P.O. Box 939 Alvin, TX 77512
13903 Highway 35 Danbury, TX 77534
(979) 922-1804 Fax (979) 922-1805
www.appliedgas.com
Material Safety Data Sheet
1/30/2008 24 Hour Emergency Phone Number : 1-800-535-5053
SECTION 1. - - - - - - - - - CHEMICAL IDENTIFICATION- - - - - - - - - -
NAME: 1-DODECENE
SECTION 2. - - - - - COMPOSITION/INFORMATION ON INGREDIENTS - - - - - -
CAS #: 112-41-4
MF: C12H24
ADDITIONAL INFORMATION
CONTAINS 2-ETHYL-1-DECENE, CHEMICAL ABSTRACTS REGISTRY
NUMBER 71138-64-2.
CONTAINS 2-BUTYL-1-OCTENE, CHEMICAL ABSTRACTS REGISTRY
NUMBER 5698-48-6.
CONTAINS DODECANE, CHEMICAL ABSTRACTS REGISTRY NUMBER 112-40-3.
SECTION 3. - - - - - - - - - - HAZARDS IDENTIFICATION - - - - - - - - -
LABEL PRECAUTIONARY STATEMENTS
HARMFUL
HARMFUL BY INHALATION AND IF SWALLOWED.
IRRITATING TO EYES, RESPIRATORY SYSTEM AND SKIN.
COMBUSTIBLE.
IN CASE OF CONTACT WITH EYES, RINSE IMMEDIATELY WITH PLENTY OF
WATER AND SEEK MEDICAL ADVICE.
WEAR SUITABLE PROTECTIVE CLOTHING.
SECTION 4. - - - - - - - - - - FIRST-AID MEASURES- - - - - - - - - - -
CONTAMINATION OF THE EYES SHOULD BE TREATED BY IMMEDIATE AND PROLONGED
IRRIGATION WITH COPIOUS AMOUNTS OF WATER.
IN CASE OF CONTACT, IMMEDIATELY WASH SKIN WITH SOAP AND COPIOUS
AMOUNTS OF WATER.
IF INHALED, REMOVE TO FRESH AIR. IF NOT BREATHING GIVE ARTIFICIAL
RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
IF SWALLOWED, WASH OUT MOUTH WITH WATER PROVIDED PERSON IS CONSCIOUS.
CALL A PHYSICIAN.
WASH CONTAMINATED CLOTHING BEFORE REUSE.
SECTION 5. - - - - - - - - - FIRE FIGHTING MEASURES - - - - - - - - - -
EXTINGUISHING MEDIA
CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE FOAM.
WATER SPRAY.
SPECIAL FIREFIGHTING PROCEDURES
WEAR SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE CLOTHING TO
PREVENT CONTACT WITH SKIN AND EYES.
COMBUSTIBLE LIQUID.
1 of 3
SECTION 6. - - - - - - - - ACCIDENTAL RELEASE MEASURES- - - - - - - - -
WEAR RESPIRATOR, CHEMICAL SAFETY GOGGLES, RUBBER BOOTS AND HEAVY
RUBBER GLOVES.
COVER WITH DRY LIME OR SODA ASH, PICK UP, KEEP IN A CLOSED CONTAINER
AND HOLD FOR WASTE DISPOSAL.
VENTILATE AREA AND WASH SPILL SITE AFTER MATERIAL PICKUP IS COMPLETE.
SECTION 7. - - - - - - - - - - HANDLING AND STORAGE- - - - - - - - - - -
REFER TO SECTION 8.
SECTION 8. - - - - - - EXPOSURE CONTROLS/PERSONAL PROTECTION- - - - - -
CHEMICAL SAFETY GOGGLES.
RUBBER GLOVES.
NIOSH/MSHA-APPROVED RESPIRATOR.
SAFETY SHOWER AND EYE BATH.
MECHANICAL EXHAUST REQUIRED.
AVOID CONTACT AND INHALATION.
AVOID PROLONGED OR REPEATED EXPOSURE.
WASH THOROUGHLY AFTER HANDLING.
IRRITANT.
KEEP CONTAINER CLOSED.
KEEP AWAY FROM HEAT AND OPEN FLAME.
STORE IN A COOL DRY PLACE.
SECTION 9. - - - - - - - PHYSICAL AND CHEMICAL PROPERTIES - - - - - - -
APPEARANCE AND ODOR
COLORLESS LIQUID
PHYSICAL PROPERTIES
BOILING POINT: 213 C
MELTING POINT: -35 C
FLASHPOINT 172 F
77C
EXPLOSION LIMITS IN AIR:
UPPER ~4.7%
LOWER ~0.4%
VAPOR PRESSURE: 0.2MM 20 C
SPECIFIC GRAVITY: 0.758
VAPOR DENSITY: 5.8
SECTION 10. - - - - - - - - -STABILITY AND REACTIVITY - - - - - - - - -
INCOMPATIBILITIES
BASES
OXIDIZING AGENTS
REDUCING AGENTS
HAZARDOUS COMBUSTION OR DECOMPOSITION PRODUCTS
TOXIC FUMES OF:
CARBON MONOXIDE, CARBON DIOXIDE
SECTION 11. - - - - - - - - - TOXICOLOGICAL INFORMATION - - - - - - - -
ACUTE EFFECTS
HARMFUL IF INHALED OR SWALLOWED.
2 of 3
CAUSES EYE AND SKIN IRRITATION.
MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND UPPER
RESPIRATORY TRACT.
TO THE BEST OF OUR KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
SECTION 12. - - - - - - - - - ECOLOGICAL INFORMATION - - - - - - - - - -
DATA NOT YET AVAILABLE.
SECTION 13. - - - - - - - - - DISPOSAL CONSIDERATIONS - - - - - - - - -
THIS COMBUSTIBLE MATERIAL MAY BE BURNED IN A CHEMICAL INCINERATOR
EQUIPPED WITH AN AFTERBURNER AND SCRUBBER.
OBSERVE ALL FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.
SECTION 14. - - - - - - - - - - TRANSPORT INFORMATION - - - - - - - - -
CONTACT APPLIED GAS FOR TRANSPORTATION INFORMATION.
SECTION 15. - - - - - - - - - REGULATORY INFORMATION - - - - - - - - - -
EUROPEAN INFORMATION
CAUTION: SUBSTANCE NOT YET FULLY TESTED.
R:20/22
HARMFUL BY INHALATION AND IF SWALLOWED.
R:36/37/38
IRRITATING TO EYES, RESPIRATORY SYSTEM AND SKIN.
S:26
IN CASE OF CONTACT WITH EYES, RINSE IMMEDIATELY WITH PLENTY OF
WATER AND SEEK MEDICAL ADVICE.
S:36
WEAR SUITABLE PROTECTIVE CLOTHING.
SECTION 16. - - - - - - - - - - OTHER INFORMATION- - - - - - - - - - - -
THE ABOVE INFORMATION IS BELIEVED TO BE CORRECT BUT DOES NOT PURPORT TO
BE ALL INCLUSIVE AND SHALL BE USED ONLY AS A GUIDE. THE ABOVE INFORMATION IS
DERIVED FROM THE SUPPLIER鈥橲 MSDS.APPLIED GAS, INC. SHALL NOT BE HELD LIABLE
FOR ANY DAMAGE ARISING OUT OF THE USE, MISUSE OR ABUSE OF THIS PRODUCT OR
MIXTURES OF THIS PRODUCT.
3 of 3
|