MATERIAL SAFETY DATA SHEET
GM FOAM GELLING AGENT
SECTION I鈥擯reparation/Product Information
MANUFACTURED FOR AND SUPPLIED BY: TELEPHONE NO: (818) 908-1087
GM Foam, Inc DATE PREPARED: July 11, 2001
14956 Delano St. PREPARED BY: GM Foam, Inc
Van Nuys, CA 91411 PRODUCT USE: Foam Coagulant
DATE PRINTED: July 11, 2001
EMERGENCY CONTACT: (818) 908-1087
SECTION II 鈥? Ingredients/Identity Information
HMIS HAZARD CODES
NAME: Foam Rubber Coagulant Health: 2
CLASS: Intermediate Flammability: 0
Reactivity: 0
Personal Protective Equipment: X
COMPONENTS EXPOSURE LIMITS TOXICITY
CHEMICAL IDENTITY CAS# LD50 / LC50
Water 7732-18-5 Unknown Unknown
TLV-TWA 2.5mg/m3
Sodium Silicofluoride 16893-85-9 LD50 rat/oral
125mg/kg
LC50 rat/inhalation
33mg/m3 鈥? 6hrs
Bentonite Clay 1302-78-9 Not Established Not Available
SECTION III 鈥? Physical / Chemical Characteristics
BOILING POINT: 32潞C SPECIFIC GRAVITY (H2O = 1): 1.1983
MELTING POINT: Not Available pH: Not Available
VAPOR PRESSURE (mm Hg): Not Available ODOR THRESHOLD (ppm): Not Available
VAPOR DENSITY (AIR = 1): Lighter than air COEF. WATER/OIL DIST.: Not Available
SOLUBILITY IN WATER: Appreciable (10-99%) EVAPORATION RATE: Slower
APPEARANCE (PHYSICAL STATE) AND ODOR: Gray liquid, odorless
% VOLATILE BY VOLUME: Not Available
SECTION IV 鈥? Fire and Explosion Hazard Data
FLAMMABILITY CLASSIFICATION: Not Flammable
EXTINGUISHING MEDIA: Foam, alcohol foam, carbon dioxide, water fog, dry chemical
SPECIAL FIRE FIGHTING PROCEDURES: Fire fighters should wear full protective clothing to guard against exposure to toxic and
irritating fumes.
GM FOAM GELLING AGENT 鈥? PAGE 1
FLAMABLE LIMITS LEL: Not Determined
UEL: Not Determined
AUTOIGNITION TEMPURATURE: Not Determined
SENS. TO MECHANICAL IMPACT: Not Determined
SENS. TO STATIC DISCHARGE: Not Determined
HAZARDOUS COMBUSTION PRODUCTS: None Known
SECTION V 鈥? Reactivity Data
SABILITY:
Stable X
Unstable
CONDITIONS TO AVOID (Condition of Reactivity): None.
INCOMPATIBILITY (Materials to Avoid): Some metals, acids (HF may be produced if mixed with acids), acid vapors and active metals
such as aluminum or magnesium.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: HF gas, F compounds, NaO2 from contact with some metals.
HAZARDOUS POLYMERIZATION CONDITIONS TO AVOID: None
SECTION VI 鈥? Health Hazard Data
PRIMARY ROUTE OF EXPOSURE:
Inhalation: yes Skin Contact: yes
Skin Absorption: no Ingestion: yes
Eye Contact: yes
HEALTH HAZARDS:
Acute: Skin, eye, respiratory irritation. Ingestion may cause severe nausea, vomiting, abdominal pain 鈥? may be fatal.
Chronic: None Known
CARCINOGENICITY:
NTP: No IARC: No OSHA: No
SIGNS AND SYMPTOMS OF EXPOSURE: See Health Hazards
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: None Known
Irritancy: skin, eyes, respiratory tract Reproductive Toxicity: Not Determined
Sensitization: Not Determined Teratogenicity: Not Determined
Mutagenicity: Not Determined
SYNERGISTIC PRODUCTS: Not Determined
HMIS RATING: 2
SECTION VII 鈥? First Aid Measures
GM FOAM GELLING AGENT 鈥? PAGE 2
EMERGENCY AND FIRST AID PROCEDURES
Inhalation: Move to fresh air
Ingestion: Consult a physician
Skin Contact: Wash with soap and water.
Eye Contact: Flush with water for 15 minutes. If irritation persists, consult a physician.
SECTION VIII 鈥? Precautions for Safe Handling and Use
Steps to be taken in case material is released or spilled:
Properly protected personnel should contain the spill. Soak it up with absorbent material. Shovel the absorbed material into
containers for disposal.
Waste Disposal Method:
In accordance with all Federal, State and Local regulations. Empty containers retain product residue and are subject to all of
the handling instructions on this sheet
Precautions to be taken in handling and storing:
Avoid contact with eyes, skin and clothing.
Other Precautions:
None Known
SECTION IX 鈥? Control Measures
Respiratory Protection Specify Type): None normally required.
VENTILATION
Local Exhaust: Recommended to minimize exposure.
Mechanical (General): Recommended to minimize exposure.
PROTECTIVE GLOVES: Rubber gloves
EYE PROTECTION: Chemial Safety Glasses or splash goggles to prevent eye contact.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: If needed to prevent unnecessary skin contact.
WORK/HYGIENIC PRACTICES: Wash thoroughly after handling.
ROUTES OF ENTRY: Skin contact, inhalation, eye contact, ingestion.
SECTION X 鈥? Special Precautions
HANDLING AND STORAGE PRECAUTIONS:
GM FOAM GELLING AGENT 鈥? PAGE 3
Avoid unnecessary skin contact with this product. Teach employees proper handling procedures before using this product.
Provide adequate ventilation during use.
OTHER PRECAUTIONS:
Store in a cool, dry location. Keep containers tightly sealed and upright when not in use. Keep from freezing.
SECTION XI 鈥? Additional Information
SPECIAL SHIPPING INFORMATION:
DOT SHIPPING NAME: Latex Intermediate
HAZARD CLASS: n.o.s.
UN/NA NUMBER: none/none
SARA TITLE III:
Section 302 鈥? Extremely Hazardous Substances: does not contain
Section 311/312 鈥? Categories for Tier I & Tier II reporting:
______Fire __X__Immediate (acute) Health ______Reactivity
______Delayed (chronic) Health ______Sudden Release of Pressure
Section 313 鈥? Emissions reporting: All product ingredients with 鈥測es鈥? in the 鈥淟isted?鈥? column are subject to the reporting
requirements of Section 313. EPA lists chemical name & CAS# or by chemical category. This information must accompany all
copies of this MSDS.
CHEMICAL CAS# LISTED %
Sodium Silicofluoride 16893-85-9 No 25-30
CALIFORNIA PROPOSITION 65:
This product does not contain any listed chemicals.
THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE BASED UPON DATA THAT IS ACCURATE AND
RELIABLE TO THE BEST OF GM FOAM鈥橲 KNOWLEDGE AND BELIEF. WITH RESPECT TO THE INFORMATION AND
RECOMMENDATIONS, GM FOAM MAKES NO REPRESENTATIONS OR WARRANTIES OF ANY KIND OR NATURE, EXPRESS
OR IMPLIED.
This Adobe Portable Document Format file was created from GM Foam, Inc鈥檚 original Material Safety
Data Sheet word document files by Cybergraphic Designs, Inc. for use on the Cybergraphic Designs, Inc.
Makeup Effects & Supply website. Please visit us on the web to download other useful MSDS PDF files.
http://www.getspfx.com
GM FOAM GELLING AGENT 鈥? PAGE 4
|