庐
LUBRIPLATE
MATERIAL SAFETY DATA SHEET
Section 1
PRODUCT NAME OR NUMBER FORMULA
LUBRIPLATE Chain & Cable Fluid (AEROSOL) Mineral Oil, Additives and Propellant
GENERIC/CHEMICAL NAME: USDA AUTHORIZATION:
Petroleum Lubricating Oil H-2
Manufacturer's Name Emergency Telephone Number
Fiske Brothers Refining Co. 1-800-255-3924 - CHEM-TEL (24 hour)
Address Telephone Number for Information
1500 Oakdale Ave., Toledo, Ohio 43605 - 129 Lockwood St., Newark, NJ 07105 419-691-2491 - Toledo Office
Section 2 - Hazardous Ingredients/Identity Information
Hazardous Components OSHA PEL ACGIH TLV Other Limits Recommended % (optional)
5mg/m3 5mg/m3
Oil Mist in Air
C-300 mg/m3 150 mg/m3
O-Dichlorobenzene <4
LPG (Propellant) 1000 ppm 2500 ppm 20
* ACGIH - LISTED AS SIMPLE ASPHYXIANT (See Section 3)
Hazardous Material Identification System (HMIS): Health - 1, Flammability - 4, Reactivity - 0
Not a Controlled Product under (WHMIS) - Canada Consumer Commodity Special Protection: See Section 9
Section 3 - Health Hazard Data
PEL for Ortho-dichlorobenzene: C-300mg/m3 TLV for oil mist = 5mg/m3
Threshold Limit Value
Effects of Overexposure Inhalation is the most likely method of exposure. Minimal effects are expected at levels below the TLV of
components. Dizziness, drowsiness, coughing, nasal or throat irritations at higher levels. Propane may cause myocardial irritation and may
act as a simple asphyxiant without other significant physiologic effects if the oxygen content is low. It is reported that O-Dichlorobenzene
can cause liver and kidney damage in test animals.
Carcinogenicity: NTP? No IARC Monographs? No OSHA Regulated? No
Section 4 - Emergency and First Aid Procedures
EYE CONTACT: Flush with clear water for 15 minutes or until irritation subsides. If irritation persists, consult a physician.
SKIN CONTACT: Remove any contaminated clothing and wash exposed area with soap and warm water.
INHALATION: Remove to fresh air. If breathing has stopped, administer artificial respiration. Get medical help immediately.
INGESTION: If ingested, call a physician immediately. Do not induce vomiting.
Section 5 - Fire and Explosion Hazard Data
Flash Point (Method Used) Propellant < 0掳F Flammable Limits LEL 0.9% UEL 9.5%
Extinguishing Media Foam, Dry Chemical, Carbon Dioxide.
Special Fire Fighting Procedures Keep containers cool. Use air-supplied breathing equipment for enclosed or confined spaces.
Use shielding to protect personnel against bursting containers.
Unusual Fire and Explosion Hazards Do not spray near open flame. At elevated temperatures (over 130掳F.), aerosol containers may
vent, burst, or rupture.
PRODUCT NAME OR NUMBER - LUBRIPLATE Chain & Cable Fluid (AEROSOL)
Section 6 - Physical/Chemical Characteristics
Boiling Point (Aerosol) N/A Specific Gravity (H 2O = 1) 0.93
Of Product
Vapor Pressure (mm Hg.) Aerosol @ 130掳F. - 80 psig Melting Point Spray
Vapor Density (AIR = 1) >1 Evaporation Rate Faster
(Butyl Acetate = 1)
Solubility in Water Insoluble
Appearance and Odor Off white mist with additive odor from aerosol can.
Section 7 - Reactivity Data
Stability Unstable Conditions to Avoid Avoid spraying into open flame or onto
Stable X red-hot surfaces.
Incompatibility (Materials to Avoid) Strong oxidizers.
Hazardous Decomposition or Byproducts May form Carbon Monoxide, Hydrogen Chloride.
Hazardous Polymerization May Occur Conditions to Avoid N/A
Will Not Occur X
Section 8 - Spill or Leak Procedures
Steps to be taken in case material is released or spilled
Remove sources of ignition, ventilate area. Use appropriate safety equipment to enter area. Allow time for vapors to be below their TLV.
Add oil absorbent and clean area. Keep petroleum products out of sewers and watercourses.
Waste disposal method
Do not puncture or incinerate containers. Give empty, leaking or full containers to a disposal service equipped to safely handle and dispose
of pressurized containers.
SARA/TITLE III, Section 313 Status - 1,2 - Dichlorobenzene - <4%
Section 9 - Special Protection Information
Respiratory Protection (Specify type) Need approved organic vapor mask if TLV is exceeded.
Ventilation Local Exhaust Use for fumes & to maintain below TLV value. Special N/A
Mechanical (General) Other N/A
Protective Gloves Use oil-impervious gloves, such as nitrile. Eye Protection Use goggles or face shield.
Other Protective Equipment Use oil-resistant apron, if needed.
Section 10 - Special Precautions
Precautions to be taken in handling and storing
Store in cool, dry area out of direct sunlight. Do not puncture or incinerate, or heat full or empty containers above 130掳F.
Other Precautions
Please read and follow the directions on the product label. Keep away from children.
The above information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Fiske
Brothers Refining Company. The data on these sheets relates only to the specific material designated herein. Fiske Brothers
Refining Company assumes no legal responsibility for use or reliance upon this data.
Date Prepared: January, 2006 Prepared by: James R. Kontak
|