Material Safety Data Sheet
Date last revised: April, 2001
I. GENERAL INFORMATION
Chemical Name & Synonyms Trade Name & Synonyms
PIGMENTED POLYSULFIDE POLYMER SYNTHACALK GC-2+ BASE (PART B)
Chemical Family Formula
POLYSULFIDE SEALANT MIXTURE
Proper DOT Shipping DOT Hazard Classification
CAULKING COMPOUND N/A
Manufacturer Manufacturer鈥檚 Phone Number
PECORA CORPORATION 215-723-6051
Manufacturer鈥檚 Address Chemtrec Phone Number
165 Wambold Road, Harleysville, PA 19438 800-424-9300
II. INGREDIENTS
Principal Hazardous Components Percent Threshold Limit Value (Units)
(ACGIH-TLV) 10mg/m3 Tot. dust
CALCIUM CARBONATE (CAS # 471-34-1) 10-20
(OSHA-PEL) 15 mg/m3 Resp. dust
(ACGIH-TLV) 2 mg/m3 Tot. dust
CALCINED KAOLIN (CAS # 66402-68-4) 5-10
(OSHA-PEL) 5 mg/m3 Resp. dust
(ACGIH-TLV) 10 mg/m3
1-5
Titanium Dioxide (CAS # 13463-67-7)
(OSHA-PEL) 10 mg/m3
Below Reportable Levels (PROPRIETARY) BALANCE
III. PHYSICAL DATA
Boiling Point (oF) Specific Gravity (H20 = 1)
UNKNOWN 1.7
Vapor Pressure (mm Hg.) Percent Volatile by Volume (%)
NOT ESTABLISHED % NON-VOL (W/W) 100
Vapor Density (Air = 1) Evaporation Rate (______= 1)
NOT ESTABLISHED NOT ESTABLISHED
p
Solubility in Water H
INSOLUBLE NA
Appearance & Odor
VISCOUS OFF-WHITE PASTE. MILD, SULFUR ODOR
IV. FIRE & EXPLOSION HAZARD DATA
Flash Point (Test Method) Auto Ignition Temperature
> 200oF (93.3 0C) NOT ESTABLISHED
Flammable Limits LEL NOT ESTABLISHED UEL NOT ESTABLISHED
NOT ESTABLISHED
Extinguishing Media Small Fires: DRY CHEMICALS, CARBON DIOXIDE, WATER SPRAY, OR FOAM.
Large Fires: WATER SPRAY, FOG, OR ALCOHOL FOAM.
Special Fire Fighting Procedures: FIRE FIGHTERS / OTHERS EXPOSED TO PRODUCTS OC COMBUSTION SHOULD BE
EQUIPPED WITH NIOSH- APPROVED POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA) AND
FULL PROTECTIVE CLOTHING.
Unusual Fire & Explosion Hazards: DURING A FIRE, IRRITATING AND HIGHLY TOXIC GASES MAY BE GENERATED
DURING COMBUSTION OR DECOMPOSITION. SMOKE, SOOT, ANT TOXIC / IRRITATING FUMES (i.e.: CARBON
DIOXIDE, CARBON MONOXIDE, FORMALDEHYDE, AND / OR OTHER ALDEHYDES. HYDROGEN SULFIDE, OXIDES
OF SULFUR. LOW MOLECULAR WEIGHT HYDROCARBONS.
-Page 2 - SYNTHACALK GC-2+ (PART B)
V. Health Hazard Data
OSHA Permissible Exposure Limit ACGIH Threshold Limit Value
SEE SECTION II SEE SECTION II
Carcinogen 鈥? NTP Program ACGIH Carcinogen 鈥? IARC Program OSHA
NO NO NO NO
Symptoms of Exposure:
HAZARD RATING: (HMIS) HEALTH 鈥? 1* FLAMMABILITY =1 REACTIVITY = 1
*= CHRONIC (NFPA) HEALTH 鈥? 1 FLAMMABILITY =1 REACTIVITY = 1
Medical Conditions Aggravated By Exposure: EMERGENCY OVERVIEW: MAY CAUSE EYE IRRITATION. DO NOT
SWALLOW. PHYSICIANS: TREATMENT SHOULD BE DIRECTED AT PREVENTING ABSORPTION, ADMINISTERING
TO SYMPTOMS, AND PROVIDING SUPPORTIVE THERAPY.
Primary Route (s) of Entry: EYES, SKIN, NOSE, AND THROAT
Emergency First Aid: EYE CONTACT: IMMEDIATELY FLUSH EYES WITH WATER FOR 15 MINUTES. GET IMMEDIATE
MEDICAL ATTENTION IF IRRITATION PERSISTS. SKIN CONTACT: FLUSH WITH WATER, REMOVE CONTAMINATED
CLOTHING. INHALATION: IF OVER EXPOSED, GET MEDICAL ATTENTION. INGESTION: IMMEDIATELY INDUCE
VOMITING, GET MEDICAL ATTENTION.
VI. REACTIVITY DATA
Stability Unstable Conditions to Avoid:
Incompatibility Stable Conditions to Avoid: HIGH TEMPERATURES
x
Materials To Avoid:
OXIDIZING AGENTS, ACIDS AND STRONG BASES
Hazardous May Occur Conditions to Avoid:
Polymerization x Will Not Occur Conditions to Avoid: HIGH TEMPERATURES, ULTRAVIOLET LIGHT
AND/OR SUNLIGHT
Hazardous Decomposition Products: INCOMPATIBILITY WITH OTHER MATERIALS: OXIDIZERS, REDUCERS AND
STRONG BASES AND ACIDS.
VII. ENVIRONMENTAL PROTECTION PROCEDURES
Spill Response: SCRAPE UP AND CLEAN AREA WITH XYLENE OR MEK, AND PLACE IN APPROVED WASTE
CONTAINER. SOLVENTS MENTIONED ARE TOXIC AND FLAMMABLE. FOLLOW ALL SOLVENT MANUFACTURER鈥橲
PRECAUTIONS.
Waste Disposal Method: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
VIII. SPECIAL PROTECTION INFORMATION
Eye Protection Skin Protection
SAFETY GLASSES OR GOGGLES IMPERMEABLE GLOVES
Respiratory Protection (Specific Type) Ventilation Recommended
ORGANIC VAPOR RESPIRATOR LOCAL OR MECHANICAL EXHAUST
Other Protection: BARRIER SKIN CREAM.
IX. SPECIAL PRECAUTIONS
Hygienic Practices In Handling & Storage: HYGIENE: WASH THOROUGHLY AFTER HANDLING, ESPECIALLY BEFORE
EATING, DRINKING, SMOKING, OR USING RESTROOM FACILITIES. STORAGE: STORE IN COOL, DRY WELL
VENTILATED AREA AWAY FROM HEAT, IGNITION SOURCES, AND DIRECT SUNLIGHT.
Precautions For Repair & Maintenance of Contaminated Equipment: CONTAMINATED CLOTHING SHOULD BE
PROFESSIONALLY LAUNDERED. SEE SECTION V
Other Precautions: AVOID PROLONGED CONTACT WITH SKIN AND BREATHING OF VAPORS. USE WITH ADEQUATE
VENTILATION. ALSO SEE PRECAUTIONS ON MSDS SHEET FOR SYNTHANCALK GC-2+ ACTIVATOR (PART A)
KEEP OUT OF REACH OF CHIIDREN!!!!!!!!
-PAGE 3 鈥? SYNTHACALK GC-2+ BASE (PART B)
X. REGULATORY INFORMATION
Federal: This product is considered hazardous under the OSHA Hazard Communication Standard (29 CFR 1910.1200)
Sara Title III 鈥? Section 311/312 鈥? Hazard Categories:
NO 鈥? Fire Hazard
NO 鈥? Sudden Release of Pressure Hazard
NO - Reactivity Hazard
YES 鈥? Immediate (acute) Health Hazard
YES 鈥? Delayed (chronic) Health Hazard
Ozone 鈥? Depleting Chemicals 鈥? No regulated ingredients
Sara Section 302 鈥? Extremely Hazardous Materials 鈥? No regulated ingredients
Sara Section 313 鈥? Toxic Chemical 鈥? No regulated ingredients.
Chemical Listing: Listed on the Country鈥檚 Chemical Inventories: Toxic Substance Control Act
United States: Chemical components in this product are on the section 8 (b)
Chemical Substance Inventory List (40 CFR 710)
State Right-To-Know:
Pennsylvania 鈥? New Jersey R-T-K CAS # %
Chlorinated paraffin wax 63449-39-8 20-30
Calcium carbonate 471-34-1 10-20
Calcined Kaolin 66402-68-4 5-10
Titanium Dioxide 13463-67-7 1-5
Non-hazardous trade secret ingredients 鈥? Proprietary balance
California Preposition 65:
Warning: This product contains a chemical (s) known to the state of California to cause Cancer.
Formaldehyde cancer hazard CAS # 50-000-0 % (trace)*
*Trace= present at less than 0.01 percent.
CONEG-No data available
Canada: This is a 鈥渃ontrolled product鈥? under the Canadian workplace Hazardous Materials Information System (WHMIS).
Class D division 2 Sub-division B
CEPA-NPRI-No regulated ingredients.
|