Material Safety Data Sheet TETRAHYDROFURFURYLAMINE
Quick Identifier
QO庐TETRAHYDROFURFURYLAMINE
May be used to comply with OSHA's Hazard Communication Standard,
Common Name (used on label and list)
29CFR 1910.1200. Standard must be consulted for specific requirements.
Section I
Emergency Telephone Number
Manufacturer's Name and Address
Penn Specialty Chemicals, Inc. 901-320-4092
3324 Chelsea Avenue HAZARD INFORMATION SERVICES:800-228-5635
Memphis, Tn 38108 (For Emergency Medical Information)
For Product Information and Other Calls:
Penn Specialty Chemicals, Inc.:877-895-7366
Effective: July 15, 2003 __
Supersedes: November 2, 1999
Section II-Hazardous Ingredients/ Identity Information
Hazardous Component(s) Chemical & Common Names(s) OSHA PEL ACGIH TLV CAS NO.
Tetrahydrofurfurylamine Not established Not established 4795-29-3
Section III-Physical/Chemical Characteristics
Boiling Point Vapor Density(Air=1) Specific Gravity (H20 = 1) Vapor Pressure (mm Hg)
307-309掳F, 153-154掳C 3.4 0.979 Not available
@ 750 mmHg
Solubility in Water Reactivity in Water
Complete Solution becomes basic.
Appearance and Color Melting Point/Freezing Point
Clear, colorless to yellow, mobile liquid. Not available
Ammoniacal-amine odor.
Section IV-Fire and Explosion Hazard Data
Flash Point Method Used Flammable Limits in Air, % Volume LEL Lower UEL Upper
113掳F, 45.掳C Setaflash 1.6 14.1
Auto-Ignition temperature Extinguisher Media
518掳F, 270掳C Water spray, dry chemical, carbon dioxide, 鈥渁lcohol鈥? foam
Special Fire Fighting Procedures
Firefighters should have eye protection and wear self-contained breathing apparatus
Use water spray to cool containers exposed to fire.
Unusual Fire and Explosion Hazards
See Section V below.
Section V-Physical Hazards/Reactivity Data
Stability Unstable Conditions to Avoid
High temperature: Under certain conditions ammonia gas may be
Stable X
generated.
Incompatibility (Materials to Avoid)
Oxidizers. Acids. Carbon dioxide.
Hazardous Decomposition Products
Combustion produces carbon dioxide and carbon monoxide.
Hazardous Polymerization May Occur Conditions to Avoid
Will Not Occur X
Page 2 of 2
TETRAHYDROFURFURYLAMINE
July 15, 2003
Section VI - Health Hazards
Chemical Listed as Carcinogen National Toxicology Yes IARC Monographs Yes OSHA Regulated Yes
or Potential Carcinogen No X No X No X
Signs and Symptoms
Exposure
Detectable odor
Acute Overexposure
Strong odor. Corrosive to skin, eyes and respiratory tract.
Chronic Overexposure
No data available.
Emergency and First Aid Procedures for Overexposure - Obtain prompt medical attention.
Inhalation
Move to fresh air. If necessary, restore and support breathing
Eyes
Immediately flush with water for 15 minutes while lifting eyelids and rolling eyes.
Get immediate medical attention.
Skin
Wash promptly with soap and water.
Ingestion
Get medical help. If conscious and medical help not readily available, give water.
Section VII - Special Precautions and Spill/Leak Procedures
Precautions to be taken in Handling and Storage
Store in a cool, dry, well ventilated location. Outside or detached storage is preferred. Separate from oxidizers, acids, and carbon
dioxide.
Other Precautions
Avoid acid contamination and skin contact. Keep containers tightly closed. No smoking or eating in handling area. Head spaces in
vessels may contain ammonia levels greater than 35 ppm.
Steps to be taken in case Material is Released or Spilled
Shut off sources of ignition. Pick up spill on sand, earth or other non-combustible, absorbent material. Place in covered container for
disposal. Flush area with water to remove last traces.
Waste Disposal Methods (Consult Federal, State, and Local Regulations)
Dispose of as a corrosive waste in accord with regulations
Section VIII - Special Protection and Control Measures
Respiratory Protection (Specify Type)
NIOSH approved organic vapor air purifying respirator.
Ventilation and local exhaust required.
Eye Protection Protective Gloves Other Protective Clothing or Equipment
Chemical goggles and face shield Impervious chemical gloves. Eye fountain and safety shower
Work Hygienic Practices
Avoid direct contact with 2-Tetrahydrofurfurylamine. Wash thoroughly after handling.
Transport Information:
DOT: Tetrahydrofurfurylamine, 3, UN 2943, PG III.
Label: Flammable liquid.
The data contained herein is based on information currently available to Penn Specialty Chemicals, Inc., and believed to be factual and the opinions expressed to be those of qualified experts; however, this data is not to be
taken as a warranty or representation for which Penn Specialty Chemicals, Inc. assumes legal responsibility.
|