN &
     NERVOUS SYSTEM DAMAGE.DO NOT HANDLE UNTIL MANUFACTURERS SAFETY
    PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:175F,79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.986
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID, PAINT
Percent Volatiles by Volume:78.8

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
    SMOKE, OXIDES OF NITROGEN.

====================  Disposal Considerations  ====================

Waste Disposal Methods:INCINERATE IN AN APPROVED FACILITY, DO NOT
    INCINERATE CLOSED CONTAINERS. DISPOSE I/A/W FEDERAL, STATE AND
    LOCAL POLLUTION CONTROL REQUIREMENTS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***