Material Safety Data Sheet
OASIS 531
Section 1. Chemical product and company identification
: OASIS 531
Trade name
: Cleaner and disinfectant
Product use
: Ecolab Inc. Institutional Division
Supplier
370 N. Wabasha Street
St. Paul, MN 55102
1-800-352-5326
: 930123
Code
: 06-July-2005
Date of issue
EPA Registration No. : 47371-130-1677
EMERGENCY HEALTH INFORMATION: 1-800-328-0026
Outside United States and Canada CALL 1-651-222-5352 (in USA)
Section 2. Composition, Information on Ingredients
CAS number % by weight
Name
didecyldimethylammonium chloride 7173-51-5 5 - 20
quaternary ammonium compounds, benzyl-c12-c16-alkyldimethyl, chlorides 68424-85-1 1-5
ethanol 64-17-5 1-5
1-octanamine, n,n-dimethyl-, n-oxide 2605-78-9 1-5
acetic acid, (ethylenedinitrilo)tetra-, tetrasodium salt 64-02-8 1-5
Section 3. Hazards identification
Physical state : Liquid. (Liquid.)
Emergency : DANGER!
overview
CAUSES EYE AND SKIN BURNS.
HARMFUL IF SWALLOWED.
CAUSES SEVERE RESPIRATORY TRACT IRRITATION.
COMBUSTIBLE LIQUID AND VAPOR.
VAPOR MAY CAUSE FLASH FIRE.
Do not ingest. Do not get in eyes, on skin or clothing. Avoid breathing vapor or mist. Keep
away from heat, sparks and flame. Keep container closed. Use only with adequate
ventilation. Wash thoroughly after handling.
Potential acute health effects
Eyes : Corrosive to eyes.
Skin : Corrosive to the skin.
: Severely irritating to the respiratory system.
Inhalation
: Harmful if swallowed. Causes burns to mouth, throat and stomach.
Ingestion
See toxicological Information (section 11)
Section 4. First aid measures
Eye contact : In case of contact, immediately flush eyes with cool running water. Remove contact lenses and
continue flushing with plenty of water for at least 15 minutes. Get medical attention
immediately.
: In case of contact, immediately flush skin with plenty of water for at least 15 minutes while
Skin contact
removing contaminated clothing and shoes. Wash clothing before reuse. Thoroughly clean
shoes before reuse. Get medical attention immediately.
Inhalation : If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult,
give oxygen. Get medical attention immediately.
Ingestion : Rinse mouth; then drink one or two large glasses of water. Do not induce vomiting. Never give
anything by mouth to an unconscious person. Get medical attention immediately.
Page: 2/4
OASIS 531
Section 5. Fire fighting measures
: 51.6667 掳C (Closed cup)
Flash point
: These products are halogenated compounds, hydrogen chloride.
Products of combustion
: In case of fire, use water spray (fog), foam, dry chemicals, or CO 2.
Fire fighting media and
instructions
Dike area of fire to prevent product run-off.
Combustible liquid and vapor. Vapor may cause flash fire. Vapors may
accumulate in low or confined areas, travel considerable distance to source of
ignition and flash back. Runoff to sewer may create fire or explosion hazard.
Special protective equipment : Fire fighters should wear appropriate protective equipment and self-contained
breathing apparatus (SCBA) with a full facepiece operated in positive pressure
for fire-fighters
mode.
Section 6. Accidental release measures
Personal : Immediately contact emergency personnel. Eliminate all ignition sources. Keep unnecessary
personnel away. Use suitable protective equipment (Section 8). Do not touch or walk through
precautions
spilled material.
Environmental : Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and
sewers.
precautions
Methods for : If emergency personnel are unavailable, contain spilled material. For small spills add
absorbent (soil may be used in the absence of other suitable materials) and use a non-sparking
cleaning up
or explosion proof means to transfer material to a sealed, appropriate container for disposal.
For large spills dike spilled material or otherwise contain material to ensure runoff does not
reach a waterway. Place spilled material in an appropriate container for disposal.--
Section 7. Handling and storage
Handling : Do not ingest. Do not get in eyes, on skin or on clothing. Keep container closed. Use only with
adequate ventilation. Avoid breathing vapor or mist. Keep away from heat, sparks and flame.
To avoid fire, minimize ignition sources. Wash thoroughly after handling.
Storage : Keep out of the reach of children. Store in a segregated and approved area. Keep container in
a cool, well-ventilated area. Keep container tightly closed and sealed until ready for use. Avoid
all possible sources of ignition (spark or flame).
Do not store above 50掳C
Section 8. Exposure Controls, Personal Protection
Engineering : Provide exhaust ventilation or other engineering controls to keep the airborne concentrations of
vapors below their respective occupational exposure limits. Ensure that eyewash stations and
controls
safety showers are proximal to the work-station location.
Personal protection
Eyes : Use chemical splash goggles. For continued or severe exposure wear a face shield over the
goggles.
Hands : Use chemical resistant, impervious gloves.
Skin : Use suitable protective equipment.
Respiratory : Use a properly fitted, air-purifying or air-fed respirator complying with an approved standard if a
risk assessment indicates this is necessary. Respirator selection must be based on known or
anticipated exposure levels, the hazards of the product and the safe working limits of the
selected respirator.
Name Exposure limits
ACGIH TLV (United States, 1/2004).
ethanol
TWA: 1880 mg/m 3 8 hour(s). Form: All forms
TWA: 1000 ppm 8 hour(s). Form: All forms
OSHA PEL (United States, 8/1997).
TWA: 1900 mg/m 3 8 hour(s). Form: All forms
TWA: 1000 ppm 8 hour(s). Form: All forms
NIOSH REL (United States, 12/2001).
TWA: 1900 mg/m 3 10 hour(s). Form: All forms
TWA: 1000 ppm 10 hour(s). Form: All forms
Page: 3/4
OASIS 531
Section 9. Physical and chemical properties
: Liquid. (Liquid.)
Physical state
: Purple.
Color
: Faint Odor
Odor
: 7.7 (100%)
pH
Specific gravity : 1 (Water = 1)
Section 10. Stability and reactivity
: The product is stable.
Stability
Hazardous decomposition : These products are halogenated compounds, hydrogen chloride.
products
Section 11. Toxicological information
Potential acute health effects
: Corrosive to eyes.
Eyes
: Corrosive to the skin.
Skin
: Severely irritating to the respiratory system.
Inhalation
: Harmful if swallowed. Causes burns to mouth, throat and stomach.
Ingestion
Potential chronic health effects
: Contains material which causes damage to the following organs: blood, the reproductive
Chronic effects on
system, liver, upper respiratory tract, skin, central nervous system (CNS), eye, lens or
humans
cornea.
Section 12. Ecological information
: These products are carbon oxides (CO, CO 2) and water, nitrogen oxides (NO, NO 2
Products of degradation
...), halogenated compounds. Some metallic oxides.
Section 13. Disposal considerations
Waste disposal : The generation of waste should be avoided or minimized wherever possible. Avoid dispersal of
spilled material and runoff and contact with soil, waterways, drains and sewers. Disposal of this
product, solutions and any by-products should at all times comply with the requirements of
environmental protection and waste disposal legislation and any regional local authority
requirements.
Waste : Unused product is D001 (Ignitable)
classification
Consult your local or regional authorities.
Section 14. Transport information
Regulatory UN number Proper shipping name Class Packing Additional information
information
group
-
DOT Not - - -
regulated.
Classification
APPLIES ONLY DURING ROAD TRANSPORT
Any variation of the shipping description based on the packaging is not addressed.
Page: 4/4
OASIS 531
Section 15. Regulatory information
HCS Classification : Combustible liquid
Corrosive material
Target organ effects
U.S. Federal regulations : SARA 302/304/311/312 extremely hazardous substances: None.
SARA 302/304 emergency planning and notification: None.
TSCA 8(b) inventory : All materials are listed or exempt.
: No products were found.
California prop. 65
: 47371-130-1677
EPA Registration No.
Section 16. Other information
Hazardous Material * 3
: Health
Information System (U.S.A.)
2
Fire hazard
0
Reactivity
B
Personal
protection
Date of issue : 06-July-2005.
Responsible name : Regulatory Affairs
Date of previous issue : 09-January-2005.
Notice to reader
The above information is believed to be correct with respect to the formula used to manufacture the product
in the country of origin. As data, standards, and regulations change, and conditions of use and handling are
beyond our control, NO WARRANTY, EXPRESS OR IMPLIED, IS MADE AS TO THE COMPLETENESS OR
CONTINUING ACCURACY OF THIS INFORMATION.
|