HELPING MAKE PRODUCTS BETTER鈩?
Safety data sheet
Kerocom庐 PIBA 03
Revision date : 2004/11/12 Page: 1/5
Version: 1.0 (30209221/MDS_GEN_US/EN)
1. Substance/preparation and company identification
Company 24 Hour Emergency Response Information
BASF Corporation CHEMTREC: (800) 424-9300
100 Campus Drive BASF HOTLINE: (800) 832-HELP
Florham Park, NJ 07932
Synonyms: Polyisobutyleneamine
2. Composition/information on ingredients
CAS Number Content (W/W) Chemical name
35.0 % Proprietary
65.0 % PMN92-0410
3. Hazard identification
Emergency overview
WARNING: COMBUSTIBLE LIQUID. MAY CAUSE SKIN IRRITATION.
MAY BE HARMFUL IF SWALLOWED.
MAY CAUSE PULMONARY EDEMA.
INGESTION MAY CAUSE GASTRIC DISTURBANCES.
Use with local exhaust ventilation.
Wear protective clothing.
Wear NIOSH-certified chemical goggles.
Wear a NIOSH-certified (or equivalent) organic vapour respirator.
Wear chemical resistant protective gloves.
Potential health effects
Primary routes of exposure
Routes of entry for solids and liquids include eye and skin contact, ingestion and inhalation. Routes of entry
for gases include inhalation and eye contact. Skin contact may be a route of entry for liquified gases.
4. First-aid measures
General advice:
Immediately remove contaminated clothing.
If inhaled:
If difficulties occur after vapour/aerosol has been inhaled, remove to fresh air and seek medical attention.
If on skin:
Wash affected areas thoroughly with soap and water. Seek medical attention.
If in eyes:
Flush with copious amounts of water for at least 15 minutes. Hold eyelids open to facilitate rinsing. If irritation
develops, seek immediate medical attention.
HELPING MAKE PRODUCTS BETTER鈩?
Safety data sheet
Kerocom庐 PIBA 03
Revision date : 2004/11/12 Page: 2/5
Version: 1.0 (30209221/MDS_GEN_US/EN)
If swallowed:
Immediately rinse mouth and then drink plenty of water, do not induce vomiting, seek medical attention. Do
not induce vomiting due to aspiration hazard.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no known
specific antidote, administer corticosteroid dose aerosol to prevent pulmonary
odema.
5. Fire-fighting measures
Flash point: 64 掳C
Autoignition: 230 掳C (DIN 51794)
Lower explosion limit: 0.50 %(V) (DIN 51649-1)
Upper explosion limit: 4.40 %(V) (DIN 51649-1)
Suitable extinguishing media:
dry extinguishing media, foam, carbon dioxide
Unsuitable extinguishing media for safety reasons:
water jet
Protective equipment for fire-fighting:
Firefighters should be equipped with self-contained breathing apparatus and turn-out gear.
Further information:
The degree of risk is governed by the burning substance and the fire conditions. Contaminated extinguishing
water must be disposed of in accordance with official regulations.
Vapours are heavier than air and may accumulate in low areas and travel a considerable distance up to the
source of ignition. Fight fire from maximum distance.
NFPA Hazard codes:
Health : 1 Fire: 2 Reactivity: 0 Special:
6. Accidental release measures
Personal precautions:
Use personal protective clothing.
Environmental precautions:
This product is not regulated by RCRA. This product is not regulated by CERCLA ('Superfund').
Cleanup:
For large amounts: Pump off product.
For residues: Pick up with suitable absorbent material. Dispose of absorbed material in accordance with
regulations.
Further information:
High risk of slipping due to leakage/spillage of product.
HELPING MAKE PRODUCTS BETTER鈩?
Safety data sheet
Kerocom庐 PIBA 03
Revision date : 2004/11/12 Page: 3/5
Version: 1.0 (30209221/MDS_GEN_US/EN)
7. Handling and storage
Handling
General advice:
No special measures necessary provided product is used correctly.
Protection against fire and explosion:
Take precautionary measures against static discharges.
Storage
General advice:
Keep container tightly closed and dry; store in a cool place.
8. Exposure controls and personal protection
Personal protective equipment
Respiratory protection:
Wear respiratory protection if ventilation is inadequate. Respiratory protection in case of vapour/aerosol
release.
Hand protection:
Chemical resistant protective gloves
Eye protection:
Wear safety goggles (chemical goggles) if there is potential for airborne dust exposures.
Body protection:
Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting boots,
chemical-protection suit (according to DIN-EN 465).
General safety and hygiene measures:
Handle in accordance with good industrial hygiene and safety practice.
9. Physical and chemical properties
Form: liquid
Odour: faint odour
Colour: yellowish
solidification temperature: < -30 掳C
onset of boiling: 190 掳C
Vapour pressure: 0.5 mbar ( 20 掳C)
Density: 0.842 g/cm3 ( 20 掳C)
Viscosity, kinematic: 127 mm2/s ( 20 掳C) (DIN 51562)
Solubility in water: ( 15 掳C) insoluble
Solubility (qualitative): soluble
solvent(s): non-polar solvents,
10. Stability and reactivity
Hazardous reactions:
The product is chemically stable.
HELPING MAKE PRODUCTS BETTER鈩?
Safety data sheet
Kerocom庐 PIBA 03
Revision date : 2004/11/12 Page: 4/5
Version: 1.0 (30209221/MDS_GEN_US/EN)
Decomposition products:
Hazardous decomposition products: No hazardous decomposition products if stored and handled as
prescribed/indicated.
11. Toxicological information
Acute toxicity
Oral:
LD50/rat: > 2,000 mg/kg
Skin irritation:
rabbit: Irritant.
Eye irritation :
rabbit: non-irritant
Chronic toxicity
Other information:
The product has not been tested. The statement has been derived from products of a similar structure and
composition.
12. Ecological information
Environmental fate and transport
Biodegradation:
Evaluation: The product is not very soluble in water and can thus be removed from
water mechanically in suitable effluent treatment plts.
Environmental toxicity
Acute and prolonged toxicity to fish:
zebra fish/LC50 (96 h): 10 - 100 mg/l
Toxicity to microorganisms:
bacterium/EC10 (0.5 h): 1,400 mg/l
Inhibition of degradation activity in activated sludge is not to be anticipated during correct introduction of low
concentrations.
Other ecotoxicological advice:
The product has not been tested. The statement has been derived from products of a similar structure and
composition.
13. Disposal considerations
Waste disposal of substance:
Dispose of in accordance with national, state and local regulations.
Do not discharge into waterways or sewer systems without proper authorization.
HELPING MAKE PRODUCTS BETTER鈩?
Safety data sheet
Kerocom庐 PIBA 03
Revision date : 2004/11/12 Page: 5/5
Version: 1.0 (30209221/MDS_GEN_US/EN)
Contaminated packaging:
Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent unauthorized
use of used containers.
14. Transport information
Reference Bill of Lading
15. Regulatory information
Federal Regulations
Registration status:
TSCA, US released / listed
16. Other information
HMIS III rating
Health: 1 Flammability: 2 Physical hazard: 0
HMIS uses a numbering scale ranging from 0 to 4 to indicate the degree of hazard. A value of zero means that the
substance possesses essentially no hazard; a rating of four indicates high hazard.
Local contact information
N-EVN_Regulatory@BASF-Corp.com
Kerocom is a registered trademark of BASF Corporation or BASF AG
IMPORTANT: WHILE THE DESCRIPTIONS, DESIGNS, DATA AND INFORMATION CONTAINED HEREIN
ARE PRESENTED IN GOOD FAITH AND BELIEVED TO BE ACCURATE , IT IS PROVIDED FOR YOUR
GUIDANCE ONLY. BECAUSE MANY FACTORS MAY AFFECT PROCESSING OR APPLICATION/USE,
WE RECOMMEND THAT YOU MAKE TESTS TO DETERMINE THE SUITABILITY OF A PRODUCT FOR
YOUR PARTICULAR PURPOSE PRIOR TO USE. NO WARRANTIES OF ANY KIND, EITHER
EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE, ARE MADE REGARDING PRODUCTS DESCRIBED OR DESIGNS, DATA OR
INFORMATION SET FORTH, OR THAT THE PRODUCTS, DESIGNS, DATA OR INFORMATION MAY BE
USED WITHOUT INFRINGING THE INTELLECTUAL PROPERTY RIGHTS OF OTHERS. IN NO CASE
SHALL THE DESCRIPTIONS, INFORMATION, DATA OR DESIGNS PROVIDED BE CONSIDERED A
PART OF OUR TERMS AND CONDITIONS OF SALE. FURTHER, YOU EXPRESSLY UNDERSTAND AND
AGREE THAT THE DESCRIPTIONS, DESIGNS, DATA, AND INFORMATION FURNISHED BY BASF
HEREUNDER ARE GIVEN GRATIS AND BASF ASSUMES NO OBLIGATION OR LIABILITY FOR THE
DESCRIPTION, DESIGNS, DATA AND INFORMATION GIVEN OR RESULTS OBTAINED, ALL SUCH
BEING GIVEN AND ACCEPTED AT YOUR RISK.
END OF DATA SHEET
|