Wednesday, June 15, 2005
Page 1 of 3
MSDS - Material Safety Data Sheet
Product Name: M-P RADIATOR SEALANT
MSDS No.: C105
I. Basic Information:
Manufacturer: RADIATOR SPECIALTY COMPANY
0
Address: 600 RADIATOR ROAD
City, ST Zip: INDIAN TRAIL, NC 28079
2 0
Emergency Contact: Rocky Mountain Poision Control Center
Emergency Telephone Number: 303-623-5716
Contact: Robert Geer
Information Telephone Number: 704-688-3430
2
0
Last Update: 06/15/2005
0
X Liquid Gas Solid
Chemical State:
E
Pure Mixture
X
Chemical Type:
II. Ingredients:
Trade Secret
EHS IARC SARA
313 OSHA ACGIH Other
% Range NTP SUB Z PEL TLV Limits
CAS No. Chemical Name
1303964 Borates, tetra, sodium salts - 5.0 - 10.0 N/E 5 mg/m3
decahydrate
III. Hazardous Identification:
Hazard Category:
X Acute Chronic Fire Pressure Reactive
Hazardous Identification Information:
Caution: eye and skin irritant. Harmful if swallowed.
IV. First Aid Measures:
Route(s) of Entry:
Absorption, inhalation and Ingestion.
Health Hazards (Acute and Chronic):
See signs and symptoms below
Signs and Symptoms:
Eye Contact: Direct spray of vapors may be irritating or harmful to eyes.
Skin Contact: Product may cause irritation.
Inhalation: High concentration of vapors may irritate nose and throat and cause headaches and nausea.
Ingestion: Can cause irritation, gastric disturbances, and nausea..
Medical Conditions Generally Aggravated by Exposure:
None known
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with water for 15 minutes while lifting upper and lower eyelids and get prompt medical attention.
.
Skin Contact: Wash with soap and water. If irritation persists, get prompt medical attention.
Inhalation: Move to fresh air. If breathing becomes difficult get prompt medical attention.
Ingestion: Do not induce vomiting. Call Poison Control Center, physician, or hospital emergency room immediately.
Wednesday, June 15, 2005
Page 2 of 3
MSDS - Material Safety Data Sheet
Product Name: M-P RADIATOR SEALANT
MSDS No.: C105
Other Health Warnings:
None Known
V. Fire Fighting Measures:
Flash Point: None Lower Explosive Limit: N/A Upper Explosive Limit: N/A
F.P. Method: N/A
Fire Extinguishing Media: Water Fog, Foam, Carbon Dioxide, Dry Chemical
Special Fire Fighting Procedures:
Wear self-contained positive pressure breathing apparatus and protective clothes.
Unusual Fire and Explosion:
None known
VI. Accidental Release Measures:
Steps to be Taken in Case Material is Released or Spilled:
Use appropiate protective equipment. Contain spill and then absorb spill with inert material or rags and scoop into a chemical
waste container. Neutralize remaining traces of material and flush with water followed by liberal covering with sodium bicarbonate.
All clean-up material should be removed and placed in approved containers for disposal. Rinse water may be disposed of down a
sanitary sewer system if authorized by the local municipality.
VII. Handling and Storage:
Precautions to be Taken:
Do not store near acids. For use with bulk materiial, use with adequate ventilation and proper protective equipment.
Other Precautions:
Keep container closed tightly when not in use.
VIII. Exposure Controls/Personal Protection:
Ventilation Requirements:
See Section 2 for applicable exposure limits.
Personal Protective Equipment:
For prolonged exposure to the material, wear safety glasses, gloves, and apron.
IX. Physical and Chemical Properties:
Boiling Point: 212掳F Melting Point: N/A
Evaporation Rate (Butyl Acetate = 1): N/D Vapor Pressure (mm Hg.): N/D
Specific Gravity (H20 = 1): 1.10000 Vapor Density (AIR = 1): N/D
Solubility In Water: Soluble Appearance and Odor: Greenish slurry with mild odor
Other Information: pH: 8 -9
VOC Content: 0%
Wednesday, June 15, 2005
Page 3 of 3
MSDS - Material Safety Data Sheet
Product Name: M-P RADIATOR SEALANT
MSDS No.: C105
X. Stability and Reactivity:
Stability:
Stable
Incompatibility (Materials to Avoid):
Avoid contact with acids.
Decomposition/By Products:
Oxides of Carbon, Nitrogen, and Sulfur.
Hazardous Polymerization:
Will not occur
XI. Toxicological Information:
N/D
XII. Ecological Information:
N/D
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or
bottle by using the product according to the label. If recycling is not available, wrap the container and discard in the trash. Dispose
of unused product in accordance with all local, state government and federal laws and regulations
XIV. Transport Information:
DOT Shipping Name: Not DOT regulated.
DOT Hazard Class: None
XV. Regulatory Information:
See Section 2 for SARA Reportable Chemicals.
USA TSCA: All components of this material are listed on the US TSCA Inventory.
XVI. Other Information:
Contact lenses may cause further damage in case of splash into eye. KEEP AWAY FROM CHILDREN AND ANIMALS!
N/E: Not Established
N/D: Not Determined
N/A: Not Applicable
N/AV: Not Available
While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the
data and we expressly disclaim all liability for reliance thereon. The data is offered soley for information, investigation, and
verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or
disposal of this product which may not be covered by this MSDS. The user is repsonsible for full compliance.
|