Thursday, March 13, 2008
Page 1 of 4
MSDS - Material Safety Data Sheet
Product Name: COOLING SYSTEM STOP LEAK ALUMINIZED
FORMULA (POWDER)
MSDS No.: C501V
I. Basic Information:
Manufacturer: RADIATOR SPECIALTY COMPANY Contact: Robert Geer
Address: 600 RADIATOR ROAD Information Telephone Number: 704-684-1811
City, ST Zip: INDIAN TRAIL, NC 28079 Emergency Contact: Rocky Mountain Poision Control Center
Country: Emergency Telephone Number: 303-623-5716
Emergency Restrictions:
Product Name: COOLING SYSTEM STOP LEAK ALUMINIZED FORMULA (POWDER)
MSDS No.: C501V
Issue Date: 03/13/2008
Supersedes Date: 11/03/2003
II. Hazards Identification:
EMERGENCY OVERVIEW
Eye Irritant
OSHA Regulatory Status
While this material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200), this MSDS contains valuable
information critical to the safe handling and proper use of the product.
Potential Health Effects
Route(s) of Entry:
Inhalation, ingestion
Health Hazards (Acute and Chronic):
See signs and symptoms below
Signs and Symptoms:
Eye Contact: May cause eye irritation
Skin Contact: Prolonged contact with product may cause irritation due to defatting of skin.
Inhalation: High concentration of vapors may irritate nose and throat and cause headaches and nausea.
Ingestion: Call Poison Control Center, Physician, or Hospital Emergency Room Immediately.
Medical Conditions Generally Aggravated by Exposure:
None known
Other Health Warnings:
None known
Potential Environmental Effects
Not Available
III. Composition/Information on Ingredients:
Chemical Name CAS No. % Range Trade Secret
1-(3-Chloroallyl)-3,5,7-triaza-1-azoniaadamantane 4080-31-3 0.1 - 1.0
chloride
Aluminum (fume or dust) 7429-90-5 1.0 - 5.0
Aluminum oxide (fibrous forms) 1344-28-1 0.1 - 1.0
Jojoba Meal 977011-04-3 60.0 - 100.0
Soap Powder, Tallow 8052-48-0 7.0 - 13.0
Thursday, March 13, 2008
Page 2 of 4
MSDS - Material Safety Data Sheet
Product Name: COOLING SYSTEM STOP LEAK ALUMINIZED
FORMULA (POWDER)
MSDS No.: C501V
IV. First Aid Measures:
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with water for 15 minutes while lifting upper and lower eyelid. Get prompt medical attention. .
Skin Contact: Wash with soap and water. If irritation persists, get prompt medical attention.
Inhalation: Move to fresh air. If breathing becomes difficult, give oxygen and get prompt medical attention.
Ingestion: Drink water or milk. Do not induce vomiting. Call Poison Control Center, physician, or hospital emergency room immediately.
Note to Physicians:
N/E
V. Fire Fighting Measures:
Suitable Extinguishing Media:
Water Fog, Foam, Carbon Dioxide, Dry Chemical
Unsuitable Extinguishing Media:
None
Products of Combustion:
Normal products of combustion; carbon monoxide, carbon dioxide, and smoke of sulfur
Protection of Firefighters:
Wear self-contained positive pressure breathing apparatus and protective clothes.
VI. Accidental Release Measures:
Personal Precautions:
No Data
Environmental Precautions:
No Data
Methods for Containment:
Follow procedure listed under Methods for Cleanup.
Methods for Cleanup:
Sweep up contaminated material into an approved chemical waste container.
Other Information:
No Data
VII. Handling and Storage:
Handling Precautions:
Store in cool place away from oxidizers
Storage Precautions:
N/D
VIII. Exposure Controls/Personal Protection:
Thursday, March 13, 2008
Page 3 of 4
MSDS - Material Safety Data Sheet
Product Name: COOLING SYSTEM STOP LEAK ALUMINIZED
FORMULA (POWDER)
MSDS No.: C501V
Chemical Name OSHA PEL ACGIH TLV Other Limits
Jojoba Meal Not Available Not Available Not Available
Aluminum oxide (fibrous forms) Not Available Not Available Not Available
Aluminum (fume or dust) 5 mg/m3 5 mg/m3 Not Available
Soap Powder, Tallow Not Available Not Available Not Available
1-(3-Chloroallyl)-3,5,7-triaza-1-azoniaadamantane Not Available Not Available Not Available
chloride
Engineering Controls:
See Section 2 for applicable exposure limits. Use with adequate ventilation. If TLV is exceeded, wear NIOSH approved respirator.
Personal Protective Equipment:
For bulk handling use goggles, dust mask and gloves.
IX. Physical and Chemical Properties:
Boiling Point: N/A Melting Point: N/A
Boiling Range: Not Available Freezing Point: Not Available
Solubility In Water: Disperses Evaporation Rate (Butyl Acetate = 1): N/A
Flash Point: N/A Flash Point Method: N/A
Odor Threshold: Not Available Appearance and Odor: Silver colored de-dusted powder. Bland
odor.
Vapor Density (AIR = 1): N/A Vapor Pressure (mm Hg.): N/A
pH Range: Not Available Not Available
Partition Coefficient:
Not Available Auto-Ignition Temp: Not Available
Decomposition Temp:
Lower Explosive Limit: N/A Upper Explosive Limit: N/A
Specific Gravity (H20 = 1): Not Available
Other Information: N/D
X. Stability and Reactivity:
Stability:
Stable
Conditions to Avoid:
See Incompatible Materials below
Incompatible Materials:
Oxidizing agents.
Hazardous Decomposition Products:
Normal products of combustion; carbon monoxide, carbon dioxide, and smoke of sulfur oxides.
Possibility of Hazardous Reactions:
Will not occur
XI. Toxicological Information:
No data available.
Thursday, March 13, 2008
Page 4 of 4
MSDS - Material Safety Data Sheet
Product Name: COOLING SYSTEM STOP LEAK ALUMINIZED
FORMULA (POWDER)
MSDS No.: C501V
XII. Ecological Information:
No data available
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or bottle by using the
product according to the label. If recycling is not available, wrap the container and discard in the trash. Dispose of unused product in accordance
with all local, state government and federal laws and regulations
XIV. Transport Information:
Shipping Name: Not Available
DOT Hazard Class: Not Available DOT Subsidiary Hazard Class: Not Available
UN/NA#: Not Available Not Available
Packing Group:
Transportation Information:
DOT Shipping Name: Not DOT regulated.
DOT Hazard Class: None
XV. Regulatory Information:
See Section 2 for SARA Reportable Chemicals.
USA TSCA: All components of this material are listed on the US TSCA Inventory.
XVI. Other Information:
Liquid Gas Solid
Chemical State: X
Pure Mixture
Chemical Type: 0
X
Hazard Category: 1 1
Acute Chronic Fire
X
Pressure Reactive
Additional Manufacturer Warnings:
Do not used in confined area without proper ventilation. Contact lenses 1
may cause further damage in case of splash into eye. KEEP AWAY FROM
0
CHILDREN AND ANIMALS!
1
N/E: Not Established
N/D: Not Determined
N/A: Not Applicable
N/AV: Not Available
Additional Product Information:
While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the
data and we expressly disclaim all liability for reliance thereon. The data is offered solely for information, investigation, and
verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or
disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.
|