Fire
HAZARD RATING
MATERIAL SAFETY DATA SHEET
0 Reactivity
4-EXTREME
3 0
3-HIGH (Prepared according to 29 CFR 1910. 1200)
2-MODERATE Health COR
Date Prepared: 2-18-03
1-SLIGHT Special
0-INSIGNIFICANT
SECTION 1 - PRODUCT IDENTIFICATION
Emergency Telephone No.
Morven Industries, Inc.
Company Name 800-424-9300
5700 Lake Worth Rd. Suite 108 Lake Worth, FL 33463
Address Information Telephone No. 561-649-6555
Product Name / ID# Product Type All Temp Mach. Deterg. X Proprietory Product
Dish Blitz (166)
SECTION 2 - HAZARDOUS INGREDIENTS
Chemical Name/Common Name Cas No. Percent (optional) TLV (Source)
Sodium Hydroxide 1310-73-2 < 20% C2mg/m3 (ACGIH)
X Contains no substances
* Substances - subject to the reporting requirements of SARA 313 and 40 CFR Part 372.
SECTION 3 - PHYSICAL DATA
Boiling Point (掳F) 卤 0.005 pH
> 212掳F Specific Gravity (H2O=1.0) 14.0 卤 0.5
1.174 0%
% VOC (ww)
Solubility In Water X Complete Insoluble Emulsifiable or (Dispersible) Slight (or Partial)
NE NE
Evaporation Rate (vs H O) X
Faster Slower About the Same Vapor Pressure Vapor Density
2
Appearance and Odor Clear, colorless, liquid. Nil odor.
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
Flammable Limits
Flash Point (T.C.C.) X None to boiling Upper NA Lower NA
Extinguishing Media NA
Special Fire Fighting Procedures NA
Unusual Fire Explosion Hazards NA
SECTION 5 - REACTIVE DATA
Stability Stable Acids; Aluminum, Tin, Zinc; Nitro Carbons, Halo Carbons.
Incompatibility
Hazardous Decomposition Products Hydrogen gas by reaction with Aluminum, Tin or Zinc metals.
SECTION 6 - HEALTH HAZARDS
Primary routes of
Threshold Limit Value Product
X None Established Not Applicable X Eyes X Skin X Oral X Inhalation
See Section 2 for Ingredients TLV Exposure
Corrosive to all human tissue. Can cause burns. Ingestion may cause violent pain in
Signs Symptoms of Over-exposure (Acute)
throat and damage gastro respiratory tract. Inhalation of mist may cause damage to upper respiratory tract with possible
chemical pneumonia from severe exposure.
Signs Symptoms of Over-exposure (Chronic) Unknown
Unknown
Medical Conditions Aggravated by Over-exposure
NTP IARC OSHA X None
Carcinogen/Suspected Carcinogen Ingredients:
SECTION 7 - FIRST AID PROCEDURES - (If any Condition persists - Consult a physician.)
Eyes Immediately flush with plenty of water for 15 minutes. Call a physician.
Skin Wash with large quantity of water. Remove contaminated clothing. Wash before reuse.
Ingestion Drink plenty of water. Do NOT induce vomiting. Consult a physician at once.
Inhalation Unlikely occurance-Remove to fresh air. If qualified, give oxygen or artificial respiration as necessary and/or seek medical help.
SECTION 8 - SPECIAL PROTECTION INFORMATION
Respiratory Protection None usually required for normal usage. If mist, NIOSH approved respirator.
Ventilation requirements X Local Exhaust X Mechanical To keep below any listed TLV鈥檚 and/or for general good ventilation.
Protective Gloves Eye Protection Safety goggles
Rubber gloves
Other Protective Clothing Chemical apron, rubber boots as appropriate to usage to prevent skin contact.
SECTION 9 - SPILL OR LEAK PROCEDURES
Steps to be Taken if Released or Spilled Contain spill. Neutralize with weak acid solution. If necessary, vacuum up or soak up with
inert absorbant and place in suitable container(s) for disposal. Flush residue with large quantity of water.
Waste Disposal Methods Check all government regulations. Probable that neutralized material may flush to sanitary sewer system with plenty of water.
SECTION 10 - STORAGE AND HANDLING INFORMATION
Precautions to be Taken in handling and Storage Store away from acids, reactive metals and organics. Keep out of reach of
children. Wash thoroughly after handling.
|