Product # (s) 7592__________________
MATERIAL SAFETY DATA SHEET
Section I 鈥? Product Information
Product Name or Identity: Dichloran Glycerol (DG-18) Agar Base
Acumedia Manufacturers, Inc. 517/372-9200
Manufacturer鈥檚 Name: Emergency Phone No.:
740 East Shiawassee 517/372-2006
Fax No.:
Lansing, Michigan 48912 foodsafety@neogen.com
e-mail:
Date Prepared or Revised: 10/11/04
Section II 鈥? Hazardous Ingredients / Identity Information
Hazardous Components: OSHA PEL ACGIH TLV Toxicity Data LD50
(Specific Chemical Identity: Common Names) (Permissible (Threshold Limit
Exposure Limits) Value)
Chloramphenicol, Amphenicol N/A N/A ORL-RAT, 2500 mg/kg
Chlorotetracycline N/A N/A ORL-MSE, 2314 mg/kg
Magnesium Sulfate N/A N/A SUBCUT-RAT, 1200 mg/kg
Potassium Phosphate N/A N/A SKN-RBT, >4640 mg/kg
Section III 鈥? Physical Characteristics
Boiling Point: 2 g/l (Cycloheximide) Specific Gravity (H2O = 1): 2.57 (Magnesium Sulfate)
Vapor Pressure (mm Hg.): N/A Melting Point: 151掳C (Chloramphenicol), 150掳C (Magnesium Sulfate)
220掳C (Chlorotetracycline)
>465掳C (Potassium Phosphate),
Vapor Density (AIR = 1): 11.1 (Chloramphenicol), Evaporation Rate (Butyl Acetate = 1): N/A
17.8 (Chlorotetracycline)
Solubility in Water: 2.5 mg/ml at 25掳C (Chloramphenicol), 150 g/ 100 g cold water (Potassium Phosphate)
8.6 mg/ml (Chlorotetracycline)
Appearance and Odor: Solid, light beige. Characteristic odor. (Chloramphenicol),
White crystals or powder, odorless (Potassium Phosphate), Solid yellow, odorless (Chlorotetracycline).
Section IV 鈥? Fire and Explosion Hazard Data
Flammable Limits: LEL (Lower Explosive Limit) - N/A
Flash Point (Method Used): 210掳C (Chlorotetracycline)
UEL (Upper Explosive Limit) - N/A
Extinguishing Media: Use sand, carbon dioxide or powdered extinguishing agent. Never use water.
Special Fire Fighting Procedures: Fight larger fires with alcohol resistant foam. Firefighters should wear protective
equipment and self-contained breathing apparatus. Remove contaminated clothing immediately.
Unusual Fire and Explosion Hazards: During heating or in case of fire, poisonous gases are produced. Vapors may be
heavier than air. Vapors can spread along the ground and collect in low or confined areas.
Section V 鈥? Reactivity Data
Unstable Conditions to Avoid: Light, dust generation, exposure to air, exposure to moist air or
Stability:
water
Stable X
Incompatibility (Materials to Avoid): Acids, acid chlorides, acid anhydrides and oxidizing agents.
Hazardous Decomposition or Byproducts: Hydrogen chlorine (HCl), Nitrogen oxides (NOx), Carbon monoxide (CO)
and Carbon dioxide (CO2).
May Occur Conditions to Avoid: Heat, light, dust, moisture, and incompatible materials.
Hazardous
Polymerization:
Will Not Occur X
Page 1 of 2
Product # (s) 7592
Section VI 鈥? Health Hazard Data
Inhalation? Yes Skin? Yes Ingestion? Yes
Route(s) of Entry:
Toxic. Toxic if swallowed, inhaled, or absorbed through skin. May cause eye, skin, or digestive
Health Hazards:
tract irritation. Possible risk of harm to unborn child. Possible carcinogen.
(Acute and Chronic)
Carcinogenicity: NTP? No IARC Monographs? 2A (Chloramphenicol) OSHA Regulated? No
(National Toxicology Program) This agent is probably carcinogenic to humans.
(International Agency for Research in Cancer)
Signs and Symptoms of Exposure: Exposure to Chloramphenicol may cause nausea, headache, and vomiting. Irritant
to skin and mucous membranes. Irritating effect to eye. Ingestion may cause nausea, vomiting and diarrhea. Allergic
reactions in hypersensitive persons. Phosphates are slowly and incompletely absorbed when ingested.
Medical Conditions Generally Aggravated by Exposure: Increased exposure to Chloramphenicol may cause anemia
and other blood abnormalities. Possible risk to unborn child.
General Information: Immediately remove contaminated clothing. Show physician product label.
Emergency /
First Aid
Ingestion: If swallowed, seek medical attention immediately. DO NOT INDUCE VOMITING.
Procedures:
Inhalation: Supply fresh air or oxygen. Seek medical attention immediately. In case of
unconsciousness, place patient on side position for transportation.
Eye Contact: Rinse opened eye for at least 15 minutes under running water, lifting lower and upper
lids. Seek medical attention.
Skin Contact: Wash with plenty of soap and water for at least 15 minutes. Seek medical attention.
Section VII 鈥? Precautions for Safe Handling and Use
Accidental Release Measures: Wear suitable protective clothing. Remove contaminated clothing immediately. In case
of fire, use sand, carbon dioxide or powdered extinguishing agent. Never use water. Avoid inhalation, contact with eyes
and skin.
Waste Disposal Method: Dispose in accordance with all applicable federal, state, and local environmental regulations.
Do not empty into drains, dispose of Chloramphenicol at a special hazardous waste collection container.
Handling and Storing: Keep container tightly closed. Protect from moisture and light. Store away from oxidizing agents.
Keep receptacle tightly sealed, avoid contact with moist air and steam. Store only in the original receptacle.
Other Precautions: Prevent formation of dust. Ensure good ventilation / exhaustion at the workplace. Avoid prolonged
or repeated exposure.
Section VIII 鈥? Control Measures
Respiratory Protection (Specify Type): None required where adequate ventilation conditions exist. If airborne
concentration is high, use an appropriate respirator or dust mask. Use only in chemical fume hood if used in high
concentrations than product label.
Local Exhaust: 50 鈥? 100 CFM Special: N/A
Ventilation:
Mechanical (General): N/A Other: N/A
Protective Gloves: Proper disposable gloves Eye Protection: Chemical resistant safety goggles
Other Protective Clothing or Equipment: Uniform, lab coat or disposable lab wear.
Work / Hygienic Practices: Follow the usual precautionary measures for handling chemicals / powder. Keep away from
food and beverages. Immediately remove all soiled and contaminated clothing. Avoid contact with eyes, skin, and
clothing.
This document is believed to be correct, but does not purport to be all inclusive and shall be used only as a guide.
Acumedia shall not be held liable for any damage resulting from handling or from contact with the above product. These
suggestions should not be confused with state, municipal or insurance requirements, and constitute NO WARRANTY.
Page 2 of 2 Rev 03, 10/04
|