Monday, January 28, 2008
Page 1 of 4
MSDS - Material Safety Data Sheet
Product Name: ENGINE CLEANER
MSDS No.: AEC1
I. Basic Information:
Manufacturer: RADIATOR SPECIALTY COMPANY
2
Address: 600 RADIATOR ROAD
City, ST Zip: INDIAN TRAIL, NC 28079
2 1
Emergency Contact: Rocky Mountain Poision Control Center
Emergency Telephone Number: 303-623-5716
Contact: Robert Geer
Information Telephone Number: 704-684-1811
2
2
Last Update: 11/03/2003 Expiration Date:
1
X Liquid Gas Solid
Chemical State:
C
Pure Mixture
Chemical Type: X
II. Ingredients:
Trade Secret
EHS IARC SARA
313 OSHA ACGIH Other
% Range NTP SUB Z PEL TLV Limits
CAS No. Chemical Name
X
111-76-2 2-Butoxyethanol 2-10 25 ppm 25 ppm
X
64742-95-6 Aromatic Petroleum Naphtha 2-10 N/E N/E 25 ppm
75-28-5 Isobutane 2-10 1000 ppm 1000 ppm
8008-20-6 Petroleum Base Oil 2-10 100 ppm 100 ppm
74-98-6 Propane 2-10 N/E 1000 ppm
III. Hazardous Identification:
Hazard Category:
X Acute Chronic X Fire X Pressure Reactive
Hazardous Identification Information:
Danger: Harmful or Fatal if Swallowed, Eye and Skin Irritant. Contents Under Pressure.
Level 2 Aerosol
IV. First Aid Measures:
Route(s) of Entry:
Absorption, Eye, Inhalation, and Ingestion.
Health Hazards (Acute and Chronic):
See signs and symptoms below
Signs and Symptoms:
Eye Contact: Direct spray of vapors may be irritating or harmful to eyes.
Skin Contact: Product may cause irritation due to defatting of skin.
Inhalation: High concentration of vapors may irritate nose and throat and cause headaches and nausea.
Ingestion: Can cause irritation, gastric disturbances, and nausea..
Monday, January 28, 2008
Page 2 of 4
MSDS - Material Safety Data Sheet
Product Name: ENGINE CLEANER
MSDS No.: AEC1
Medical Conditions Generally Aggravated by Exposure:
None Known
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with water for 15 minutes while lifting upper and lower eyelid. Get prompt medical attention. .
Skin Contact: Wash with soap and water. If irritation persists, get prompt medical attention.
Inhalation: Move to fresh air. If breathing becomes difficult get prompt medical attention.
Ingestion: Drink water or milk. Call Poison Control Center, physician, or hospital emergency room immediately.
Other Health Warnings:
Vomiting and subsequent aspiration into the lungs may lead to chemical pneumonia and pulmonary edema which is a potentially
fatal condition.
V. Fire Fighting Measures:
Flash Point: 15 Lower Explosive Limit: N/D Upper Explosive Limit: N/D
F.P. Method: TCC
Fire Extinguishing Media: Water Fog, Foam, Carbon Dioxide, Dry Chemical
Special Fire Fighting Procedures:
Wear self-contained positive pressure breathing apparatus and protective clothes. Cool containers with a water fog. Do not use
forced water stream as this could cause the fire to spread. Use shield to protect from rupturing and venting containers.
Unusual Fire and Explosion:
Contents under pressure. Exposure to temperatures above 120掳 may cause containers to vent, rupture or burst violently.
VI. Accidental Release Measures:
Steps to be Taken in Case Material is Released or Spilled:
Eliminate all ignition sources. Persons not wearing protective equipment should be excluded from area of spill until clean-up has
been completed. Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds, rags,
etc). Using a non-metalic scoop, place contaminated material into an approved chemical waste container. Where possible,
vacuum spilled liquid using an explosion proof vacuum to recover material. Prevent run-off to sewers, streams, or other bodies of
water. If run-off occurs, notify proper authorities as required that a spill has occured.
VII. Handling and Storage:
Precautions to be Taken:
Use with adequate ventilation and proper protective equipment.
Store in cool, well ventilated area below 120掳F away from heat sources. Do not use near fire, sparks, or open flame. Exposure to
sunlight and temperatures above 120掳 may cause container to vent, rupture, or burst. Do not puncture or incinerate container.
Other Precautions:
Do not used in confined area without proper ventilation. Contact lenses may cause further damage in case of splash into eye.
KEEP AWAY FROM CHILDREN AND ANIMALS!
VIII. Exposure Controls/Personal Protection:
Ventilation Requirements:
See Section 2 for applicable exposure limits. Use with adequate ventilation. If TLV is exceeded, wear NIOSH approved respirator.
Personal Protective Equipment:
See Section 2 for applicable exposure limits. For prolonged exposure wear protective safety glasses, gloves, and apron.
Monday, January 28, 2008
Page 3 of 4
MSDS - Material Safety Data Sheet
Product Name: ENGINE CLEANER
MSDS No.: AEC1
IX. Physical and Chemical Properties:
Boiling Point: N/D Melting Point: N/A
Evaporation Rate (Butyl Acetate = 1): <1 Vapor Pressure (mm Hg.): N/D
Specific Gravity (H20 = 1): 0.97500 Vapor Density (AIR = 1): 1.1
Solubility In Water: Soluble Appearance and Odor:
Hazy creamy liquid with sweet aromatic odor
Other Information: pH: 9-10
X. Stability and Reactivity:
Stability:
Stable
Incompatibility (Materials to Avoid):
Oxidizing agents and acids. Keep away from high temperatures or open flames.
Decomposition/By Products:
Normal products of combustion, carbon monoxide, carbon dioxide and Nitrogen oxides.
Hazardous Polymerization:
Will not occur
XI. Toxicological Information:
N/D
XII. Ecological Information:
N/D
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in aerosol recycling centers when empty. Before offering for recycling, empty the can
by using the product according to the label. DO NOT PUNCTURE! If recycling is not available, wrap the container and discard in
the trash. Dispose of unused product in accordance with all local, state government and federal laws and regulations.
XIV. Transport Information:
Monday, January 28, 2008
Page 4 of 4
MSDS - Material Safety Data Sheet
Product Name: ENGINE CLEANER
MSDS No.: AEC1
Shipping Name: Consumer Commodity
DOT Hazard Class: ORM-D
The DOT description is provided to assist in the proper shipping classification of this product and may not be suitable for
international and air shipping purposes.
ICAO/IATA (US)
UN number: UN1950
Shipping Name: Aerosols
Class: 2.1
International:
ICAO/IATA
UN number: UN1950
Shipping Name: Aerosols
Class: 2.1
IMDG
UN number: UN1950
Shipping Name: Aerosols
Class: 2.1
EMS: F-D, S-U
XV. Regulatory Information:
See Section 2 for SARA Reportable Chemicals.
USA TSCA: All components of this material are listed on the US TSCA Inventory.
XVI. Other Information:
Do not used in confined area without proper ventilation. Contact lenses may cause further damage in case of splash into eye.
KEEP AWAY FROM CHILDREN AND ANIMALS!
N/E: Not Established
N/D: Not Determined
N/A: Not Applicable
N/AV: Not Available
While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the
data and we expressly disclaim all liability for reliance thereon. The data is offered solely for information, investigation, and
verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or
disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.
|