BREAK-FREE INC -- BREAK-FREE PCL, AEROSOL
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJHHH
MSDS NAME: BREAK-FREE PCL, AEROSOL
Responsible Party
Name: BREAK-FREE INC
Address: 1035 S LINWOOD AVE
Box: 25020
City: SANTA ANA CA 92799-5020
Info Phone: 714-953-1900
Emergency Phone Number: 714-953-1900
Preparer's Name: JAMES MERCER
Proprietary Ind: Y
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: BREAK-FREE INC
Address: 1035 S LINWOOD AVE
Box: 25020
City: SANTA ANA CA 92799-5020
Phone: 714-953-1900
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL) >5 G/KG
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: WHILE EXPECTED TO BE NON-IRRITATING FROM SKIN, EYE &
ORAL TESTING DONE, AS W/ALL PETRO PRODS, PRLNGD & RPTD CNTCT W/SKIN COULD
CAUSE IRRIT & POSS DERM. MINERAL OILS & ADDITIVES COULD ALSO BE
ABSORBED THRU ABRADED SKIN BUT THE INFO FROM DERMAL TOXICITY TESTS SUGGEST
THAT NO ACUTE SYSTEMIC EFTS WOULD BE EXPECTED IN HEALTHY INDIVIDUALS. INHAL:
RESP IRRIT & DISCOMFORT MAY BE EXPERIENCED IF MISTS OF MI NERAL OILS OR
RELATED MATLS ARE BREATHED AT AIR CONCS EXCEEDING RECOM EXPOS LEVELS.
EXCESSIVE INHAL CAN CAUSE RESP IRRIT, CNS EFTS INCL DIZZ, WEAK, FATG, NAUS,
HDCHS & POSS UNCON. INGEST: MIXTURE HAS LOW LEVEL OF (EFTS OF OVEREXP)
Signs And Symptions Of Overexposure: HLTH HAZS: TOXICITY (LD50>5G/KG). SMALL
AMTS OF LIQ ASPIR INTO RESP SYS DURING INGEST OR VOMIT MAY CAUSE PULM EDEMA
OR BRONCHOPNEUMONIA. MINIMAL TOXICITY. SKIN CNTCT: POSS SLIGHT TO MOD REDNESS
MAY OC CUR W/EXTENDED DAILY EXPOS. NOT CLASSIFIED AS PRIMARY SKIN IRRITANT OR
CORROSIVE. EYE CNTCT: POSS TRANSIENT IRRIT. NOT CLASSIFIED AS PRIMARY
IRRITANT. NOTE: MATL IS NOT KNOWN TO CNTN ANY CARCIN REQD T O BE LISTED UNDER
THE HAZARD COMMUNICATION STANDARD 29 CFR 1910.1200 FROM NTP OR IARC SOURCES.
First Aid: FOLLOW GOOD INDUSTRIAL HYGIENE PRACTICES. EYES: IF SPLASHED IN EYES,
FLUSH W/WATER IMMED FOR AT LEAST 15 MIN. SKIN: IF SPILLED ON CLTHG, REMOVE
SOILED CLTHG & WASH SKIN W/SOAP & WATER. LAUNDER ALL CON TAM CLTHG
BEFORE REUSE. INGEST: IF SWALLOWED, DO NOT INDUCE VOMIT. IF CONSCIOUS, DRINK
LARGE QTYS OF WATER & SEEK IMMED MED ATTN. INHAL: IF INHALED, MOVE TO
FRESH AIR. ANESTHETIC OR NARCOTIC EFTS COUL D OCCUR FROM OVEREXPOSURE TO
VAPORS, SO CALL A PHYSICIAN. IF AVAILABLE, GIVE OXYGEN. IF BRTHG STOPS, GIVE
MOUTH-TO-MOUTH RESUSCITATION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: FOR SMALL SPILLS, VACUUM INTO WASTE CNTNRS OR ABSORB
W/DRY SAND OR ABSORB CLOTH. FOR LARGE SPILLS, IMMED EVACUATE AREA & SHUT
OFF POTNTL IGNIT SOURCES. ONLY PERS EQUIPPED W/PROPER NIOSH APPRVD RESP &
SKIN/EYE PROT SHOULD BE PERMITTED IN AREA. DIKE AREA TO CONTAIN SPILL. TAKE
PRECS AS NEC TO PVNT CONTAM OF GROUND OR SURF WATERS. RECOVER W/WET VACUUM OR
ABSORB SPILLED MATL IN SAWDUST OR (SUPDAT)
Waste Disposal Methods: RECOVERED LIQS MAY BE REPROCESSED OR INCINERATED OR
TREATED IN PERMITTED HAZARDOUS WASTE MANAGEMENT FACILITY. CARE MUST BE TAKEN
WHEN USING OR DISPOSING OF CHEM MATLS &/OR THEIR CNTNRS TO PREVENT ENVI
RONMENTAL CONTAMINATION. DISPOSE OF CHEM MATLS &/OR THEIR CNTNRS I/A/W
THE CLEAN AIR ACT, CLEAN WATE R ACT, THE RESOURCE CONSERVATION (SUPDAT)
Handling And Storage Precautions: KEEP AWAY FROM OPEN FLAME OR OTHER IGNITION
SOURCES. DO NOT STORE ABOVE 120F. MAINTAIN ADEQUATE VENTILATION AND KEEP FROM
CHILDREN.
Other Precautions: NOTE THAT SOME VAPORS ARE HEAVIER THAN AIR & CAN
DISPLACE AIR IN LOW AREAS OR CONFINED SPACES SUCH AS PITS/TANKS. DO NOT ENTER
THOSE AREAS WHERE LARGE QUANTITIES OF VAPORS ARE SUSPECTED OR COLLECTING
UNTIL EXCHANGING THE AIR OR USING SPECIAL NIOSH APPRVD BREATHING APPARATUS
W/AN OBSERVER PRESENT FOR POSS ASSISTANCE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NOT REQD FOR NORMAL WORK SITUATIONS WHERE ADEQUATE
VENTILATION IS PROVIDED (SEE VENTILATION). USE NIOSH APPROVED SELF-CONTAINED
POSITIVE PRESSURE RESPIRATORS FOR EMERGENICES AND IN SITUATIONS WHERE AI R
MAY BE DISPLACED BY VAPORS OR IN CONFINED AREAS WITH LOW AIR EXHANGE RATES.
FOLLOW OSHA STD 29 CFR 1910.134.
Ventilation: NO SPEC REQS. USE LOC EXHST AT FILLING ZONES & WHERE LEAKAGE
IS PROBABLE. USE MECH VENT FOR STORAGE AREAS. FOR GEN DILUTION OR LOC EXHST,
(OTHER INFO)
Protective Gloves: POLYETHYLENE, NEOPRENE OR PVC PROTECTIVE GLOVES.
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N).
PERSONAL PROT CLTHG & USE OF EQUIP MUST BE I/A/W 29CFR 1910.132 & 29CFR
1910.133. CNTCT LENSES SHOULD NOT BE WORN WHERE THERE IS PROBABILITY OF LIQ
CONTACT.
Work Hygienic Practices: DO NOT SMOKE, EAT OR DRINK WHILE USING THIS PROD. WASH
HANDS W/SOAP & WATER BEFORE SMOKING, EATING, DRINKING OR USING TOILET
FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health: SPILL PROC: VERMICULITE & SWEEP INTO CLSD
CNTNRS FOR DISPOSAL. AFTER ALL VISIBLE TRACES HAVE BEEN REMOVED, THOROUGHLY
WET VACUUM AREA AGAIN. DO NOT FLUSH INTO SEWER. WASTE DISP METH: ACT, AS WELL
AS A NY OTHER FED, STATE OR LOCAL LAWS & REGS REGARDING DISPOSAL.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: =198.9C, 390.F
B.P. Text: INITIAL
Melt/Freeze Pt: =15.6C, 60.F
M.P/F.P Text: POUR POINT
Vapor Pres: <1 MM HG 20C(68F)
Volatile Org Content %: 27
Spec Gravity: 0.89
Viscosity: 20.8 CST 40C
Solubility in Water: NIL
Appearance and Odor: LIGHT AMBER COLOR; MILD ODOR.
Percent Volatiles by Volume: 32.3
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: SOURCES OF IGNITION SUCH AS SPARKS, HOT SPOTS,
WELDING, FLAMES AND CIGARETTES.
Materials To Avoid: AVOID STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: OXIDES OF CARBON, SULFUR, NITROGEN AND PTFE
POWDER.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
Transport Information: DOT CLASS: AEROSOL, ORM-D. TRANSPORATION EMERGENCY PHONE
NUMBER: CHEM-TEL, INC 1-800-265-3824 (US AND CANADA) OR 1-313-979-6826 (CALL
COLLECT).
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: NOTE: ALL SARA TITLE III MATERIALS HAVE BEEN
REPORTED IN INGREDIENT SECTION.
Federal Regulatory Information: ALL INGREDIENTS CONTAINED IN THIS FORMULA ARE
LISTED ON THE TOXIC SUBSTANCES CONTROL ACT (TSCA) CHEMICAL INVENTORY.
=======================================================
Other Information
=======================================================
Other Information: FIRE FIGHT PROC: HEATED ABOVE 212F. CARBON DIOXIDE CAN
DISPLACE OXYGEN. USE CAUTION WHEN APPLYING CARBON DIOXIDE IN CONFINED SPACES.
VENT: MAINTAIN ADEQ AIR EXHANGE TO AVOID VAPOR BUILD-UP. ALL VENT S HOULD BE
DESIGNED I/A/W OSHA STD 29 CFR 1910.94.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: BREAK-FREE PCL, AEROSOL
Assigned IND: Y
Company: BREAK-FREE INC
Street: 1035 S LINWOOD AVE
PO Box: 25020
City: SANTA ANA CA
Zipcode: 92799-5020
Health Emergency Phone: 714-953-1900
Label Required IND: Y
Date Of Label Review: 04/19/1999
Status Code: A
Origination Code: F
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: SKIN: COULD CAUSE IRRITATION AND POSS DERM.
REDNESS. COULD BE ABSORBED THROUGH ABRADED SKIN. INHAL: RESP IRRITATION
AND DISCOMFORT, CENTRAL NERVOUS SYSTEM EFFECTS INCLUDING DIZZINESS, WEA
KNESS, FATIGUE, NAUSEA, HEADACHES, AND POSSIBLE UNCONSCIOUSNESS. INGEST:
LOW LEVEL TOXICITY. SMALL AMOUNTS ASPIRATED INTO RESPIRATORY SYSTEM DURING
INGESTION OR VOMITING MAY CAUSE PULMONARY EDEMA O R BRONCHOPNEUMONIA. EYES:
POSSIBLE TRANSIENT IRRITATION. CHRONIC: NONE SPECIFIED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|