Material Safety Data Sheet
Section 1 - Manufacturer and Product Information
Manufacturer: CARBOLINE, DIVISION OF STONCOR GROUP, INC.
Mailing 350 HANLEY IND. CT.
Address: ST. LOUIS, MO 63144
Customer Information: (314) 644-1000
24 Hour Emergency CHEMTREC 1-800-424-9300
Phone: Outside US (703) 527-3887
Product Name: Semstone 9029 Block Flr Pt.B Revision Date: 10/28/2003
Product Code: 283PB1NL Supercedes : 08/26/2003
Preparer: Schlereth, Ken
Section 2 - Composition / Information On Ingredients
CAS # OR NJ TRADE SECRET # CHEMICAL NAME WEIGHT % LESS THAN
014808-60-7 SILICON DIOXIDE 70.0
012174-11-7 MAGNESIUM ALUMINUM SILICATE 5.0
014807-96-6 TALC 5.0
000112-57-2 TETRAETHYLENEPENTAMINE 5.0
Chemical Exposure Guidelines
CAS# OR NJ TRADE SECRET # OSHA PEL ACGIH TLV
014808-60-7 0.1 MG/M3 0.1 MG/M3
012174-11-7 15.00 MG/M3 10.00 MG/M3
014807-96-6 20.0 MPPCF 2.0 MG/M3
000112-57-2
Section 3 - Hazards Identification
Emergency Overview: AVOID EYE CONTACT WITH VAPOR, SPRAY, OR MIST. AVOID SKIN CONTACT. AVOID
BREATHING OF VAPORS. DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT. WASH EXPOSED
AREAS THOROUGHLY WITH SOAP AND WATER.
Potential Health Effects:
Eyes: WILL CAUSE BURNS. AVOID ALL EYE CONTACT.
Skin: WILL CAUSE BURNS. AVOID SKIN CONTACT WHEN MOIST OR WET.
Ingestion: DO NOT INGEST.
Inhalation: MAY CAUSE IRRITATION OF THE UPPER RESPIRATORY TRACT.
Systemic: N/A
* This product contains the following chemicals classified by the International Agency for Research on Cancer (IARC)
as 1, 2A, or 2B carcinogens:
CAS # OR NJ TRADE SECRET # IARC
014808-60-7 Known Carcinogenic
Section 4 - First Aid Measures
Eyes: HOLD EYELIDS APART AND IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SEEK
MEDICAL ATTENTION.
Skin: IMMEDIATELY FLUSH AFFECTED AREA WITH WATER FOR 15 MINUTES. SEEK MEDICAL ADVISE. DO
NOT APPLY GREASES OR OINTMENTS. LAUNDER CONTAMINATED CLOTHING, LEATHER SHOULD BE
DISCARDED.
Ingestion: DO NOT INDUCE VOMITING. ADMINISTER 3-4 GLASSES OF MILK OR WATER. SEEK MEDICAL
ATTENTION.
Inhalation: MOVE TO FRESH AIR. PREVENT ASPIRATION OF VOMIT. IF BREATHING HAS STOPPED GIVE
ASSISTED RESPIRATION. SEEK MEDICAL ATTENTION.
Section 5 - Fire Fighting Measures
Flash Point: 383F / 195C Lower Explosive Limit, %: N.D.
Upper Explosive Limit, %: N.D.
(TCC)
Extinguishing Media: Carbon Dioxide, Dry Chemical, Foam
Haz. Combustion Products: CARBON MONOXIDE & CARBON DIOXIDE, OXIDES OF NITROGEN, HYDROGEN
CYANIDE
Fire Fighting Instruction: USE PROTECTIVE COVERING FOR EXPOSED AREAS OF THE HEAD.
Fire Fighting Equipment: WEAR FULL PROTECTIVE CLOTHING, SELF CONTAINED POSITIVE PRESSURE
BREATHING APPARATUS.
Other Information: REACTS WITH WATER
Section 6 鈥? Accidental Release Measures
Steps To Be Taken If Material Is Released Or Spilled: USE ADEQUATE PROTECTION EQUIPMENT. USE
RESPIRATORY PROTECTION EQUIPMENT AND PROTECTIVE CLOTHING. VENT CLOSED SPACES TO
OUTSIDE ATMOSPHERE. STOP THE LEAK, VENTILATE THE SPACE INVOLVED. REDUCE VAPOR SPREADING
WITH A WATER SPRAY. SHUT OFF OR REMOVE ALL IGNITION SOURCES. CONSTRUCT A DIKE TO PREVENT
SPREADING. IF RECOVERY IS NOT FEASIBLE, ADMIX WITH DRY SOIL, SAND OR NON-REACTIVE
ABSORBANT AND PLACE IN A CONTAINER OR DUMPSTER PENDING DISPOSAL. TRANSFER TO
CONTAINERS BY SUCTION IF POSSIBLE.
Section 7 - Handling And Storage
Handling: AVOID CONTACT WITH SKIN OR EYES. AVOID BREATHING OF VAPORS. HANDLE IN WELL
VENTILATED AREA. HANDLE UNDER INERT GAS ATMOSPHERE IN DRY EQUIPMENT. DO NOT EAT, DRINK,
OR SMOKE. AVOID USING IN SPRAY APPLICATIONS.
Storage: KEEP AWAY FROM ACID, OXIDIZERS. KEEP IN COOL, DRY, VENTILATED STORAGE AND IN
CLOSED CONTAINERS. PREFERABLE, STORE OUTDOORS, ABOVE GROUND, AND SURROUNDED BY DIKES
TO CONTAIN SPILLS OR LEAKS. DO NOT STORE IN REACTIVE CONTAINERS
Section 8 - Exposure Controls / Personal Protection
Engineering Controls: MECHANICAL VENTILATION AS APPRORIATE.
Respiratory Protection: USE ONLY WITH VENTILATION TO KEEP LEVELS BELOW EXPOSURE GUIDELINES
(Section II). USER SHOULD TEST AND MONITOR EXPOSURE LEVELS TO ENSURE ALL PERSONEL ARE
BELOW GUIDELINES. IF NOT SURE, OR NOT ABLE TO MONITOR, USE MSHA/NIOSH APPROVED SUPPLIED
AIR RESPIRATOR. FOLLOW ALL CURRENT OSHA REQUIREMENTS FOR RESPIRATOR USE.
Skin Protection: IMPERMEABLE GLOVES. NEOPRENE RUBBER GLOVES. CUFFED BUTYL RUBBER GLOVES.
NITRILE RUBBER GLOVES. LATEX GLOVES.
Eye Protection: PROTECTIVE EYEWEAR SUCH AS SAFETY GLASSES, GOGGLES OR FULL FACE SHIELD AS
ADEQUATE FOR THE APPLICATION.
Other Protective Equipment: IMPERVIOUS CLOTHING. SLICKER SUIT. RUBBER BOOTS. BUTYL OR LATEX
PROTECTIVE CLOTHING.
Section 9 - Physical And Chemical Properties
Physical State: LIQUID
Appearance: N/A
Odor: AMMONICAL
Vapor Pressure: N/A
Vapor Density: N/A
Boiling Range: None - None
Solubility in H2O: N/A
Specific Gravity: 1.911
Viscosity: N/A
pH: N/A
(See section 16 for abbreviation legend)
Section 10 - Stability And Reactivity
Stability: STABLE
Conditions To Avoid: NONE
Incompatibility: OXIDIZING AGENTS, MINERAL ACIDS, AND EPOXY RESINS UNDER UNCONTROLLED
CONDITIONS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF NITROGEN.
Hazardous Polymerization: WILL NOT OCCUR.
Section 11 - Toxicological Information
Skin/Dermal: NOT AVAILABLE
Oral/Ingestion: NOT AVAILABLE
Inhalation: NOT AVAILABLE
Section 12 - Ecological Information
Movement & Partitioning: NOT DETERMINED
Degradation & Transformation: NOT DETERMINED
Ecotoxicology: NOT DETERMINED
Section 13 - Disposal Information
Disposal Information: COMPLY WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.
Section 14 - Transportation Information
DOT Proper Shipping Name: PAINT RELATED MATERIAL
DOT Technical Name: None
DOT Hazard Class: 8
Hazard Subclass: NONE
DOT UN/NA Number: UN3066
Packing Group: III
Resp. Guide Page: 153
Section 15 - Regulatory Information
CERCLA 鈥? SARA Hazard Category
This product has been reviewed according to the EPA 鈥楬azard Categories鈥? promulgated under Sections 311and 312
of the Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable
definitions, to meet the following categories:
None Known.
SARA Section 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the
Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
None
Toxic Substances Control Act:
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if
exported from the United States:
None
Clean Air Act:
Coating Category: INDUSTRIAL MAINTENANCE COATINGS
VOC Content Limit (g/l)*: 450
Product VOC Content (g/l)*: 0
Thinning Recommendations: NONE
Application Recommendations: INDUSTRIAL USE ONLY
* Grams of VOC per liter of coating product as applied (mixture of Part A and Part B) per EPA Method 24.
U.S. State Regulations: As follows 鈥?
New Jersey Right-to-Know:
The following materials are non-hazardous, but are among the top five components in this product.
CAS # OR NJ TRADE SECRET # CHEMICAL NAME
068953-36-6 TOFA, REACTION PRODUCTS WITH T
TS-73 TRADE SECRET - NON-HAZARDOUS
000141-04-8 DIISOBUTYL ADIPATE
Pennsylvania Right-to-Know:
The following non-hazardous ingredients are present in the product at greater than 3%.
CAS # OR J TRADE SECRET # CHEMICAL NAME
068953-36-6 TOFA, REACTION PRODUCTS WITH T
TS-73 TRADE SECRET - NON-HAZARDOUS
California Proposition 65:
Warning: The following ingredients present in the product are known to the state of California to cause Cancer:
CAS # OR NJ TRADE SECRET # CHEMICAL NAME
014808-60-7 SILICON DIOXIDE
012174-11-7 MAGNESIUM ALUMINUM SILICATE
Warning: The following ingredients present in the product are known to the state of California to cause birth defects,
or other reproductive hazards.
None
International Regulations:
CANADIAN WHMIS:
This MSDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16
headings.
* CANADIAN DSL:
All chemical ingredients included on inventory
* European Economic Community (EEC) EINECS Master Inventory:
All chemical ingredients included on inventory
Section 16 - Other Information
US STATE REGULATIONS CALIFORNIA: THE FOLLOWING INFORMATION IS REQUIRED BY THE STATE OF
CALIFORNIA FOR THIS PRODUCT (PROPOSITION 65) *THIS PRODUCT CONTAINS CHEMICALS KNOWN TO
THE STATE OF CALIFORNIA TO CAUSE CANCER.
HMIS Ratings:
Health: 2 Flammability: 1 Reactivity: 0 Personal Protection: X
REASON FOR REVISION: Change made in Section 14
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
Information presented herein has been compiled from sources considered to be dependable and is accurate and
reliable to the best of our knowledge and belief but is not guaranteed to be so. Nothing herein is to be construed as
recommending any practice or any product in violation of any patent or in violation of any law or regulation. It is the
user's responsibility to determine for himself the suitability of any material for a specific purpose and to adopt such
safety precautions as may be necessary. We make no warranty as to the results to be obtained in using any material
and, since conditions of use are not under our control, we must necessarily disclaim all liability with the respect to the
use of any material supplied by us.
|