Thursday, August 28, 2008
Page 1 of 5
MSDS - Material Safety Data Sheet
Product Name: CARBURETOR AND PARTS CLEANER (UPC:
078698330372)
MSDS No.: CC349
I. Basic Information:
Manufacturer: RADIATOR SPECIALTY COMPANY Contact: Robert Geer
Address: 600 RADIATOR ROAD Information Telephone Number: 704-684--181 1
City, ST Zip: INDIAN TRAIL, NC 28079 Emergency Contact: Rocky Mountain Poision Control Center
Country: Emergency Telephone Number: 303-623-5716
Emergency Restrictions:
Product Name: CARBURETOR AND PARTS CLEANER (UPC: 078698330372)
MSDS No.: CC349
Issue Date: 08/28/2008
Supersedes Date: 10/27/2006
II. Hazards Identification:
EMERGENCY OVERVIEW
Danger: Combustible. Harmful or fatal if swallowed. Eye and Skin Irritant.
OSHA Regulatory Status
This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Potential Health Effects
Route(s) of Entry:
Absorption, Inhalation, and Ingestion.
Health Hazards (Acute and Chronic):
See Signs and Symptoms
Signs and Symptoms:
Eye Contact: Irritant. Prolonged contact may cause conjunctivitis.
Skin Contact: Irritant. Defatting of tissue, dermatitis may occur.
Inhalation: Irritating to the respiratory tract. . Repeated exposure may cause narcosis..
Ingestion: HARMFUL OR FATAL IF SWALLOWED.
Medical Conditions Generally Aggravated by Exposure:
None known
Other Health Warnings:
Vomiting and subsequent aspiration into the lungs may lead to chemical pneumonia and pulmonary edema which is a potentially fatal condition.
Potential Environmental Effects
Not Available
III. Composition/Information on Ingredients:
Chemical Name CAS No. % Range Trade Secret
Petroleum naphtha 64742-94-5 10.0 - 30.0
1,2,4-Trimethylbenzene 95-63-6 1-5
2-Butoxyethanol 111-76-2 10.0 - 30.0
Naphthalene 91-20-3 1-5
Petroleum Distillate, Hydrotreated Middle 64742-46-7 10.0 - 30.0
Sodium Glucohrptonate 31138-65-5 0.1 - 1.0
Tall Oil Fatty Acid 61790-12-3 5.0 - 10.0
Triethanolamine 102-71-6 1-5
Thursday, August 28, 2008
Page 2 of 5
MSDS - Material Safety Data Sheet
Product Name: CARBURETOR AND PARTS CLEANER (UPC:
078698330372)
MSDS No.: CC349
IV. First Aid Measures:
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with clean water for 15 minutes while lifting eyelids. Get prompt medical attention.
Skin Contact: Wash with soap and water thoroughly. If irritation persist, get prompt medical attention. Launder contaminated clothing before
reuse.
Inhalation: Remove to fresh air. If breathing becomes difficult get prompt medical attention.
Ingestion: DO NOT INDUCE VOMITING! Call Poison Control Center, physician, or hospital emergency room immediately.
Note to Physicians:
N/D
V. Fire Fighting Measures:
Suitable Extinguishing Media:
Water Fog, Foam, Carbon Dioxide, Dry Chemical
Unsuitable Extinguishing Media:
Do not use forced water stream as this could cause the fire to spread.
Products of Combustion:
Products of combustion: carbon oxides, oxides of nitrogen, smoke.
Protection of Firefighters:
Wear self-contained positive pressure breathing apparatus and protective clothes. At elevated temperatures containers may vent, rupture or burst,
even violently
VI. Accidental Release Measures:
Personal Precautions:
Persons not wearing protective equipment should be excluded from area of spill until clean-up has been completed.
Environmental Precautions:
Prevent run-off to sewers, streams, or other bodies of water. If run-off occurs, notify proper authorities as required that a spill has occurred. Run off
to sewer may create fire or explosion hazard.
Methods for Containment:
Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds, rags, etc).
Methods for Cleanup:
Using a non-metalic scoop, place contaminated material into an approved chemical waste container. Where possible, vacuum spilled liquid using
an explosion proof vacuum to recover material.
Other Information:
Prevent run-off to sewers, streams, or other bodies of water. If run-off occurs, notify proper authorities as required that a spill has occured.
VII. Handling and Storage:
Handling Precautions:
Use with adequate ventilation and proper protective equipment.
Do not use or store near fire, sparks, or open flame.
Storage Precautions:
Keep container closed tightly when not in use. CAUTION: Combustible.
Store in a cool place away from ignition sources and oxidizing agents.
VIII. Exposure Controls/Personal Protection:
Thursday, August 28, 2008
Page 3 of 5
MSDS - Material Safety Data Sheet
Product Name: CARBURETOR AND PARTS CLEANER (UPC:
078698330372)
MSDS No.: CC349
Chemical Name OSHA PEL ACGIH TLV Other Limits
Petroleum naphtha N/E N/E 100 ppm
2-Butoxyethanol 25 ppm 25 ppm Not Available
Triethanolamine N/E 5 mg/m3 Not Available
Naphthalene 10 ppm 10 ppm Not Available
1,2,4-Trimethylbenzene N/E 25 ppm Not Available
Sodium Glucohrptonate N/E N/E Not Available
Tall Oil Fatty Acid N/E 10 mg/m3 Not Available
Petroleum Distillate, Hydrotreated Middle 5 mg/m3 5 mg/m3 Not Available
Engineering Controls:
See above Section for applicable exposure limits. Maintain adequate ventilation.
Avoid breathing vapors. In restricted areas, use respirator with approved chemical filters designed to remove vapor. In confined areas, use
approved air line type respirator or hood. A self-contained breathing apparatus is required for vapor concentrations above TLV limit
Personal Protective Equipment:
For prolonged exposure wear protective goggles, gloves, and apron.
IX. Physical and Chemical Properties:
Boiling Point: > 212 F Melting Point: N/D
Boiling Range: N/D Freezing Point: N/D
Solubility In Water: Emulsifies Evaporation Rate (Butyl Acetate = 1): N/D
Flash Point: 146掳 F Flash Point Method: TCC
Odor Threshold: N/D Appearance and Odor: Clean amber color liquid, aromatic
solvent odor.
Vapor Density (AIR = 1): N/D Vapor Pressure (mm Hg.): < 1.0 mm Hg @ 20掳C
pH Range: Not Available N/D
Partition Coefficient:
Decomposition Temp: N/D Auto-Ignition Temp: N/D
Lower Explosive Limit: N/D Upper Explosive Limit: N/D
Specific Gravity (H20 = 1): 0.92
Other Information: VOC Contents: <45% (Wt)
X. Stability and Reactivity:
Stability:
Stable
Conditions to Avoid:
See Incompatible Materials below.
Incompatible Materials:
Strong oxidizing agents
Hazardous Decomposition Products:
Products of combustion: carbon oxides, oxides of nitrogen, smoke
Possibility of Hazardous Reactions:
Will not occur
Thursday, August 28, 2008
Page 4 of 5
MSDS - Material Safety Data Sheet
Product Name: CARBURETOR AND PARTS CLEANER (UPC:
078698330372)
MSDS No.: CC349
XI. Toxicological Information:
N/D
XII. Ecological Information:
N/D
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or bottle by using the
product according to the label. If recycling is not available, wrap the container and discard in the trash. Dispose of unused product in accordance
with all local, state government and federal laws and regulations
XIV. Transport Information:
Shipping Name: Not Available
DOT Hazard Class: Not Available DOT Subsidiary Hazard Class: Not Available
UN/NA#: Not Available Not Available
Packing Group:
Transportation Information:
DOT Shipping Name: Not DOT regulated.
DOT Hazard Class: None
The DOT description is provided to assist in the proper shipping classification of this product and may not be suitable for international and air
shipping purposes.
XV. Regulatory Information:
SARA 313 Reportable Chemicals.
Petroleum Naphtha (64742-94-5)
2 Butoxyethanol (111-76-2)
Naphthalene (91-20-3)
1,2,4 Trimethyl benzene (95-63-6)
USA TSCA: All components of this material are listed on the US TSCA Inventory.
Warning: This product contains a chemical known to the State of California to cause cancer.
State RTK Chemicals;
2 Butoxyethanol (111-76-2)
Naphthalene (91-20-3)
XVI. Other Information:
Liquid Gas Solid
Chemical State: X
Pure Mixture
Chemical Type: 2
X
Hazard Category: 2 0
Acute Chronic Fire
X X X
Pressure Reactive
Thursday, August 28, 2008
Page 5 of 5
MSDS - Material Safety Data Sheet
Product Name: CARBURETOR AND PARTS CLEANER (UPC:
078698330372)
MSDS No.: CC349
Additional Manufacturer Warnings:
Do not used in confined area without proper ventilation. Contact lenses 2
may cause further damage in case of splash into eye. KEEP AWAY FROM
2
CHILDREN AND ANIMALS!
0
N/E: Not Established
N/D: Not Determined C
N/A: Not Applicable
N/AV: Not Available
Additional Product Information:
While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the
data and we expressly disclaim all liability for reliance thereon. The data is offered solely for information, investigation, and
verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or
disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.
|