Anderson & Associates, LLC
830 Morris Turnpike 鈥? Short Hills, NJ 07078
Toll Free: 800 678-3024
Web site: www.andisil.com
Phone: 908 273-8015 鈥? Fax: 908 273-8056
email: info@andisil.com
We鈥檝e got the right chemistry
MATERIAL SAFETY DATA SHEET Product Name: ANDISIL 2827-186L FLUID
SECTION I 鈥? PRODUCT IDENTIFICATION
MANUFACTURER:
Information Phone: (908) 273-8015
Anderson & Associates, LLC
830 Morris Turnpike Emergency Phone : (888) 234-1395
Short Hills, NJ 07078
CHEMTREC EMERGENCY No.: (800) 424-9300
PRODUCT NAME: ANDISIL 2827-186L FLUID
SECTION II 鈥? HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
INGREDIENTS: CAS # EXPOSURE LIMITS
1,3-Divinyltetramethyl disiloxane 2627-95-4 None Established.
Comments: The above ingredients are hazardous as defined in 29 CFR 1910.1200
SECTION III 鈥? PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING POINT: 139掳C SPECIFIC GRAVITY: 0.81 @ 25掳C
VAPOR PRESSURE (psi): NA* MELTING POINT: NA
VAPOR DENSITY (AIR = 1): NA EVAPORATION RATE (Butyl Acetate = 1): <1
SOLUBILITY IN WATER: Negligible
APPEARANCE AND ODOR: Clear, colorless liquid.
SECTION IV 鈥? FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: 66掳F/19掳C FLAMMABLE LIMITS: NA
(ASTM D-3278) LEL: NA UEL: NA
EXTINGUISHING MEDIA: Carbon dioxide, Sand, Foam, or Dry Chemicals.
Water can be used to lower the temperature of fire-exposed containers.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should wear full protective clothing, including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Do not mix with strong oxidants. Vapors are heavier than air and can travel along the ground
to remote ignition source(s). Static electricity may accumulate and ignite vapors. Prevent a possible fire hazard by suitable means, such as,
grounding, inert gas purge, vapor dilution, and the like.
SECTION V 鈥? REACTIVITY DATA
STABILITY: Stable
CONDITIONS TO AVOID: NONE
INCOMPATIBILITY (Materials to avoid): Strong oxidants such as chlorine, oxygen, sodium or calcium hypochlorite.
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: See above on exposure to air at elevated temperatures which can evolve formaldehyde.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
SECTION VI 鈥? HEALTH HAZARD DATA
ROUTES OF ENTRY: INHALATION: YES SKIN: YES INGESTION: YES
HEALTH HAZARDS (acute & chronic): Product may be harmful if inhaled but toxicity of this material has not been determined. Skin irritation is
not expected, but may occur in some individuals. Product may cause mild eye irritation.
CARCINOGENICITY: NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
SIGNS AND SYMPTOMS OF EXPOSURE: Direct eye contact may cause temporary discomfort with mild redness and dryness similar to wind-
burn. Small amounts of the product transferred to the mouth by fingers during use, etc., should not injure. Swallowing large amounts of the
product may cause digestive discomfort.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: None known
Continued on reverse
*NA throughout this document represents 鈥淣ot Applicable鈥?.
Continued from reverse
EMERGENCY AND FIRST AID PROCEDURES: Eye contamination is treated by immediately flushing with water. No first aid is
needed for skin, inhalation or oral contact or contamination.
SECTION VII 鈥? PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Cover spill with an absorbent material such as sand or
sawdust. Scoop up and place in an appropriately marked container for disposal.
WASTE DISPOSAL METHOD: May be incinerated under conditions complying with Federal, State, and Local environmental
control regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: No special precautions.
OTHER PRECAUTIONS: None
SECTION VIII 鈥? CONTROL MEASURES
RESPIRATORY PROTECTION: Organic vapor canister or supplied air respirator in enclosed areas.
VENTILATION: LOCAL EXHAUST: 60 fpm face velocity SPECIAL: NA MECHANICAL: Acceptable OTHER: NA
PROTECTIVE GLOVES: Rubber/Chem. gloves required. EYE PROTECTION: Safety Goggles
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Rubber apron, eye wash fountain(s) & safety shower.
WORK and/or HYGIENIC PRACTICES: Always wash hands after handling chemicals and before eating or smoking. Do not smoke when work-
ing or handling chemicals.
PREPARED BY: MJN DATE: 12/02/02
|