The MSDS format adheres to the standards and regulatory requirements
of the United States and may not meet regulatory requirements
in other countries.
DuPont Page 1
Material Safety Data Sheet
----------------------------------------------------------------------
DuPont(TM) StoneTech(R) Professional Enhancer Pro(TM)
6485CR Revised 7-FEB-2007
----------------------------------------------------------------------
----------------------------------------------------------------------
CHEMICAL PRODUCT/COMPANY IDENTIFICATION
----------------------------------------------------------------------
Company Identification
MANUFACTURER/DISTRIBUTOR
DuPont StoneTech(R) Professional
370 North Wiget Lane
Suite 200
Walnut Creek
California
94598
PHONE NUMBERS
Product Information : 800-441-7515/Outside US: 302-774-1000
Transport Emergency : CHEMTREC: 800-424-9300/Outside US:
703-527-3887
Medical Emergency : 800-441-3637/Outside US: 302-774-1000
----------------------------------------------------------------------
COMPOSITION/INFORMATION ON INGREDIENTS
----------------------------------------------------------------------
# Components
Material CAS Number %
Proprietary Silicone Resin
Isooctyl Trimethoxy Silane
*Methanol 67-56-1 <2
Aliphatic Hydrocarbons 68551-16-6 >70
Butyl Acetate 123-86-4 <1
* Disclosure as a toxic chemical is required under Section 313 of
Title III of the Superfund Amendments and Reauthorization Act of 1986
and 40 CFR part 372.
----------------------------------------------------------------------
HAZARDS IDENTIFICATION
----------------------------------------------------------------------
Potential Health Effects
Inhalation: Inhalation may cause respiratory irritation.
May cause headache, dizziness, nausea, or unconsciousness in
high concentrations.
Skin Contact: May cause skin irritation.
Eye Contact: May cause eye irritation.
Ingestion: Harmul or fatal if swallowed. May irritate
stomach and intestines.
6485CR DuPont Page 2
Material Safety Data Sheet
(HAZARDS IDENTIFICATION - Continued)
Carcinogenicity Information
None of the components present in this material at concentrations
equal to or greater than 0.1% are listed by IARC, NTP, OSHA or ACGIH
as a carcinogen.
----------------------------------------------------------------------
FIRST AID MEASURES
----------------------------------------------------------------------
First Aid
INHALATION
If inhaled, remove to fresh air. If not breathing, give
artificial respiration. If breathing is difficult, give oxygen.
Call a physician.
SKIN CONTACT
Flush skin with water after contact. Wash contaminated clothing
before reuse.
EYE CONTACT
In case of contact, immediately flush eyes with plenty of water
for at least 15 minutes. Call a physician.
INGESTION
If swallowed, do not induce vomiting. Immediately give 2 glasses
of water. Never give anything by mouth to an unconscious person.
Call a physician.
Notes to Physicians
Activated charcoal mixture may be beneficial. Suspend 50 g
activated charcoal in 400 mL water and mix well. Administer 5
mL/kg, or 350 mL for an average adult.
----------------------------------------------------------------------
FIRE FIGHTING MEASURES
----------------------------------------------------------------------
# Flammable Properties
Flash Point : 83 F (28 C)
Method : Pensky-Martens Closed Cup - PMCC.
Flammable.
Extinguishing Media
Water Spray, Dry Chemical, CO2.
6485CR DuPont Page 3
Material Safety Data Sheet
(FIRE FIGHTING MEASURES - Continued)
Fire Fighting Instructions
Evacuate personnel to a safe area. Wear self-contained breathing
apparatus (SCBA) and full protective equipment.
----------------------------------------------------------------------
ACCIDENTAL RELEASE MEASURES
----------------------------------------------------------------------
Safeguards (Personnel)
NOTE: Review FIRE FIGHTING MEASURES and HANDLING (PERSONNEL)
sections before proceeding with clean-up. Use appropriate
PERSONAL PROTECTIVE EQUIPMENT during clean-up.
Initial Containment
Dike spill.
Spill Clean Up
Dispose of in an approved container.
----------------------------------------------------------------------
HANDLING AND STORAGE
----------------------------------------------------------------------
Handling (Personnel)
Avoid inhalation. Avoid contact with eyes, skin or clothing.
Wash thoroughly after handling. Wash clothing after use.
Handling (Physical Aspects)
Keep container tightly closed.
Storage
Store in a cool, dry place.
Avoid freezing or extended storage in high temperatures.
----------------------------------------------------------------------
EXPOSURE CONTROLS/PERSONAL PROTECTION
----------------------------------------------------------------------
Engineering Controls
Use only with adequate ventilation.
Personal Protective Equipment
EYE/FACE PROTECTION
Wear safety glasses, or where splash potential exists wear
chemical splash goggles.
6485CR DuPont Page 4
Material Safety Data Sheet
(EXPOSURE CONTROLS/PERSONAL PROTECTION - Continued)
RESPIRATORS
Where the potential exists for airborne exposure, wear NIOSH
approved respiratory protection.
PROTECTIVE CLOTHING
Where there is potential for skin contact, have available and wear
as appropriate impervious gloves, apron or smock.
Exposure Guidelines
Applicable Exposure Limits
Methanol
PEL (OSHA) : 200 ppm, 260 mg/m3, 8 Hr. TWA
TLV (ACGIH) : 200 ppm, 8 Hr. TWA, Skin
STEL 250 ppm
AEL * (DuPont) : 200 ppm, 8 & 12 Hr. TWA, Skin
Butyl Acetate
PEL (OSHA) : 150 ppm, 710 mg/m3, 8 Hr. TWA
TLV (ACGIH) : 150 ppm, 8 Hr. TWA
AEL * (DuPont) : None Established
* AEL is DuPont’s Acceptable Exposure Limit. Where governmentally
imposed occupational exposure limits which are lower than the AEL
are in effect, such limits shall take precedence.
Exposure Guideline Comments
Aliphatic Hydrocarbon:
TLV (ACGIH) : 200 ppm, 8 Hr. TWA
AEL * (DuPont) : 100 ppm, 8 Hr. TWA
----------------------------------------------------------------------
PHYSICAL AND CHEMICAL PROPERTIES
----------------------------------------------------------------------
# Physical Data
Boiling Point : >300 F (>149 C)
Evaporation Rate : <1 (Butyl Acetate=1.0)
Odor : (slight), Hydrocarbon.
Form : Liquid.
Color : Clear.
Specific Gravity : 0.78
6485CR DuPont Page 5
Material Safety Data Sheet
----------------------------------------------------------------------
STABILITY AND REACTIVITY
----------------------------------------------------------------------
Chemical Stability
Stable at normal temperatures and storage conditions.
Incompatibility with Other Materials
Incompatible or can react with water or acids to release
methanol.
# Decomposition
Hazardous decomposition products: methanol, carbon dioxide,
and carbon monoxide.
----------------------------------------------------------------------
DISPOSAL CONSIDERATIONS
----------------------------------------------------------------------
Waste Disposal
Treatment, storage, transportation, and disposal must be in
accordance with applicable Federal, State/Provincial, and Local
regulations.
----------------------------------------------------------------------
TRANSPORTATION INFORMATION
----------------------------------------------------------------------
Shipping Information
DOT:
For 5 gal. and 55 gal.:
Proper Shipping Name ΒΈ: Hydrocarbons, Liquid, N.O.S.
Hazard Class ΒΈΒΈ: 3
UN Number ΒΈΒΈ: 3295
Packing Group ΒΈΒΈ: III
Label ΒΈΒΈΒΈ: Flammable Liquid
For 2 oz., 1 Pint, 1 Quart and 1 Gallon
Proper Shipping Name ΒΈ: Consumer Commodity
Hazard Class ΒΈΒΈ: ORM-D
UN Number ΒΈΒΈ: N/A
Packing Group ΒΈΒΈ: N/A
Label ΒΈΒΈΒΈ: None
IMDG:
For 5 gal. and 55 gal. package:
Proper Shipping Name ΒΈ: Hydrocarbons, Liquid, N.O.S.
Hazard Class ΒΈΒΈ: 3
6485CR DuPont Page 6
Material Safety Data Sheet
(TRANSPORTATION INFORMATION - Continued)
UN Number ΒΈΒΈ: 3295
Packing Group ΒΈΒΈ: III
Label ΒΈΒΈΒΈ: Flammable Liquid
For 2 Oz., 1 Pint, 1 Quart, and 1 Gal.:
Proper Shipping Name ΒΈ: Hydrocarbons, Liquid, N.O.S.
Hazard Class ΒΈΒΈ: 3
UN Number ΒΈΒΈ: 3295
Packing Group ΒΈΒΈ: III
Label ΒΈΒΈΒΈ: Flammable Liquid
Special Instructions ΒΈ: Limited Quantity
IATA:
For 5 gal. and 55 gal. package:
Proper Shipping Name ΒΈ: Hydrocarbons, Liquid, N.O.S.
Hazard Class ΒΈΒΈ: 3
UN Number ΒΈΒΈ: 3295
Packing Group ΒΈΒΈ: III
Label ΒΈΒΈΒΈ: Flammable Liquid
For 1 Quart and 1 Gal.:
Proper Shipping Name ΒΈ: Hydrocarbons, Liquid, N.O.S.
Hazard Class ΒΈΒΈ: 3
UN Number ΒΈΒΈ: 3295
Packing Group ΒΈΒΈ: III
Label ΒΈΒΈΒΈ: Flammable Liquid
Special Instructions ΒΈ: Limited Quantity
For 2 Oz. and 1 Pint:
Proper Shipping Name ΒΈ: Consumer Commodity
Hazard Class ΒΈΒΈ: 9
UN Number ΒΈΒΈ: ID 8000
Label ΒΈΒΈΒΈ: Miscellaneous
----------------------------------------------------------------------
REGULATORY INFORMATION
----------------------------------------------------------------------
U.S. Federal Regulations
TSCA Inventory Status : Listed.
----------------------------------------------------------------------
The data in this Material Safety Data Sheet relates only to the
specific material designated herein and does not relate to use in
combination with any other material or in any process.
# Indicates updated section.
6485CR DuPont Page 7
Material Safety Data Sheet
(Continued)
This information is based upon technical information believed to be
reliable. It is subject to revision as additional knowledge and
experience is gained.
End of MSDS
|