Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 133MA ANTI-SEIZE LUBRICANT 8.5OZ AE
Item No: 81464
Product Type: Aerosol lubricant
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient Weight Percent ACGIH TLV: OSHA PEL:
500 ppm TWA; 2000 mg/m3 TWA
HEPTANE 35-45 400 ppm TWA; 500 ppm STEL
142-82-5
5mg/m3 TWA 5mg/m3 TWA
DISTILLATES (PETROLEUM), 5-15
HYDROTREATED HEAVY
PARAFFINIC
64742-54-7
1000 ppm TWA; 1800 mg/m3 TWA
PROPANE 5-15 1000 ppm TWA
74-98-6
800 ppm TWA; 1900 mg/m3 TWA
BUTANE 5-15 1000 ppm TWA
106-97-8
2 mg/m3 respir.dust
GRAPHITE 1-10 15 mppcf TWA
7782-42-5
TOLUENE <3 50 ppm TWA 200 ppm TWA; 300 ppm Ceiling
108-88-3
10 mg/m3 TWA 6 mg/m3 TWA
AMORPHOUS SILICA 0.5-5.0
7631-86-9
3. HAZARDS IDENTIFICATION
May cause eye, skin and respiratory irritation. Long term exposure to high concentrations of vapor may
Toxicity:
cause lung, liver or kidney damage. Intentional misuse by concentrating and inhaling the vapor may be
harmful or fatal. High concentrations may cause central nervous system (CNS) depression.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Excessive accidental exposure may cause headache, dizziness, nausea and mild respiratory irritation.
Signs and Symptoms of Exposure:
May cause redness to eyes and irritation to nasal passages.
Ingredient Weight NTP ACGIH Carcinogens IARC
Percent
TOLUENE <3 male rat-no evidence; A4 - Not Classifiable Group 3; Monograph 71,
108-88-3 female rat-no as a Human Monograph 47, 1989
evidence; male mice- Carcinogen
no, female mice-no
AMORPHOUS SILICA 0.5-5.0 Group 3 Monograph 68, 1997
7631-86-9
Persons with preexisting respiratory, liver, kidney, eye or skin diseases may be adversely affected.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
Do not induce vomiting. Slowly dilute with 1-2 glasses of water or milk and seek medical attention. Never
Ingestion:
give anything by mouth to an unconscious person.
Move to fresh air in case of accidental inhalation of vapours. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
Flammable aerosol per flame projection
Flash Point (掳F/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
1 of 3
Product Name: 133MA ANTI-SEIZE LUBRICANT 8.5OZ Item No: 81464
AE
5. FIRE FIGHTING MEASURES
Firefighters should wear self-contained breathing apparatus. Keep
Special Fire-Fighting Procedures:
containers cool. Use equipment or shielding required to protect against
bursting or venting of containers. Water spray may be ineffective on flames
but should be used to keep fire-exposed containers cool.
Oxides of carbon
Hazardous Products of Combustion:
Contents under pressure. Exposure to temperatures over 120 degrees F.
Unusual Fire/Explosion Hazards:
may cause bursting or venting. Use equipment or shielding to protect
personnel from bursting containers.
1.0
Lower Explosive Limit:
9.5
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 120 degrees F.
Storage:
Exposure to high temperatures may cause container to burst.
Do not use near heat, sparks or open flame. Vapors may accumulate readily and may ignite explosively.
Handling:
Avoid contact with skin and eyes. Avoid breathing vapors, if exposed to high vapor concentration, leave
area at once. Use only in a well ventilated area. Extinguish all flames, pilot lights and heaters. Turn off
stoves, electric tools and appliances, and other sources of ignition. Do not puncture or incinerate
container. Intentionally concentrating and inhaling the vapor may be harmful or fatal.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Gray liquid
Appearance:
Solvent
Odor:
<0掳F - 238掳F
Boiling Point:
Does not apply
pH:
Nil
Solubility in Water:
0.73
Specific Gravity:
64% by weight; 461 g/l
VOC Content(Wt.%):
Not Determined
Vapor Pressure:
>1 (air = 1)
Vapor Density (Air=1):
Faster than ether
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
Strong oxidizers
Incompatabilities:
Keep away from heat, sparks and open flame. - No smoking
Conditions to Avoid:
Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
2 of 3
Product Name: 133MA ANTI-SEIZE LUBRICANT 8.5OZ Item No: 81464
AE
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations. This container may be
recycled in aerosol recycling centers. Before offering for recycling, empty the can by using the product
according to the label. If recycling is not available, wrap the container and discard in the trash.
D001 as per 40CFR 261.21
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
CONSUMER COMMODITY
DOT Shipping Name:
ORM-D
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
Consumer Commodity (Not more than 1 liter)
Proper Shipping Name:
Class 9
Class or Division:
ID 8000
UN/NA Number:
IMDG
Aerosols, Limited Quantity
Proper Shipping:
Class 2.1
Hazard Class:
UN 1950
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
TOLUENE
CALIFORNIA PROP 65:
WARNING: This product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive
harm.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 4 , REACTIVITY 1
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 4, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: February/05/2007
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 3
Company: Revision
Number:
3 of 3
|