24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
MATERIAL SAFETY DATA SHEET
SECTION I - MATERIAL AND MANUFACTURER IDENTIFICATION
Manufacturer's Name: Chemtrec Emergency Telephone No.: 800-424-9300
JEEN International Corp. *Chemtrec International Telephone No.: 703-527-3887
24 Madison Road *(Collect Calls Accepted)
Fairfield, NJ 07004
Telephone # 439-1401
Product Name: JEEMIDE HCA-RC-3
Chemical Name: COCAMIDE DEA
Chemical Family: FATTY ALKANOLAMIDE
CAS#: 68603-42-9
HMIS HAZARD RATINGS: Health (2) Fire (0) Reactivity (0)
4= EXTREME; 3= HIGH; 2= MODERATE; 1= SLIGHT; 0= INSIGNIFICANT
SECTION II - HAZARDOUS INGREDIENTS
INGREDIENTS CAS# OSHA/PEL
DIETHANOLAMINE 111-42-2 0.46 ppm, skin (ACGIH TLV)
Cocamide DEA 68603-42-9 Not Listed
Values are not product specifications.
SECTION III 鈥? HAZARDS IDENTIFICATION
General: Limited toxicity data are available on this specific product; this health hazard assessment is based on
the results of screening tests.
Emergency Overview: Appearance: Clear Amber Liquid
MAY CAUSE EYE IRRITATION. MAY CAUSE SLIGHT SKIN IRRITATION. INHALATION OR
INGESTION MAY CAUSE MUCOUS MEMBRANE IRRITATION
Routes of Exposure: Eye Contact; Skin Contact; Inhalation
Symptoms of Overexposure (Acute & Chronic):
Eye Contact: This material may irritate human eyes following contact.
Skin Contact: This material may irritate human skin. Exposure to diethanolamine may cause allergic contact
dermatitis. If allergy develops, very low future exposures can cause itching and a skin rash.
Systemically toxic concentrations of this product will probably not be absorbed through human skin.
Diethanolamine has the potential for possibly harmful skin absorption. Studies have been performed by the National Toxicology
Program (NTP) on skin absorption of diethanolamine in mice and rats. The results of these studies show no evidence of carcinogenicity
in rats of both sexes but clear evidence of carcinogenicity on mice of both sexes. The significance of these findings is unclear and
additional testing is currently underway.
Inhalation: High concentrations of mists or aerosols may irritate respiratory passages. No toxic effects are known
to be associated with inhalation of this material.
Ingestion: In humans, irritation of the mouth, pharynx, esophagus and stomach can develop following ingestion
of this product. No toxic effects are expected following ingestion of this product.
Chronic Effects: Overexposure to diethanolamine may affect the liver, kidneys, and blood. In acute and subacute
feeding studies in rats, 0.09 g/kg. Of diethanolamine caused changes in liver and kidney weights.
___________________________________________________________________________________________________________
SECTION IV - FIRST AID MEASURES
Eyes: Immediately flush with plenty of water for at least 15 minutes. If redness, itching, or a burning sensation
develops, have eyes examined and treated by medical personnel.
Skin: Wash material off of the skin with plenty of soap and water. If redness, itching, or a burning sensation
develops, get medical attention.
Ingestion: DO NOT INDUCE VOMITING. Give one or two glasses of water to drink and refer to medical personnel or take
direction from either a physician or a poison control center. Never give anything by mouth to an unconscious
person.
Inhalation: Remove victim to fresh air. If a cough or other respiratory symptoms develop, consult medical personnel.
Page No. 1 of 4 - MSDS - JEEMIDE HCA-RC3
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
Page No. 2 of 4 - MSDS - JEEMIDE HCA-RC3
SECTION V -FIRE FIGHTING MEASURES
Flash point and method: >200 deg. F, 93.33 deg. C (PMCC)
Auto-ignition temperature: No data
Flammable limits: No data.
Extinguishing Media: Water fog, alcohol foam, carbon dioxide, dry chemical, halogenated agents.
Special Fire-Fighting Protective Equipment:
Self-contained breathing apparatus with full facepiece and protective clothing.
Unusual fire and Explosion Hazards: None Known.
Explosion Data: Sensitivity to mechanical impact: Not applicable
Sensitivity to static discharge: Not applicable
SECTION VI - Accidental Release Measures
Refer to Section 8 for proper personal protective equipment.
Steps to be taken in case material is released or spilled:
Soak up material with absorbent and shovel into a chemical waste container.
Wash residue from spill area with water and flush to a sewer serviced by a permitted wastewater treatment facility.
SECTION VII - HANDLING AND STORAGE
Storage requirements: 50 - 90 deg. F in original closed container.
Precautions to take during handling and storage: Prevent skin and eye contact. Avoid breathing this material.
Do not swallow. Normal chemical handling and storage.
SECTION VIII- EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Limits: No ACGIH TLV or OSHA PEL is assigned to this mixture. Control of exposure to below the
PEL and/or TLV for the ingredients (see Section 2 and/or below) may not be sufficient.
Minimize exposure in accordance with good hygiene practice. The ACGIH TLV for
diethanolamine is 0.46 ppm (skin).
Engineering Controls: Use ventilation adequate to maintain safe levels.
Eye Protection: Chemical tight goggles.
Protective Clothing: Impervious Gloves.
Respiratory Protection: If needed, use MSHA-NIOSH approved respirator for organic vapors.
Other Protective Equipment: Eyewash station and safety shower in work area.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
Appearance & Odor: Clear Amber Liquid Odor Threshold: No Data.
Boiling Point: >350 Deg. F, 176.67 Deg. C. Melting Point: No Data.
Vapor Pressure (mm Hg @ 20 Deg. C: No Data Vapor Density (air=1): No Data.
Solubility in Water: Dispersible pH (10% aqueous): 10.8
Specific Gravity: 0.9826 % Volatile by volume: No Data
Cloud Point: No Data Viscosity: No Data.
Partition Coefficient: No Data. Freezing point: No Data.
Coefficient of water/oil distribution: No Data.
SECTION X - Stability and Reactivity
Stability: Stable under normal conditions.
Incompatibility: Oxidizing agents.
Conditions to Avoid: None Known.
Hazardous decomposition products: Combustion products: Carbon dioxide, carbon monoxide. Nitrogen oxides, amonia.
Hazardous polymerization: Will not occur.
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
Page No. 3 of 4 - MSDS - JEEMIDE HCA-RC3
SECTION XI - TOXICOLOGICAL INFORMATION
The toxicity data listed below are based on the results of screening tests on this specific products.
Eye Contact: This material was minimally irritating in rabbit eye irritation studies. A similar degree of irritation is
expected following human eye contact.
Skin Contact: This material was slightly irritating following a 24-hour exposure to rabbit skin.
Acute oral Toxicity: The oral LD50 is between 5 and 15 g/kg. This material is classified as "practically nontoxic" by
ingestion.
Carcinogenicity: This material is not listed as a carcinogen by OSHA, IARC, and NTP.
Reproductive toxicity/
Teratogenicity: No available information.
Mutagenicity: No available information.
Toxicologically synergistic products: None known.
SECTION XII - ECOLOGICAL INFORMATION
No data is available on this product.
SECTION XIII - DISPOSAL CONSIDERATIONS
Disposal Method: Discarded product is not a hazardous waste under RCRA, 40 CFR 261.
Container Disposal: Empty container retains product residue. Observe all hazard precautions. Do not distribute, make
available, furnish or reuse empty container except for storage and shipment of original product.
Remove all product residue from container and puncture or otherwise destroy empty container before
disposal.
SECTION XIV - TRANSPORT INFORMATION
Department of Transportation: Regulated only when the RQ is met or exceeded.
Proper shipping name: Environmentally hazardous substance, liquid, n.o.s. (contains:
Diethanolamine)
Hazard Class: Class 9, PG III, Environmentally Hazardous Substance
UN/NA ID number: UN3082
EFG Number: ERG#171
TDG (Transportation of Dangerous Goods): Not regulated.
SECTION XV - REGULATORY INFORMATION
TSCA (Toxic Substances Control Act) Regulations, 40 CFR 710: All ingredients are on the TSCA Chemical Substance
Inventory.
DSL (Canadian) Domestic Substances List): All ingredients are listed on the Canadian DSL.
OSHA Hazard Communication Standard, 29 CFR 1910.1200,
Hazard Summary: Physical Hazards:None
Health Hazards: Irritant (eye)
WHMIS Classification: Class D, Division 2 -- Toxic.
CERCLA and SARA Regulations (40 CFR 255, 370, and 372): This material contains the following chemicals subject to
the reporting requirements of SARA 313:
CAS Number: Chemical Name
Diethanolamine
SARA 311/312 Hazard Categories:
Immediate: Yes
Fire: No Delayed: No
Pressure: No Reactivity: No
State Regulations: None
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
Page No. 4 of 4 - MSDS - JEEMIDE HCA-RC3
SECTION XVI - OTHER INFORMATION
We assigned NFPA ratings and HMIS ratings to this product based on the hazards of its ingredient(s). Because the customer is most
aware of the application of the product, he must ensure that the proper personal protective equipment (PPE) is provided consistent with
information contained in the products MSDS.*
HMIS Information: Health: 1 Flammability: 1 Reactivity: 0
NFPA Information: Health: 1 Flammability: 1 Reactivity: 0
*This information is intended solely for the use of individuals trained in the particular hazard rating system.
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of JEEN
International Corporation. The data on this sheet relates only to the specific material designated herein. JEEN International
Corporation assumes no legal responsibility for use or reliance upon these data.
|