Safety data sheet
Kerocom庐 PIBSI
Revision date : 2006/06/19 Page: 1/6
Version: 1.0 (30148694/MDS_GEN_US/EN)
1. Substance/preparation and company identification
Company 24 Hour Emergency Response Information
BASF CORPORATION CHEMTREC: 1-800-424-9300
100 Campus Drive BASF HOTLINE: 1-800-832-HELP
Florham Park, NJ 07932
2. Composition/information on ingredients
CAS Number Content (W/W) Chemical name
64742-94-5 45.0 % solvent naphtha
104-76-7 5.0 % 2-ethylhexan-1-ol
50.0 % TSRN 489909-5517-PC
3. Hazard identification
Emergency overview
WARNING: COMBUSTIBLE LIQUID. PROLONGED OR REPEATED CONTACT MAY DRY SKIN AND
CAUSE IRRITATION.
PROLONGED OR REPEATED CONTACT MAY RESULT IN DERMATITIS.
HARMFUL OR FATAL IF SWALLOWED. CAN ENTER LUNGS AND CAUSE DAMAGE.
Avoid contact with the skin, eyes and clothing.
Avoid inhalation of mists/vapours.
Provide local exhaust ventilation to control vapours/mists.
Wear NIOSH-certified chemical goggles.
Wear chemical resistant protective gloves.
Wear protective clothing.
Eye wash fountains and safety showers must be easily accessible.
Potential health effects
Primary routes of exposure
Routes of entry for solids and liquids include eye and skin contact, ingestion and inhalation. Routes of entry
for gases include inhalation and eye contact. Skin contact may be a route of entry for liquified gases.
4. First-aid measures
General advice:
Immediately remove contaminated clothing.
Safety data sheet
Kerocom庐 PIBSI
Revision date : 2006/06/19 Page: 2/6
Version: 1.0 (30148694/MDS_GEN_US/EN)
If inhaled:
If difficulties occur after vapour/aerosol has been inhaled, remove to fresh air and seek medical attention.
If on skin:
Wash affected areas thoroughly with soap and water. Seek medical attention.
If in eyes:
Wash affected eyes for at least 15 minutes under running water with eyelids held open.
Seek medical attention.
If swallowed:
Immediately rinse mouth and then drink plenty of water, do not induce vomiting, seek medical attention.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no known
specific antidote.
5. Fire-fighting measures
Flash point: > 55 掳C (DIN 51755)
Autoignition: 435 掳C (DIN 51794)
Lower explosion limit: 1.3 %(V)
Upper explosion limit: 6.4 %(V)
Suitable extinguishing media:
water spray, dry extinguishing media, foam
Unsuitable extinguishing media for safety reasons:
water jet
Hazards during fire-fighting:
harmful vapours
Evolution of fumes/fog. The substances/groups of substances mentioned can be released in case of fire.
Protective equipment for fire-fighting:
Wear a self-contained breathing apparatus.
Further information:
The degree of risk is governed by the burning substance and the fire conditions. Contaminated extinguishing
water must be disposed of in accordance with official regulations.
NFPA Hazard codes:
Health : 1 Fire: 2 Reactivity: 0 Special:
6. Accidental release measures
Personal precautions:
Use personal protective clothing.
Environmental precautions:
Do not discharge into drains/surface waters/groundwater.
Cleanup:
Spills should be contained, solidified, and placed in suitable containers for disposal.
Safety data sheet
Kerocom庐 PIBSI
Revision date : 2006/06/19 Page: 3/6
Version: 1.0 (30148694/MDS_GEN_US/EN)
7. Handling and storage
Handling
General advice:
Keep away from sources of ignition - No smoking.
Protection against fire and explosion:
Take precautionary measures against static discharges.
Storage
General advice:
Keep container tightly closed and dry; store in a cool place.
8. Exposure controls and personal protection
Advice on system design:
Provide adequate exhaust ventilation to control work place concentrations.
Personal protective equipment
Respiratory protection:
Wear a NIOSH-certified (or equivalent) organic vapour/particulate respirator.
Hand protection:
Chemical resistant protective gloves
Eye protection:
Tightly fitting safety goggles (chemical goggles).
Body protection:
Impermeable protective clothing
General safety and hygiene measures:
Handle in accordance with good industrial hygiene and safety practice. Keep away from food, drink and
animal feeding stuffs. Take off immediately all contaminated clothing.
9. Physical and chemical properties
Form: liquid
Odour: product specific
Colour: amber
solidification temperature: < -30 掳C (DIN/ISO 3016)
onset of boiling: 160 掳C
Vapour pressure: 1.2 mbar ( 20 掳C)
6.3 mbar ( 50 掳C)
Density: approx. 0.92 g/cm3 ( 20 掳C)
Viscosity, kinematic: 130 mm2/s ( 20 掳C) (DIN 51562)
Solubility in water: insoluble
Solubility (qualitative): soluble
solvent(s): non-polar solvents,
10. Stability and reactivity
Hazardous reactions:
No hazardous reactions when stored and handled according to instructions.
The product is chemically stable.
Safety data sheet
Kerocom庐 PIBSI
Revision date : 2006/06/19 Page: 4/6
Version: 1.0 (30148694/MDS_GEN_US/EN)
Decomposition products:
Hazardous decomposition products: No hazardous decomposition products if stored and handled as
prescribed/indicated.
11. Toxicological information
Acute toxicity
Oral:
LD50/rat: > 2,000 mg/kg
Skin irritation:
rabbit: non-irritant (OECD Guideline 404)
Prolonged contact with the product can result in skin irritation.
Eye irritation :
rabbit: non-irritant (OECD Guideline 405)
Chronic toxicity
Other information:
The statement was derived from products of similar composition.
The product has not been tested. The statement has been derived from the properties of the individual
components.
12. Ecological information
Environmental fate and transport
Biodegradation:
Evaluation: The substance can be virtually eliminated from water in suitable effluent
treatment plants by biodegradation, stripping and mechanical separation.
Environmental toxicity
Acute and prolonged toxicity to fish:
LC50 (96 h): 1 - 10 mg/l
The product has not been tested. The statement has been derived from the properties of the individual
components.
Acute toxicity to aquatic invertebrates:
OECD Guideline 202, part 1 Daphnia magna/EC50 (48 h): > 100 mg/l
Toxicity to microorganisms:
DIN/EN/ISO 8192-OECD 209-88/302/EEC,P. C activated sludge, domestic/EC50 (34 h): > 1,000 mg/l
Inhibition of degradation activity in activated sludge is not to be anticipated during correct introduction of low
concentrations.
Other ecotoxicological advice:
Do not release untreated into natural waters.
Safety data sheet
Kerocom庐 PIBSI
Revision date : 2006/06/19 Page: 5/6
Version: 1.0 (30148694/MDS_GEN_US/EN)
13. Disposal considerations
Waste disposal of substance:
Dispose of in accordance with national, state and local regulations.
Container disposal:
Recommend crushing, puncturing or other means to prevent unauthorized use of used containers. Dispose
of in accordance with national, state and local regulations.
RCRA: D001
14. Transport information
Land transport
USDOT
Proper shipping name: FLAMMABLE LIQUID, N.O.S. (contains SOLVENT NAPHTHA)
Hazard class: 3
ID-number: UN 1993
Packing group: III
Sea transport
IMDG
Proper shipping name: FLAMMABLE LIQUID, N.O.S. (contains SOLVENT NAPHTHA)
Hazard class: 3
ID-number: UN 1993
Packing group: III
Marine pollutant: YES
Air transport
IATA/ICAO
Proper shipping name: FLAMMABLE LIQUID, N.O.S. contains (SOLVENT NAPHTHA)
Hazard class: 3
ID-number: UN 1993
Packing group: III
15. Regulatory information
Federal Regulations
Registration status:
TSCA, US released / listed
OSHA hazard category: Combustible Liquid
SARA hazard categories (EPCRA 311/312): Fire
Safety data sheet
Kerocom庐 PIBSI
Revision date : 2006/06/19 Page: 6/6
Version: 1.0 (30148694/MDS_GEN_US/EN)
State regulations
State RTK
CAS Number Chemical name State RTK
104-76-7 2-ethylhexan-1-ol MA, NJ, PA
16. Other information
Kerocom is a registered trademark of BASF Corporation or BASF AG
IMPORTANT: WHILE THE DESCRIPTIONS, DESIGNS, DATA AND INFORMATION CONTAINED HEREIN
ARE PRESENTED IN GOOD FAITH AND BELIEVED TO BE ACCURATE , IT IS PROVIDED FOR YOUR
GUIDANCE ONLY. BECAUSE MANY FACTORS MAY AFFECT PROCESSING OR APPLICATION/USE,
WE RECOMMEND THAT YOU MAKE TESTS TO DETERMINE THE SUITABILITY OF A PRODUCT FOR
YOUR PARTICULAR PURPOSE PRIOR TO USE. NO WARRANTIES OF ANY KIND, EITHER
EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE, ARE MADE REGARDING PRODUCTS DESCRIBED OR DESIGNS, DATA OR
INFORMATION SET FORTH, OR THAT THE PRODUCTS, DESIGNS, DATA OR INFORMATION MAY BE
USED WITHOUT INFRINGING THE INTELLECTUAL PROPERTY RIGHTS OF OTHERS. IN NO CASE
SHALL THE DESCRIPTIONS, INFORMATION, DATA OR DESIGNS PROVIDED BE CONSIDERED A
PART OF OUR TERMS AND CONDITIONS OF SALE. FURTHER, YOU EXPRESSLY UNDERSTAND AND
AGREE THAT THE DESCRIPTIONS, DESIGNS, DATA, AND INFORMATION FURNISHED BY BASF
HEREUNDER ARE GIVEN GRATIS AND BASF ASSUMES NO OBLIGATION OR LIABILITY FOR THE
DESCRIPTION, DESIGNS, DATA AND INFORMATION GIVEN OR RESULTS OBTAINED, ALL SUCH
BEING GIVEN AND ACCEPTED AT YOUR RISK.
END OF DATA SHEET
|