The MSDS format adheres to the standards and regulatory requirements
of the United States and may not meet regulatory requirements
in other countries.
DuPont Page 1
Material Safety Data Sheet
----------------------------------------------------------------------
MicroPlanar(R) CMP3510
EPM00092 Revised 29-MAY-2008
----------------------------------------------------------------------
----------------------------------------------------------------------
CHEMICAL PRODUCT/COMPANY IDENTIFICATION
----------------------------------------------------------------------
Product Use
Tungsten Redox Agent
Tradenames and Synonyms (Remarks)
MicroPlanar(R) is a registered trademark of EKC
Technologies, Inc licensed to DuPont Air Products
Nanomaterials L.L.C.
Company Identification
MANUFACTURER/DISTRIBUTOR
DuPont Air Products NanoMaterials L.L.C.
2441 W.Erie Dr.
Tempe
AZ
United States
85282
PHONE NUMBERS
Product Information : (800)441-7515(outside U.S. 302-774-1000)
Transport Emergency : (800)424-9300(outside U.S. 703-527-3887)
Medical Emergency : (800)441-3637(outside U.S. 302-774-1000)
----------------------------------------------------------------------
COMPOSITION/INFORMATION ON INGREDIENTS
----------------------------------------------------------------------
Components
Material CAS Number %
Periodic Acid 10450-60-9 5-15
Water 7732-18-5 >80
Potential decomposition products:
Iodine 7553-56-2
----------------------------------------------------------------------
HAZARDS IDENTIFICATION
----------------------------------------------------------------------
Emergency Overview
Clear liquid with no odor. Oxidizer. Contact with other
materials may cause fire. Causes burns to eyes and skin.
Inhalation of vapors causes irritation of the upper
respiratory tract.
EPM00092 DuPont Page 2
Material Safety Data Sheet
(HAZARDS IDENTIFICATION - Continued)
Potential Health Effects
INHALATION
Causes irritation.
EYE CONTACT
Causes burns.
SKIN CONTACT
Causes burns.
INGESTION
May cause gastrointestinal irritation.
TARGET ORGANS
Eyes, skin, gastrointestinal system, and respiratory tract.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
Overexposure may aggravate existing respiratory conditions
or dermatitis.
POTENTIAL ENVIRONMENTAL EFFECTS
No adverse effects have been noted.
Carcinogenicity Information
None of the components present in this material at concentrations
equal to or greater than 0.1% are listed by IARC, NTP, OSHA or ACGIH
as a carcinogen.
----------------------------------------------------------------------
FIRST AID MEASURES
----------------------------------------------------------------------
First Aid
INHALATION
If inhaled, remove to fresh air. If not breathing, give
artificial respiration. If breathing is difficult, give oxygen.
Call a physician.
SKIN CONTACT
In case of contact, immediately flush skin with plenty of water
for at least 15 minutes, while removing contaminated clothing and
shoes. Call a physician. Wash contaminated clothing before reuse.
EYE CONTACT
In case of contact, immediately flush eyes with plenty of water
for at least 15 minutes. Call a physician.
INGESTION
EPM00092 DuPont Page 3
Material Safety Data Sheet
(FIRST AID MEASURES - Continued)
If swallowed, do not induce vomiting. Immediately give 2 glasses
of water. Never give anything by mouth to an unconscious person.
Call a physician.
Notes to Physicians
Treat symptomatically as indicated by the condition of the
patient.
----------------------------------------------------------------------
FIRE FIGHTING MEASURES
----------------------------------------------------------------------
Flammable Properties
Flash Point : Not Applicable
Autoignition : Not Available
Flammable limits in Air, % by Volume
LEL : Not Applicable
UEL : Not Applicable
Unusual Fire and Explosion Hazards
Contact with reducing agents, wood, paper, or other
combustibles can cause fire.
Hazardous Combustion Products
Burning may produce toxic iodine vapors.
Do not use carbon dioxide or other gas-filled fire
extinguishers. Flood with water or use a water fog.
Extinguishing Media
Deluge with water.
Fire Fighting Instructions
Evacuate personnel to a safe area. Wear self-contained breathing
apparatus (SCBA) and full protective equipment. Flood with water.
----------------------------------------------------------------------
ACCIDENTAL RELEASE MEASURES
----------------------------------------------------------------------
Safeguards (Personnel)
NOTE: Review FIRE FIGHTING MEASURES and HANDLING (PERSONNEL)
sections before proceeding with clean-up. Use appropriate
PERSONAL PROTECTIVE EQUIPMENT during clean-up.
Spill Clean Up
Soak up with sawdust, sand, oil dry or other absorbent material.
Dispose of in an approved container. Comply with Federal, State,
and local regulations for reporting releases.
EPM00092 DuPont Page 4
Material Safety Data Sheet
----------------------------------------------------------------------
HANDLING AND STORAGE
----------------------------------------------------------------------
Handling (Personnel)
Avoid contact with eyes, skin or clothing. Use with sufficient
ventilation to keep employee exposure below recommended limits.
Wash thoroughly after handling. Wash clothing after use.
Handling (Physical Aspects)
Keep container tightly closed.
Storage
Store in original container. Store in a cool, dry,
well-ventilated area. Store between 40-90 F (4-32 C).
----------------------------------------------------------------------
EXPOSURE CONTROLS/PERSONAL PROTECTION
----------------------------------------------------------------------
Engineering Controls
Use only with adequate ventilation.
Personal Protective Equipment
RESPIRATORY PROTECTION
No respiratory protection is required when this material is
handled under proper ventilation, such as a wet bench or
fume hood. If proper ventilation is not available or when in
doubt of the atmospheric concentration, use a supplied air
respirator. Consult 29 CFR 1910.134 regarding use of
respirators.
PROTECTIVE CLOTHING
Take all precautions to prevent skin contact. Wear Nitrile,
Neoprene or Latex clothing and gloves, and chemical
resistant boots when there is a probability of liquid
contact.
EYE/FACE PROTECTION
Use chemical goggles.
Exposure Guidelines
Applicable Exposure Limits
Iodine
PEL (OSHA) : 0.1 ppm, 1 mg/m3, Ceiling
TLV (ACGIH) : Ceiling 0.1 ppm, 1.0 mg/m3, Notice of
Intended Changes (2007)
EPM00092 DuPont Page 5
Material Safety Data Sheet
(Applicable Exposure Limits - Continued)
0.01 ppm, A4, 8 Hr. TWA
STEL 0.1 A4
Notice of Intended Changes (2007)
Iodides
0.1 mg/m3, 8 Hr. TWA, A4
AEL * (DuPont) : None Established
* AEL is DuPont鈥檚 Acceptable Exposure Limit. Where governmentally
imposed occupational exposure limits which are lower than the AEL
are in effect, such limits shall take precedence.
----------------------------------------------------------------------
PHYSICAL AND CHEMICAL PROPERTIES
----------------------------------------------------------------------
Physical Data
Boiling Point : 212 F (100 C)
Vapor Pressure : Not Available
Vapor Density : >1 (Air=1.0)
Evaporation Rate : Not Available
Solubility in Water : Not Available
pH : 0.9-1.1
Odor : None.
Color : Clear.
Specific Gravity : 1.05-1.08 @ 25 C (77 F)
Form : Liquid.
----------------------------------------------------------------------
STABILITY AND REACTIVITY
----------------------------------------------------------------------
Chemical Stability
Stable at normal temperatures and storage conditions.
Incompatibility with Other Materials
Reducing agents, wood, and paper.
Decomposition
Decomposition Products: Iodine vapors
Polymerization
Will not normally occur.
EPM00092 DuPont Page 6
Material Safety Data Sheet
----------------------------------------------------------------------
TOXICOLOGICAL INFORMATION
----------------------------------------------------------------------
Animal Data
INHALATION
No information available.
EYE CONTACT
No information available.
SKIN CONTACT
LD50, rabbit: >2000 mg/kg, not harmful.
Considered corrosive from in vitro assay results.
INGESTION
LD50, rabbit: >2000 mg/kg, not harmful. Causes irritation.
GENOTOXICITY
Not mutagenic in bacterial cells in culture.
TARGET ORGANS
Eyes, skin, gastrointestinal tract, and respiratory tract.
----------------------------------------------------------------------
ECOLOGICAL INFORMATION
----------------------------------------------------------------------
Ecotoxicological Information
No information is available.
Aquatic Toxicity
Not expected to be harmful if adequate pH is maintained.
Fate
Expected to react readily with organic matter in soil and
water. Will leach readily in soil. Not expected to
evaporate from water or bioconcentrate in aquatic organisms.
----------------------------------------------------------------------
DISPOSAL CONSIDERATIONS
----------------------------------------------------------------------
Waste Disposal
Treatment, storage, transportation, and disposal must be in
accordance with applicable Federal, State/Provincial, and Local
regulations.
Incineration at a facility with proper Federal and State
issued permits is the recommended method for disposal.
Container Disposal
Observe all label warnings. Empty containers may contain
hazardous residue. Refer to applicable Local, State/Provincial,
and Federal Regulations, as well as industry Standards.
EPM00092 DuPont Page 7
Material Safety Data Sheet
(DISPOSAL CONSIDERATIONS - Continued)
Do not distribute, make available, or reuse empty containers
except for storage and shipment of original product. Remove
all hazardous product residue, and puncture or otherwise
destroy empty containers before disposal. Consult 40 CFR,
Parts 261 and 268 for guidance on disposal.
----------------------------------------------------------------------
TRANSPORTATION INFORMATION
----------------------------------------------------------------------
Shipping Information
DOT/IMO/IATA
UN No. : UN 3264
Proper Shipping Name : Corrosive Liquid, Acidic, Inorganic,
N.O.S
(Contains Periodic Acid)
Hazard Class :8
Packing Group : III
----------------------------------------------------------------------
REGULATORY INFORMATION
----------------------------------------------------------------------
U.S. Federal Regulations
This product complies with TSCA inventory reporting requirements.
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION
ACT)
311/312 Hazard Categories: Acute, Reactive
313: This product contains substances which are subject
to the report requirements of Section 313 of the
Emergency Planning and Community Right-To-Know Act of 1986
and of 40 CFR 372.
CERCLA (COMPREHENSIVE RESPONSE COMPENSATION AND LIABILITY
ACT)
Not reportable.
We recommend you contact local authorities to determine if
there may be other local reporting requirements.
----------------------------------------------------------------------
OTHER INFORMATION
----------------------------------------------------------------------
# NFPA, NPCA-HMIS
NFPA Rating
Health :1
Flammability :0
Reactivity :0
EPM00092 DuPont Page 8
Material Safety Data Sheet
(Continued)
Specific Hazard : Oxidizer
Additional Information
This material is for industrial use. Use only
under the supervision of a technically qualified indiviual.
----------------------------------------------------------------------
The data in this Material Safety Data Sheet relates only to the
specific material designated herein and does not relate to use in
combination with any other material or in any process.
Responsibility for MSDS : MSDS Coordinator
Telephone : (757)686-8663 OR (919)248-5027
# Indicates updated section.
This information is based upon technical information believed to be
reliable. It is subject to revision as additional knowledge and
experience is gained.
End of MSDS
|