Fire
HAZARD RATING
MATERIAL SAFETY DATA SHEET
1 Reactivity
4-EXTREME
2 0
3-HIGH (Prepared according to 29 CFR 1910. 1200)
2-MODERATE Health 0 Date Prepared: 2-18-03
1-SLIGHT Special
0-INSIGNIFICANT
SECTION 1 - PRODUCT IDENTIFICATION
Emergency Telephone No.
Morven Industries, Inc.
Company Name 800-424-9300
5700 Lake Worth Rd. Suite 108 Lake Worth, FL 33463
Address Information Telephone No. 561-649-6555
Product Name / ID# Product Type X Proprietory Product
Maxi - Clean (696) Alkaline / Solvent Cleaner
SECTION 2 - HAZARDOUS INGREDIENTS
Chemical Name/Common Name Cas No. Percent (optional) TLV (Source)
*2-Butoxyethanol 111-76-2 <10% 25 ppm (skin) (ACGIH)
Potassium Hydroxide 1310-58-3 < 5% C 2 mg/m3 (ACGIH)
X * Substances Contains no substances - subject to the reporting requirements of SARA 313 and 40 CFR Part 372.
SECTION 3 - PHYSICAL DATA
Boiling Point (掳F) 卤 0.005 pH
Approx. 212掳F Specific Gravity (H2O=1.0) 12.5 卤 0.5
1.020 5.1
% VOC (ww)
Solubility In Water X Complete Insoluble Emulsifiable or (Dispersible) Slight (or Partial)
NA NA
Evaporation Rate (vs H O) X
Faster Slower About the Same Vapor Pressure Vapor Density
2
Appearance and Odor Clear red non-viscous liquid. Sassafras odor.
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
Flammable Limits
Flash Point (T.C.C.) >200掳F None to boiling Upper NA Lower NA
Extinguishing Media CO 2, Dry Chemical, water fog
Special Fire Fighting Procedures None
Unusual Fire Explosion Hazards None
SECTION 5 - REACTIVE DATA
Stability Stable Strong Acids, Oxidizers
Incompatibility
Hazardous Decomposition Products Oxides of carbon
SECTION 6 - HEALTH HAZARDS
Primary routes of
Threshold Limit Value Product
X None Established Not Applicable X Eyes X Skin X Oral X Inhalation
See Section 2 for Ingredients TLV Exposure
May cause burns to eyes and skin. Excessive inhalation may cause headaches or
Signs Symptoms of Over-exposure (Acute)
dizziness. If ingested may cause burns to mouth and throat and also nausea, vomiting, abdominal pain. Possibility of harmful
absorption through skin.
Signs Symptoms of Over-exposure (Chronic) Unknown
May aggravate existing dermatitis.
Medical Conditions Aggravated by Over-exposure
NTP IARC OSHA X None
Carcinogen/Suspected Carcinogen Ingredients:
SECTION 7 - FIRST AID PROCEDURES - (If any Condition persists - Consult a physician.)
Eyes Flush with water for 15 minutes. Get medical attention.
Skin Wash with plenty of water. Remove any contaminated clothing.
Ingestion Give large amounts of water. Do NOT induce vomiting. Get medical attention.
Inhalation Remove to fresh air. If qualified, give oxygen or artificial respiration as necessary and/or seek medical attention.
SECTION 8 - SPECIAL PROTECTION INFORMATION
Respiratory Protection None. If general good ventilation maintained. Use organic vapors respirator in high vapor conditions.
Ventilation requirements Local Exhaust X Mechanical To keep below any listed TLV鈥檚 and/or for general good ventilation.
Protective Gloves Eye Protection Chemical Goggles
Rubber Gloves
Other Protective Clothing Rubber apron recommended when handling larger volumes of material.
SECTION 9 - SPILL OR LEAK PROCEDURES
Steps to be Taken if Released or Spilled Contain spill. Neutralize with mild acid. Vacuum up or absorb on inert material. Rinse
with water.
Waste Disposal Methods Check all government regulations. May be possible to flush neutralized material to sanitary sewer with plenty of water.
SECTION 10 - STORAGE AND HANDLING INFORMATION
Precautions to be Taken in handling and Storage Keep out of reach of children. Wash thoroughly after handling.
|