HMIS庐
Material Safety Data Sheet
HEALTH 2 REACTIVITY 0
PERSONAL PROTECTION
FLAMMABILITY 3 B
庐 Note: Blank spaces are not permitted. If any item is not applicable, or no
Identity: SCRUBS Graffiti & Spray Paint Remover
information is available, the space must be marked to indicate that.
Formula: B901
Part numbers: 90101, 90130
SECTION 1: Company Identification
Manufacturer's Name Emergency Telephone Number
ITW Dymon 1-800-535-5053
Address (Number, Street, City, State, and ZIP Code) International Emergency Telephone Number
805 East Old 56 Highway 1-352-323-3500
Telephone Number for Information
Olathe, Kansas 66061 1-913-397-9889
Signature of Preparer (Optional)
Regulatory Dept.
SECTION 2: Ingredients/Identity Information
Components (Chemical Identity, Other Limits
Common Name(s)) CAS No. OSHA PEL ACGIH-TLV Recommended % (Opt.)
Water 7732-18-5 No Data No Data No Data 15 鈥? 40%
Dimethyl Glutartate 1119-40-0 No Data No Data No Data 15 鈥? 40%
Dimethyl Adipate 627-93-0 No Data No Data No Data 10 鈥? 30%
PPG-3 Methyl Ether 25498-49-1 No Data No Data No Data 10 鈥? 30%
Acetone 67-64-1 1000 ppm 500 ppm 750 ppm STEL 7 鈥? 13%
Methoxyisopropanol 107-98-2 No Data 100 ppm 150 ppm STEL 7 鈥? 13%
2-Butoxyethanol (skin designation) 111-76-2 50 ppm 20 ppm 700 ppm IDLH 5 鈥? 10%
Amyl acetate 628-63-7 100 ppm 50 ppm 100 ppm STEL 3 鈥? 7%
Dimethyl Succinate 106-65-0 No Data No Data No Data 3 鈥? 7%
Any substance listed as hazardous by the States of California, Florida, Illinois, Michigan, New Jersey, Ohio, Pennsylvania or
Texas is described above if known present in regulated concentrations.
SECTION 3: Hazards Identification
Route(s) of Entry Eyes? Inhalation? Skin? Ingestion?
Yes Yes Yes Yes
Acute Health Hazards - Warning. Flammable liquid and vapor. Causes eye and skin irritation. Liquid may be harmful or fatal if swallowed
(aspiration hazard). May be harmful if absorbed through intact skin. May be harmful if inhaled. Overexposure to vapors may induce central nervous
system effects. Follow good chemical hygiene practices to avoid these hazards.
Chronic Health Hazards - Repeated or prolonged occupational overexposure can cause dermatitis, severe skin irritation, or Painter鈥檚 Syndrome.
Carcinogenicity:
Chemical: OSHA: NTP: IARC:
None No No No
Signs and Symptoms of Exposure - Redness, tearing or burning in eyes. Redness, burning, drying or cracking of skin. Swallowing, overexposure
to vapors or skin absorption may cause drowsiness, dizziness, nausea, headaches, fatigue, loss of coordination. Inhalation of excessive amounts of
vapors may irritate nose, throat, lungs and upper respiratory tract. Follow good chemical hygiene practices to avoid these hazards.
Medical Conditions Generally Aggravated by Exposure - Pre-existing skin, lung, kidney, liver, and blood conditions could be aggravated by
overexposure and misuse.
SECTION 4: Emergency and First Aid Procedures:
Eyes - Flush with plenty of water for at least 15 minutes lifting eyelids to insure complete removal. See a physician immediately.
Ingestion 鈥? If liquid is ingested call a physician or poison control center immediately. Do NOT induce vomiting unless directed to do so by a
physician or poison control center. Never give anything by mouth to an unconscious person.
Inhalation 鈥? Get to fresh air. If breathing has stopped, qualified personnel should administer artificial respiration. If breathing is difficult, give
oxygen.
1 Formula: B901
Skin 鈥? Flush with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing and shoes before reuse.
If irritation arises and persists get medical attention.
SECTION 5: Fire Fighting Measures
Flash Point, Concentrate (Method Used) Flammable Limits LEL UEL
64oF (PMCC) No Data No Data No Data
Extinguishing Media - Use carbon dioxide, dry chemical, foam, or water fog. Large spills may cause a floating fire to form as if an oil fire.
Special Fire Fighting Procedures - Keep containers cool and vapors down with water spray. Prevent runoff from entering sewers and public
waterways. Wear SCBA in chemical fires.
Hazardous Products of Combustion - Carbon dioxide, carbon monoxide, smoke and soot and various organic oxidation by-products.
Unusual Fire and Explosion Hazards - Flammable liquid on a polypropylene towel.
SECTION 6: Accidental Release Measures
Small Spill - Wipe up small releases with a dry absorbent cloth or other absorbent material.
Large Spill 鈥? Absorb liquid with vermiculite, absorbent cloth, or other absorbent material. Prevent material from entering sewers or drains.
Ventilate area and block traffic. Transfer contaminated material into suitable container for proper disposal.
SECTION 7: Handling and Storage
Handling 鈥? Do not get into eyes, on skin, or clothing. Wash thoroughly after handling. Do not swallow. Do not smoke while using. Avoid inhaling
vapors. Use with adequate ventilation. Do not deliberately concentrate and inhale vapors. Follow label directions carefully.
Storage 鈥? Store in a cool well ventilated area. Keep away from heat sources. Keep out of reach of children. Keep container tightly sealed when
not in use. Do not contaminate water, food or feed by use or storage.
SECTION 8: Exposure Controls / Personal Protection
Eye Protection 鈥? If direct contact is possible, use goggles or approved safety glasses (ANSI Z87).
Skin Protection 鈥? Yes, impervious.
Respiratory Protections 鈥? Not usually necessary. Use with adequate ventilation. Use NIOSH/MSHA approved respirator if PELs or TLVs are
exceeded.
Engineering Controls 鈥? Ventilation should be provided in the event of overexposure.
SECTION 9: Physical and Chemical Properties
Clear colorless liquid with an Amyl Acetate scent saturated on a towel.
Appearance and Odor:
6.3
PH
Specific Gravity (70oF) 0.986
>212o F
Boiling Point:
No Data
Melting Point:
No Data
Evaporation Rate (Butyl Acetate = 1)
Vapor Pressure (mm-Hg @ 70oF) No Data
Greater than one (1)
Vapor Density (AIR = 1)
Miscible
Solubility in Water
295.80 grams per liter or 30% by weight VOCs.
Volatile Organic Compounds (VOCs)
SECTION 10: Stability and Reactivity
Hazardous Polymerization 鈥? This product will not undergo hazardous polymerization.
Hazardous Decomposition or Byproducts 鈥? Carbon dioxide, carbon monoxide, smoke and soot and various organic oxidation by-products.
Chemical Stability - Stable
Incompatibility (Materials to Avoid) - Strong alkalis, acids, oxidizers, alkali metal hydroxides and heat.
SECTION 11: Toxicological Information
2-Butoxyethanol: Oral LD50: 470 鈥? 3000 mg/kg, rat
2 Formula: B901
Skin LD50: 220 mg/kg, rabbit
Inhalation LC50: 700 ppm/ 7H, rat
SECTION 12: Ecological Information
2-Butoxyethanol: Fathead minnow LC50: 1900 mg/L
Daphnia magna EC50: 2500 mg/L
Selenastrum capriconmutum EC50: >1000 mg/L
SECTION 13: Disposal Consideration
Disposal Method - Dispose of in accordance with all applicable local, state, and federal regulations.
RCRA Waste Information 鈥? If this product becomes a waste, it would be a hazardous waste (D001) as defined by RCRA (40 CFR 261). However
the waste should be properly characterized to evaluate whether its composition has been modified prior to disposal.
SECTION 14: Transport Information
DOT Information 鈥? 49 CFR 172.101
Proper Shipping Description: Consumer Commodity
Hazard Class: ORM-D
Identification Number: None
Packing Group: None
Water Transportation:
Proper Shipping Description: Paint Related Material
Hazard Class: 3
Identification Number: UN 1263
Packing Group: II
Air Transportation:
Proper Shipping Description: Paint Related Material
Hazard Class: 3
Identification Number: UN 1263
Packing Group: II
SECTION 15: Regulatory Information
US Federal Regulations:
TSCA (Toxic Substances Control Act) Status
All ingredients are on the TSCA inventory or are not required to be listed on the TSCA inventory.
CERCLA RQ 鈥? 40 CFR 302.4 (a)
Acetone (CAS# 67-64-1) 鈥? 5000 lbs
SARA 313 Components 鈥? 40 CFR 372.65
2-Butoxyethanol (CAS# 111-76-2) 鈥? 7.4%
State and Local Regulations:
California Proposition 65
None
Section 16: Additional Information
3 Formula: B901
Date Prepared:
Rev. 3 鈥? 08/28/06 鈥? VOC Reformulation
Rev. 2 鈥? 06/26/06 鈥? Corrected spelling errors and revised carcinogenicity table.
Rev. 1 鈥? 02/20/06 鈥? New format
WARNING! The use of this product is beyond the control of the manufacturer; therefore, no guarantee, expressed or implied, is made as to the effects of such or
the results to be obtained if not used in accordance with directions or established safe practice. The user must assume all responsibility, including injury or damage,
resulting from its misuse as such, or in combination with other materials. The manufacturer warrants only that this product meets the manufacturer's specifications
for such product. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, AS TO DESCRIPTION, QUALITY,
MERCHANTABILITY. FITNESS FOR ANY PARTICULAR PURPOSE, PRODUCTIVENESS, OR ANY OTHER MATTER, OF THIS PRODUCT. THE
MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE IMPROPER USE OF THIS PRODUCT. The sole and exclusive remedy against the
manufacturer for breach of warranty shall be reimbursement of the purchase price of the product in the event that a defective condition of the product shall be found
to exist. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED TO INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR
PROPERTY OR ANY OTHER INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.
4 Formula: B901
|