SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET AA 361
Threshold Limited Value
ALDON Not established by ACGIH 1983-84.
1533 W.Henrietta Rd.
AA 361
Avon, New York 14414 MSDS No.
庐
CORPORATION January 31, 1994
Effective Date
(716) 226-6177
Effects of Overexposure May be harmful by ingestion or skin absorption. May cause skin and eye irritation.
Material is irritating to mucous membranes and upper respiratory tract. May
cause irritation. May cause allergic reaction. To the best of our knowledge, the
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
chemical, physical and toxicological properties have not been thoroughly
CHEMTREC
Product ANILINE BLUE, 1% AQUEOUS SOLUTION investigated. Exercise appropriate procedures to minimize potential hazards.
800-424-9300 1
Health
Chemical Emergency and
Aniline Blue, W. S. , Stain; C.I. 42755 Day 716-226-6177
Synonyms INHALATION AS MIST: Remove from exposure, treat symptomatically, and get
0
Fire
First Aid Procedures
Night 716-334-4222
medical attention. EYES: Immediately flush eyes with plenty of water for at least
Formula C32H25N3Na2 O9S3 /H2O 0
Reactivity 15 minutes and get medical attention if any symptoms are present after washing.
NFPA
Unit(s) Size SKIN: Immediately flush with plenty of water for at least 15 minutes and get
HAZARD RATING HMIS *
30 mL.
medical attention if any symptoms are present after washing. INGESTION: If
LEAST SLIGHT MODERATE HIGH EXTREME
C.A.S. No. 0 1 2 3 4 swallowed, if conscious, give several glasses of water to drink. Call physician
28631-66-5
immediately. Never give anything by mouth to an unconscious person.
SECTION II HAZARDOUS INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Hazardous Component(s) % TLV Units
Stability Unstable Conditions to Avoid
Aniline Blue, Water Soluble. 1% None established. Excessive temperature and heat.
Stable X
Incompatibility
Water: (CAS No. 7732-18-5) 99% None established.
Strong oxidizing materials and reducing agents.
(Materials to Avoid)
CAUTION! MAY BE HARMFUL IF SWALLOWED OR
Hazardous
ABSORBED THROUGH SKIN. MAY CAUSE IRRITATION. Carbon monoxide and carbon dioxide, nitrogen oxides, sulfur oxides.
Decomposition Products
SECTION III PHYSICAL DATA
Hazardous Polymerization Conditions to Avoid
Melting Point (掳F) Specific Gravity (H2 O = 1)
Freezes approx. 0掳C (32掳F) 1.0
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) Approx. 100掳C (212掳F) 99%
by Volume (%)
X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) 14 (water) ( n-Butyl Ac. Less than 1.
=1)
Steps to be taken in case
Vapor Density (Air=1) 0.7 (water)
material is released or spilled Absorb in vermiculite, sand, paper towels and place in a suitable
Solubility in Water container for incineration. Wash spill area with soap and water.
Complete.
Appearance & Odor Violet in color; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
SECTION IV FIRE AND EXPLOSION HAZARD DATA Waste Disposal Method These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flash Point Flammable Limits in Air Upper
Dispose of in an approved incinerator equipped with an afterburner and scrubber
(Method Used) % by Volume
Non-flammable (NA). NA -------- --------
or contract with a licensed waste disposal company.
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Use any media suitable for extinguishing supporting fire.
Media
Respiration Protection None should be needed in normal laboratory handling. If misty conditions prevail, work in
(Specify Type)
SPECIAL FIREFIGHTING ventilation hood or wear a NIOSH-approved dust mask.
None needed. No.
Local Exhaust Special
PROCEDURES
Ventilation Mechanical (General) Other
None needed. No.
This solution due to its chemical composition and/or its concentration
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
does not present any firefighting hazard.
Other Protective
Safety glasses, lab coat or apron, vented hood, proper gloves, eye wash station.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND
Store in a cool, dry place.
in Handling & Storing
EXPLOSION HAZARDS Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
There are no unusual fire and explosion hazard associated with this
Avoid contact with skin, eyes and clothing.
solution.
Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Date
Rev. No. No. 1 1/31/94 Alexander A. Piccirilli AP
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information gathered
by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these materials and the
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 safety and health of employees. * Hazardous Materials Industrial Standards.
|