Hydrogen Peroxide, 3% Page 1 of 7
Hydrogen Peroxide, 3%
MSDS Number: H4071 --- Effective Date: 03/01/97
1. Product Identification
Synonyms: Hydrogen Dioxide Solution
CAS No.: 7722-84-1
Molecular Weight: 34.01
Chemical Formula: H2O2 in aqueous solution
Product Codes: 5679
2. Composition/Information on Ingredients
Ingredient CAS No Percent Hazardous
--------------------------------------- ------------ ------- ---------
Hydrogen Peroxide 7722-84-1 2 - 4% Yes
Acetanilide 103-84-4 < 0.05% No
Water 7732-18-5 96 - 98% No
3. Hazards Identification
Emergency Overview
--------------------------
WARNING! MAY BE HARMFUL IF SWALLOWED. CAUSES EYE
IRRITATION.
J.T. Baker SAF-T-DATA(tm) Ratings (Provided here for your convenience)
http://www.jtbaker.com/msds/h4071.htm 12/31/98
Hydrogen Peroxide, 3% Page 2 of 7
-----------------------------------------------------------------------------------------------------------
Health Rating: 0 - None
Flammability Rating: 0 - None
Reactivity Rating: 1 - Slight
Contact Rating: 1 - Slight
Lab Protective Equip: GOGGLES; LAB COAT
Storage Color Code: Orange (General Storage)
-----------------------------------------------------------------------------------------------------------
Potential Health Effects
----------------------------------
Inhalation:
Not expected to be a health hazard under normal conditions.
Ingestion:
Large oral doses may cause irritation and blistering to the mouth, throat, and abdomen.
May also cause abdominal pain, vomiting, and diarrhea.
Skin Contact:
No adverse effects expected on intact skin. Contact on burn or open skin may cause
stinging pain or irritation.
Eye Contact:
Causes irritation, redness, and pain.
Chronic Exposure:
No information found.
Aggravation of Pre-existing Conditions:
No information found.
4. First Aid Measures
Inhalation:
Not expected to require first aid measures.
Ingestion:
Give several glasses of water to drink to dilute. If large amounts were swallowed, get
medical advice.
Skin Contact:
Not expected to require first aid measures. Wash exposed area with soap and water. Get
medical advice if irritation develops.
Eye Contact:
Immediately flush eyes with plenty of water for at least 15 minutes, lifting lower and
upper eyelids occasionally. Get medical attention immediately.
5. Fire Fighting Measures
http://www.jtbaker.com/msds/h4071.htm 12/31/98
Hydrogen Peroxide, 3% Page 3 of 7
Fire:
Not considered to be a fire hazard. Concentrated hydrogen peroxide (30%) is a strong
oxidizer, but this dilute product does not present that hazard.
Explosion:
Not considered to be an explosion hazard. Drying of concentrated hydrogen peroxide on
clothing or other combustible materials may cause fire or explosion.
Fire Extinguishing Media:
Use any means suitable for extinguishing surrounding fire.
Special Information:
In the event of a fire, wear full protective clothing and NIOSH-approved self-contained
breathing apparatus with full facepiece operated in the pressure demand or other positive
pressure mode.
6. Accidental Release Measures
Ventilate area of leak or spill. Wear appropriate personal protective equipment as
specified in Section 8. Contain and recover liquid when possible. Collect liquid in an
appropriate container or absorb with an inert material (e. g., vermiculite, dry sand, earth),
and place in a chemical waste container. Do not use combustible materials, such as saw
dust. Small amounts of residue may be flushed to sewer with plenty of water.
7. Handling and Storage
Store in a cool, well-ventilated dark area. Protect from freezing. Isolate from
incompatible substances. Protect container from physical damage. Containers of this
material may be hazardous when empty since they retain product residues (vapors, liquid);
observe all warnings and precautions listed for the product.
8. Exposure Controls/Personal Protection
Airborne Exposure Limits:
-OSHA Permissible Exposure Limit (PEL):
1 ppm (TWA) for hydrogen peroxide
-ACGIH Threshold Limit Value (TLV):
1 ppm (TWA) for hydrogen peroxide, A3: Animal Carcinogen
Ventilation System:
A system of local and/or general exhaust is recommended to keep employee exposures
below the Airborne Exposure Limits. Local exhaust ventilation is generally preferred
because it can control the emissions of the contaminant at its source, preventing
dispersion of it into the general work area. Please refer to the ACGIH document,
Industrial Ventilation, A Manual of Recommended Practices, most recent edition, for
details.
Personal Respirators (NIOSH Approved):
http://www.jtbaker.com/msds/h4071.htm 12/31/98
Hydrogen Peroxide, 3% Page 4 of 7
Not expected to require personal respirator usage. If the exposure limit is exceeded, wear
a supplied air, full-facepiece respirator, airlined hood, or full-facepiece self-contained
breathing apparatus. This substance has unknown warning properties.
Skin Protection:
Wear protective gloves and clean body-covering clothing.
Eye Protection:
Use chemical safety goggles and/or a full face shield where splashing is possible. Maintain
eye wash fountain and quick-drench facilities in work area.
9. Physical and Chemical Properties
Appearance:
Clear, colorless liquid.
Odor:
Odorless.
Solubility:
Complete (100%)
Specific Gravity:
1.01
pH:
No information found.
% Volatiles by volume @ 21C (70F):
100
Boiling Point:
ca. 100C (ca. 212F)
Melting Point:
ca. 0C (ca. 32F)
Vapor Density (Air=1):
No information found.
Vapor Pressure (mm Hg):
No information found.
Evaporation Rate (BuAc=1):
No information found.
10. Stability and Reactivity
Stability:
Stable under ordinary conditions of use and storage.
Hazardous Decomposition Products:
Decomposes to water and oxygen.
Hazardous Polymerization:
Will not occur.
Incompatibilities:
Heat, reducing agents, organic materials, dirt, alkalis, rust, and many metals.
Conditions to Avoid:
http://www.jtbaker.com/msds/h4071.htm 12/31/98
Hydrogen Peroxide, 3% Page 5 of 7
Light, heat, incompatibles.
11. Toxicological Information
For Hydrogen peroxide: Investigated as a tumorigen and mutagen. No LD50/LC50
information found relating to normal routes of occupational exposure.
--------\Cancer Lists\------------------------------------------------------
---NTP Carcinogen---
Ingredient Known Anticipated IARC Category
------------------------------------ ----- ----------- -------------
Hydrogen Peroxide (7722-84-1) No No 3
Acetanilide (103-84-4) No No None
Water (7732-18-5) No No None
12. Ecological Information
Environmental Fate:
No information found.
Environmental Toxicity:
No information found.
13. Disposal Considerations
Dilute with water and flush to sewer if local ordinances allow, otherwise, whatever
cannot be saved for recovery or recycling should be managed in an appropriate and
approved waste disposal facility. Processing, use or contamination of this product may
change the waste management options. State and local disposal regulations may differ
from federal disposal regulations. Dispose of container and unused contents in accordance
with federal, state and local requirements.
14. Transport Information
Not regulated.
15. Regulatory Information
--------\Chemical Inventory Status - Part 1\---------------------------------
Ingredient TSCA EC Japan Australia
http://www.jtbaker.com/msds/h4071.htm 12/31/98
Hydrogen Peroxide, 3% Page 6 of 7
----------------------------------------------- ---- --- ----- ---------
Hydrogen Peroxide (7722-84-1) Yes Yes Yes Yes
Acetanilide (103-84-4) Yes Yes Yes Yes
Water (7732-18-5) Yes Yes Yes Yes
--------\Chemical Inventory Status - Part 2\---------------------------------
--Canada--
Ingredient Korea DSL NDSL Phil.
----------------------------------------------- ----- --- ---- -----
Hydrogen Peroxide (7722-84-1) Yes Yes No Yes
Acetanilide (103-84-4) Yes Yes No Yes
Water (7732-18-5) Yes Yes No Yes
--------\Federal, State & International Regulations - Part 1\----------------
-SARA 302- ------SARA 313------
Ingredient RQ TPQ List Chemical Catg.
----------------------------------------- --- ----- ---- --------------
Hydrogen Peroxide (7722-84-1) 1000 1000 No No
Acetanilide (103-84-4) No No No No
Water (7732-18-5) No No No No
--------\Federal, State & International Regulations - Part 2\----------------
-RCRA- -TSCA-
Ingredient CERCLA 261.33 8(d)
----------------------------------------- ------ ------ ------
Hydrogen Peroxide (7722-84-1) 1 No No
Acetanilide (103-84-4) No No No
Water (7732-18-5) No No No
Chemical Weapons Convention: No TSCA 12(b): No CDTA: No
SARA 311/312: Acute: Yes Chronic: No Fire: No Pressure: No
Reactivity: No (Mixture / Liquid)
Australian Hazchem Code: No information found.
Poison Schedule: S5
WHMIS:
This MSDS has been prepared according to the hazard criteria of the Controlled Products
Regulations (CPR) and the MSDS contains all of the information required by the CPR.
16. Other Information
NFPA Ratings: Health: 1 Flammability: 0 Reactivity: 1
Label Hazard Warning:
WARNING! MAY BE HARMFUL IF SWALLOWED. CAUSES EYE IRRITATION.
Label Precautions:
Avoid contact with eyes.
Keep container closed.
Wash thoroughly after handling.
Label First Aid:
In case of eye contact, immediately flush eyes with plenty of water for at least 15 minutes.
Get medical attention. If swallowed, give large amounts of water to drink. Never give
http://www.jtbaker.com/msds/h4071.htm 12/31/98
Hydrogen Peroxide, 3% Page 7 of 7
anything by mouth to an unconscious person. If large amounts were swallowed, get
medical advice.
Product Use:
Laboratory Reagent.
Revision Information:
New 16 section MSDS format, all sections have been revised.
Disclaimer:
***************************************************************************************
Mallinckrodt Baker, Inc. provides the information contained herein in good faith
but makes no representation as to its comprehensiveness or accuracy. This
document is intended only as a guide to the appropriate precautionary handling of
the material by a properly trained person using this product. Individuals receiving
the information must exercise their independent judgment in determining its
appropriateness for a particular purpose. MALLINCKRODT BAKER, INC.
MAKES NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR
IMPLIED, INCLUDING WITHOUT LIMITATION ANY WARRANTIES OF
MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE WITH
RESPECT TO THE INFORMATION SET FORTH HEREIN OR THE PRODUCT
TO WHICH THE INFORMATION REFERS. ACCORDINGLY,
MALLINCKRODT BAKER, INC. WILL NOT BE RESPONSIBLE FOR
DAMAGES RESULTING FROM USE OF OR RELIANCE UPON THIS
INFORMATION.
***************************************************************************************
Prepared by: Strategic Services Division
Phone Number: (314) 539-1600 (U.S.A.)
http://www.jtbaker.com/msds/h4071.htm 12/31/98
|