SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET CC 200
TWA: Calculated: 40 ppm; 97 mg/m 3 .
Threshold Limited Value
ALDON 1533 W.Henrietta Rd.
Data for compution taken from ACGIH 1992-93.
CC 200
Avon, New York 14414 MSDS No.
庐
CORPORATION November 4, 1996
Effective Date
(716) 226-6177
Effects of Overexposure INHALATION: Prolonged exposure to high concentration or repeated exposures to low
concentrations causes CNS depression and may result in liver or kidney and possible
cardiac sensitization. EYES: Contact with eyes causes irritation and may be painful.
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE SKIN: Prolonged or repeated contact causes defatting and cracking of the skin. To the
best of our knowledge, this chemical mixture's physical and toxicological properties have
Product CARNOY鈥橲 SOLUTION
CHEMTREC not been thoroughly investigated.
3
Health
800-424-9300
Chemical
Emergency and
Carnoy鈥檚 Solution (Lebrun) INHALATION: Remove to fresh air. If not breathing, give artificial
Synonyms Fire 3
Day 716-226-6177
First Aid Procedures respiration or if breathing is difficult, give oxygen by trained personnel. Get
Formula Mixture * immediate medical attention. EYES: Flush thoroughly with water for at
Reactivity 2
NFPA least 15 minutes, lifting upper and lower eyelids occasionally. Get
HAZARD RATING HMIS * immediate medical attention. SKIN: Flush thoroughly with water, then
up to 500 mL.
Unit Size
wash with mild soap and water. INGESTION: If conscious and able to
LEAST SLIGHT MODERATE HIGH EXTREME
swallow, have victim drink several glasses of water. Call physician or
0 1 2 3 4
Mixture.
C.A.S. No.
Poison Control Center immediately. Never give anything by mouth to an
SECTION II INGREDIENTS OF MIXTURES unconscious or convulsing person.
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
1000 ppm;1880 mg/m3
*Ethyl Alcohol, Denatured: Open flame, excessive temperature and heat.
(CAS No. 64-17-5) 57%
Stable X
3
Chloroform: (CAS No. 67-66-3) 30% 10,A2 ppm; 49,A2 mg/m Incompatibility
Excessive water, strong alkalies, oxidizing materials.
(Materials to Avoid)
10 ppm, 25 mg/m 3
Acetic Acid, Glacial: (CAS No. 64-19-7) 11%
Hazardous
DANGER! FLAMMABLE! MAY BE HARMFUL IF INHALED OR SWALLOWED. CAUSES IRRITATION ON CONTACT.
CONTAINS CHLOROFORM, A SUSPECTED CARCINOGEN. CAN CAUSE ADVERSE REPRODUCTIVE EFFECTS. Phosgene, Hydrochloric Acid, Carbon Dioxide, and/or Carbon Monoxide.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Approx. -65掳C (-85掳F) 1.0 @ 20掳C
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 100%
Unknown: range 61掳-118掳C (141掳-244掳F) by Volume (%) X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) (Chloroform) 100 mm @ 10.4掳C Ether Greater than 1.
=1)
(
Steps to be taken in case
Vapor Density (Air=1) (Chloroform) 4.12
Wear suitable protective clothing and have good ventilation, absorb spill in
material is released or spilled
an inert dry material, sweep up and place in suitable container for disposal.
Solubility in Water Approximately 70 mL. Carnoy鈥檚 Solution per 100 mL. water.
Wash spill area with soap and water.
Appearance & Odor Clear, colorless liquid; mild, sweet, vinegar odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Ethyl Alcohol 16.1掳C(61掳F)c.o.c. Ethyl Alc.
% by Volume
(Method Used) Dispose of in accordance with federal, state and local regulations.
Ca 3% Ca 15%
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Water spray; carbon dioxide (CO2 ); dry chemical (ABC).
Media
None needed in normal laboratory handling. If misty conditions prevail, work in ventilation
Respiration Protection
hood or wear a NIOSH/MSHA-approved respirator.
(Specify Type)
SPECIAL FIREFIGHTING
* Denaturants: Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation
Methanol: (CAS No. 67-56-1)...2%
Recommended. No.
Mechanical (General) Other
Methyl Isobutyl Ketone: (CAS No. 108-10-1)...0.1%
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
Other Protective
In fire conditions, wear a NIOSH/MSHA-approved, self-contained breathing
Goggles, face shield, lab coat, ventilation hood, proper gloves, fire extinguisher, eye wash station.
Equipment
apparatus and full protective clothing.
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry, well-ventilated place, preferably not above 30掳C (86掳F). Wash
in Handling & Storing
EXPLOSION HAZARDS thoroughly after handling. Avoid contact with skin, eyes and mucous membranes.
Keep container tightly closed when not in use.
Fire or excessive heat may produce hazardous decomposition
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
products; can react vigorously with oxidizing materials.
Avoid breathing vapors. Use with adequate ventilation. Laboratory studies have
NOTE: Burns with a clear, almost invisible flame, especially hard
shown chloroform, a component of this product produces cancer in animals.
to see in strong sunlight.
Handle as a suspected carcinogen. Chronic exposure may cause embryo-fetal
injury. Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
(1993 EMERGENCY RESPONSE GUIDEBOOK, DOT P 5800.6, GUIDE PAGE NO. 26) Approved
Revision Date
No. 7 11/04/96 Michael Raszeja MR
Coordinator
D.O.T. DENATURED ALCOHOL, (SOLUTION), 3, NA 1987, PG III The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|