MATERIAL SAFETY DATA SHEET
PAR-WAY TRYSON COMPANY
107 BOLTE LANE PH: (636) 629-4545
ST. CLAIR, MO 63077 FAX: (636) 629-1330
(8:30-5:00 P.M. CST)
________________________________________________________________________
HIMS RATING
SECTION 1 PRODUCT IDENTIFICATION HEALTH 1
PRODUCT NAME: GARLIC MIST FLAMMABILITY 4
PRODUCT CLASS: AEROSOL COOKING OIL REACTIVITY 1
DATE PREPARED: 09/00 P.P. EQUIPMENT 0
ITEM #:
______________________________________________________________________________________
SECTION 2 HAZARDOUS INGREDIENTS
INGREDIENT CAS# ACGIH OSHA OTHER % OPTIONAL
CANOLA OIL NO LIMIT
LECITHIN NO LIMIT
FLAVORING NO LIMIT
GARLIC OIL NO LIMIT
ANNATTO NO LIMIT
PROPANE/ISOBUTANE 68476-85-7 900 PPM 10-20%
THIS MSDS WAS PREPARED USING THE GUIDELINES SET BY 49 CFR 1910.1200 AND SARA III
______________________________________________________________________________________
SECTION 3A PHYSICAL DATA: CONTENTS WITHOUT PROPELLANT
FLASH POINT: >500掳F SPECIFIC GRAVITY: 0.92 @ 25掳C
EVAPORATION RATE: SLOWER THAN B-ACETATE VAPOR DENSITY (AIR = 1): N/A
SOLUBILITY IN WATER: NEGLIGIBLE APPEARANCE: LIQUID UNDER PRESSURE
______________________________________________________________________________________ ____
SECTION 3B PHYSICAL DATA: CONTENTS WITH PROPELLANT
VAPOR PRESSURE @ 70掳F: 70+/- 5 PSIG VAPOR PRESSURE @ 130掳F: 100 +/- 10 PSIG
FLAMMABILITY CLASS: FLAMMABLE FLAME EXTENSION @ 70掳F: > 18 INCHES
DRUM TEST: NEGATIVE FLAME BACK: NONE
PERCENT VOLATILE: 10-20%
__________________________________________________________________________ ______________
SECTION 4 FIRE AND EXPLOSION DATA
FLASH POINT: -156掳F PROPELLANT > 500掳F CONCENTRATE
EXPLOSIVE LIMITS LOWER: 1.8 % UPPER: 9.5 %
EXTINGUISHING MEDIA: WATER FOG, STANDARD FOAM, CO2, DRY CHEMICAL, HALON
HAZARDOUS DECOMPOSITION PRODUCTS: OXIDES OF CARBON, NITROGEN
FIRE FIGHTING PROCEDURES AND EXPLOSION HAZARDS:
WEAR SELF CONTAINED BREATHING APPARATUS WITH A FULL FACE PIECE OPERATED IN A POSITIVE
PRESSURE MODE. WATER FOG MAY BE USED TO HELP COOL CONTAINERS TO HELP MINIMIZE PRESSURE
BUILD-UP. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL ALONG THE GROUND TO SOURCES OF
IGNITION. REPORTS HAVE BEEN MADE OF IGNITION FROM PILOT LIGHTS, HEATERS, ETC AFTER VAPORS
HAVE BEEN MOVED BY VENTILATING FANS. EXPLODING CANS MAY TRAVEL GREAT DISTANCES SPEWING
BURNING MATERIALS. EXPOSURE TO TEMPERATURES OVER 1200F MAY CAUSE CANS TO BURST.
______________________________________________________________________________________
SECTION 5 REACTIVITY DATA
STABILITY: NORMALLY STABLE
INCOMPATIBILITY: STRONG OXIDIZERS, HEAT AND IGNITION SOURCES
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
CONDITION TO AVOID: DO NOT STORE ABOVE 120掳F. DO NOT STORE IN DIRECT SUNLIGHT
GARLIC MIST (CON'T) PAGE 2
SECTION 6 HEALTH HAZARD DATA
PERMISSIBLE EXPOSURE LEVELS: 900 PPM PROPELLANT
ACUTE EFFECTS
EYES: CAN CAUSE PAIN AND SLIGHT CORNEAL INJURY. VAPORS IRRITATE EYES.
SKIN: PROLONGED OR REPEATED CONTACT MAY CAUSE IRRITATION, DEFATTING.
BREATHING: MILDLY ANESTHETIC, NARCOTIC EFFECTS MAY BE SEEN IN THE 5,000-10,000 PPM RANGE.
CHRONIC EFFECTS
TARGET ORGAN/SYSTEMATIC EFFECTS:
EXCESSIVE EXPOSURE CAN CAUSE RESPIRATORY IRRITATION, LIVER OR KIDNEY DAMAGE.
FIRST AID
EYES: IRRIGATE WITH FLOWING WATER AT LEAST 10 MINUTES. HOLD LIDS OPEN AS IT HELPS PREVENT
SCRATCHING AND MINIMIZE IRRITATION. SEEK MEDICAL ATTENTION AS MATERIAL MAY BECOME
IMBEDDED.
SKIN: WASH WITH SOAP AND WATER. CONSULT A PHYSICIAN IF IRRITATION PERSISTS.
INGESTION: DO NOT INDUCE VOMITING. CALL A PHYSICIAN AND/OR POISON CONTROL CENTER
IMMEDIATELY.
INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE MOUTH TO MOUTH RESUSCITATION. IF
BREATHING IS DIFFICULT GIVE OXYGEN. CALL A PHYSICIAN AS EXCESSIVE EXPOSURE MAY CAUSE
IRRITATION TO THE UPPER RESPIRATORY SYSTEM.
________________________________________________________________________________________________
SECTION 7 PRECAUTIONS FOR STORAGE AND DISPOSAL
STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED:
CLEAN WITH SOAP AND WATER, VENTILATE, EXCESSIVE CONCENTRATION OF VAPORS ARE FLAMMABLE.
WASTE DISPOSAL METHODS: DO NOT PUNCTURE OR INCINERATE "EMPTY" OR FULL CANS. ONCE SPILLS
OR LEAKS ARE CLEANED UP, DISPOSE OF WASTE IN ACCORDANCE WITH GOVERNMENTAL ORDINANCES.
________________________________________________________________________________________________
SECTION 8 HANDLING PRECAUTIONS
VENTILATION: GENERAL VENTILATION SHOULD BE ADEQUATE FOR NORMAL USE. IF USING IN CONFINED
AREAS USE NECESSARY MEANS OF VENTILATION TO KEEP FROM EXCEEDING THE TLV.
RESPIRATORY: IF USING IN AREAS WHERE THE TLV IS LIKELY TO BE EXCEEDED USE A NIOSH/MSA
APPROVED RESPIRATOR.
SKIN: USE CHEMICAL RESISTANT GLOVES IF THE POSSIBILITY OF PROLONGED CONTACT EXISTS.
STORAGE: STORE BELOW 120掳F. AVOID DIRECT SOURCES OF HEAT AND IGNITION. DO NOT USE
DEFORMED OR DAMAGED CANS. KEEP OUT OF THE REACH OF CHILDREN. CONSULT LOCAL FIRE
MARSHALL AND INSURANCE REPRESENTATIVES FOR SPECIFIC STORAGE REQUIREMENTS IN YOUR AREA.
________________________________________________________________________________________________
SECTION 9 TRANSPORTATION AND REGULATORY INFORMATION
A. GROUND
PROPER SHIPPING NAME: CONSUMER COMMODITY
CONTAINER SIZE: SEVERAL SIZES ARE AVAILABLE
DOT CLASSIFICATION: ORM-D
DOT MARKINGS: ORM-D
DOT HAZARD CLASS: N/A
PROPELLANT: PROPANE/ISOBUTANE
SARA III REPORTABLE QUANTITY: 25,000 LBS.
NFPA 30B WAREHOUSE CLASSIFICATION: LEVEL 1
B. AIR
PROPER SHIPPING NAME: CONSUMER COMMODITY
CONTAINER SIZE: SEVERAL SIZES ARE AVAILABLE
DOT CLASSIFICATION: ORM-D-AIR
DOT LABELING/ MARKINGS: ID 8000/ORM-D-AIR
DOT HAZARD CLASS: 9.0
PROPELLANT: PROPANE/ISOBUTANE
SARA III REPORTABLE QUANTITY: 25,000 LBS
NFPA 30B WAREHOUSE CLASSIFICATION: LEVEL 1
GARLIC MIST (CON'T) PAGE 3
SECTION 9 TRANSPORTATION AND REGULATORY INFORMATION (CON'T)
C. IMDG
PROPER SHIPPING NAME: AEROSOL, FLAMMABLE
CONTAINER SIZE: SEVERAL SIZES ARE AVAILABLE
DOT CLASSIFICATION: FLAMMABLE LIQUID UN-1950
DOT MARKINGS: ORM-D
DOT PLACARD: LIMITED QUANTITY
DOT HAZARD CLASS: 2.0
PROPELLANT: PROPANE/ISOBUTANE
SARA III REPORTABLE QUANTITY: 25,000 LBS
NFPA 30B WAREHOUSE CLASSIFICATION: LEVEL 1
________________________________________________________________________________________________
DISCLAIMER:
THE FOREGOING INFORMATION HAS BEEN COMPILED FROM SOURCES BELIEVED TO BE ACCURATE BUT IS
NOT WARRANTED TO BE. RECIPIENTS ARE ADVISED TO CONFIRM IN ADVANCE OF THE NEED THAT THE
DATA IS CORRECT, APPLICABLE AND SUITABLE TO THEIR CIRCUMSTANCES. STANDARDS CHANGE
WITHOUT NOTICE; IT IS THE RESPONSIBILITY OF THE RECIPIENT TO ASSURE THAT THEIR PERSONNEL HAVE
BEEN NOTIFIED OF ANY CHANGES WHICH MAY AFFECT THEM. THE DATA PROVIDED ON THE MSDS ARE NOT
MEANT TO BE USED AS SPECIFICATIONS, ONLY GUIDELINE INFORMATION AS TO SAFE USE OF THE
PRODUCT. USER SHOULD ALSO REFER TO OSHA, STATE AND LOCAL SAFETY LAWS BEFORE USE.
PREPARED BY: ROBERT M. SMITH, TECHNICAL DIRECTOR
|