HILL MFG INC -- 3127 HILCOTROL
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BSWVF
MSDS NAME: 3127 HILCOTROL
Responsible Party
Name: HILL MFG CO INC
Address: 1500 JONESBORO RD
City: ATLANTA GA 30315
Info Phone: 404-522-8364
Emergency Phone Number: 800-535-5053
Preparer's Name: RICK GLISSON
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HILL MANUFACTURING CO INC
Address: 1500 JONESBORO DR
City: ATLANTA GA 30315
Phone: 404-522-8364
Name: HILL MFG CO INC
Address: 1500 JONESBORO ROAD
City: ATLANTA GA 30315
Phone: (404) 522-8364
=======================================================
Ingredients
=======================================================
Cas: 64742-95-6
RTECS #: WF3400000
Name: SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC PETROLEUM
DISTILLATES)
% Wt: >40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Name: SUPDAT:MATL & SHOVELED INTO CNTNRS. PVNT RUN-OFF TO SEWERS,
STREAMS/OTHER BODIES OF WATER. IF RUN-OFF OCCURS,
-----------------------------
Name: ING 2:NOTIFY PROPER AUTHORITIES AS REQUIRED THAT A SPILL HAS OCCURED.
-----------------------------
Name: WASTE DISP METH:I/A/W STATE, FEDERAL & LOCAL REGULATIONS.
-----------------------------
Name: RESP PROT:SUPPLIER). ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE
IMPLEMENTED TO REDUCE EXPOSURE.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES:CAN CAUSE SEV IRRIT, REDNESS, TEARING, BLURRED
VISION. SKIN:PRLNG/RPTD CONT CAN CAUSE MOD IRRIT, DEFAT, DERM.
INHAL:EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL & RESP IRRIT, DIZZ, WEAK,
FATG, NAUS, H DCH, POSS UNCON & EVEN ASPHY. INGEST:CAN CAUSE GI IRRIT,
NAUS, VOMIT & DIARR. ASPIR OF MATL INTO LUNGS (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES:FLUSH W/LG AMTS OF WATER FOR AT LST 15 MINS, LIFTING UPPER
& LOWER LIDS OCCAS, GET MED ATTN. SKIN:THORO WASH EXPOS AREA W/SOAP &
WATER. REMOVE & LAUNDER CONTAM CLTHG BEFORE RE-USE. INGEST:DO NOT INDUCE
VOMIT. KEEP PERS WARM, QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS DUE
TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. INHAL:REMOVE INDIVIDUAL TO
FRESH AIR. IF BRTHG IS DFCLT, (SUPP DATA)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SM SPILL:ABSORB LIQ ON PAPER, VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL & TRANSFER TO HOOD. LG SPILL:ELIM ALL IGNIT
SOURCES (FLAMES, FLAMES INCL PILOT LIGHTS, ELEC SPKS). PERS NOT WEARING PROT
EQUIP SHOULD BE EXCLUDED FROM AREA OF SPILL (SUPP DATA)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: SM SPILL:ALLOW VOLAT PORTION TO EVAP IN HOOD. ALLOW
SUFFICIENT TIME FOR VAPS TO COMPLETELY CLEAR HOOD DUCT WORK. DISP OF
REMAINING MATL I/A/W STATE, FED & LOC REGS. LG SPILL:DESTROY BY LIQ
INCIN. CONT AM ABSORB MAY BE DEPOSITED IN LANDFILL
Handling And Storage Precautions: NEVER STORE IN UNLABELED OR IMPROPERLY
LABELED CONTAINER. KEEP OUT OF REACH OF CHILDREN. FOR COMMERCIAL/INDUSTRIAL
USE ONLY.
Other Precautions: CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED.
SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR, LIQUID &/OR
SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS MSDS MUST BE OBSERVED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: 140F,60C
Lower Limits: 1%
Extinguishing Media: DRY CHEMICAL, FOAM, CO*2.
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: FORMS CARBON DIOXIDE & CARBON MONOXIDE.
COMBUSTIBLE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, NIOSH/MSHA
APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON CONTROL.
OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESPS UNDER SPECIFIED CNDTN S.
(SEE YOUR SAFETY EQUIP
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves: RESIST GLOVES, SUCH AS NITRILE RUBBER.
Eye Protection: CHEM WORK GOGG W/FULL LNGTH FACESHLD.
Other Protective Equipment: TO PREVENT RPTD/PRLNG SKIN CONTACT, WEAR IMPERVIOUS
CLOTHING & BOOTS. EMERGENCY EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: FIRST AID PROC:ADMIN OXYGEN. IF BRTHG HAS
STOPPED GIVE ARTF RESP. KEEP PERS WARM, QUIET & GET MED ATTN. SPILL
PROC:UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT SOURCE. DIKE AREA OF
SPILL TO PVNT S PREADING, PUMP LIQ TO SALVAGE TANK. REMAINING LIQ MAY BE
TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORB/OTHER ABSORB
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 300F,149C
Vapor Pres: 3
Vapor Density: 4.5
Spec Gravity: 0.87 (H*2O=1)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: FORMS AN EMULSION
Appearance and Odor: LIGHT AMBER LIQUID W/PLEASANT CITRUS ODOR.
Percent Volatiles by Volume: >90
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY FORM TOXIC MATERIALS: CARBON DIOXIDE &
CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 3127 HILCOTROL
Assigned IND: Y
Company: HILL MFG CO INC
Street: 1500 JONESBORO ROAD
City: ATLANTA GA
Zipcode: 30315
Health Emergency Phone: 800-535-5053
Label Required IND: Y
Date Of Label Review: 02/01/1994
Status Code: C
Label Date: 02/01/1994
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: FOR COMMERCIAL OR INDUSTRIAL USE ONLY. ACUTE:EYES:CAN
CAUSE SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN:PROLONGED OR
REPEATED CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS .
INHAL:EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL & RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, POSSIBLE
UNCONSCIOUSNESS & EVEN ASPHYXIATION. INGEST:CAN CAUSE GASTROIN TESTINAL
IRRITATION, NAUSEA, VOMITING & DIARRHEA. ASPIRATION OF MATERIAL INTO
LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. CHRONIC:NONE LISTED
BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|