===================== Product Identification =====================
MSDS NAME:PC#:5049 FRESH FORCE AEROSOL
NIIN:00D006777
MSDS Number: CDZHJ
=== Responsible Party ===
Company:MANTEK, DIV. OF NCH CORP
Box:152170
City:IRVING
State:TX
ZIP:75015
Country:US
Info Phone Num:214-438-4144 EXT. 013
Emergency Phone Num:972-438-1381
Preparer's Name:M. PERKINS/CHEMIST
CAGE:EO321
=== Contractor Identification ===
Company:MANTEK
Box:UNKNOW
CAGE:0A783
Company:MANTEK, DIV. OF NCH CORP
Box:152170
City:IRVING
State:TX
ZIP:75015
Country:US
Phone:214-438-4144 EXT. 013
CAGE:EO321
Company:NCH CORP
Address:2727 CHEMSEARCH BLVD
Box:152170
City:IRVING
State:TX
ZIP:75015-2170
Country:US
Phone:972-438-0563
CAGE:20913
============= Composition/Information on Ingredients =============
Name:D-LIMONENE
CAS:5989-27-5
RTECS #:GW6360000
Other REC Limits:NONE RECOMMENDED
Name:NONYLPHENOL POLYETHYLENE GLYCOL ETHER
CAS:127087-87-0
Other REC Limits:NONE RECOMMENDED
Name:OCTYLPHENOXY POLYETHOXYETHANOL
CAS:9036-19-5
RTECS #:MD0907600
Other REC Limits:NONE RECOMMENDED
Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Other REC Limits:NONE RECOMMENDED
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT; 9596
Name:ISOBUTANE
CAS:75-28-5
RTECS #:TZ4300000
Other REC Limits:NONE RECOMMENDED
===================== Hazards Identification =====================
LD50 LC50 Mixture:TLV NOT ESTABLISHED FOR MIXTURE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:CAUSES SEVERE IRRIT.PROL CONTACT
MAY CAUSE BURNS,CORNEAL INJURY,VISUAL
IMPARIMENT.SKIN:IRRIT,ITCH,RED.REP/PROL CONTACT DERM,MAY ALLOW
ABSORPTION OF POT HAMRFUL AMTS OF THRU SKIN.MAY CAUSE SENS & A
LLERGIC SKIN RX.INHAL:IRRIT W/COUGH,SNEEZING,NAU,NASAL
DISCHARGE,CHEST PAIN,HI CONCEN INAL CAUSES DIZZ,DISORIENT,(SUPPL)
Explanation of Carcinogenicity:PER MSDS:PROD CONTAINS CHEM LISTED AS
CARCINOGEN/POT CARCINOGEN BY IARC/NTP/OSHA/ACGIH/OTHER:NO.
Effects of Overexposure:EYE:REARING,REDNESS,PAIN,EXCESSIVE
BLINKING,SWELLING OF CONJUNCTIVA,BURNING
SENSATION.SKIN:ITCHING,REDNESS.INHAL:COUGHING,SNEEZING,NAU,NASAL
DISCHARGE,CHEST PAIN,DIZZ,DISORIENTATION,HEAD,EXCITATION,CN S
DEPRESS,ANESTHESIA.INGEST:NAU,VOMIT,DIARR,ASPIRATION OF PRODUCT CAN
CAUSE DMG,FATAL.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY AND SKIN
CONDITIONS SUCH AS ASTHMA,EMPHYSEMA,DERM. TARGET ORGANS:NONE KNOWN.
======================= First Aid Measures =======================
First Aid:INHAL:REMOVE TO FRESH AIR.IRRIT DEVLP/DIFFI BREATH GET MED
ATTN.EYE:IMMED RINSE W/H2O.REMOVE ANY CONTACT LENSES&CONT FLUSHING
@LEAST 15MINS.OPEN EYELIDS.GET IMMED MED ATTN.SKIN:WASH AREA
W/SOAP/WATER FOR SEVERAL MINS.IRRIT DEVLPS GET MED
ATTN.INGEST:GIVE 3-4GLASSES OF H2O.DONT INDUCE VOMIT.VOMIT OCCUR
SGIVE FLUIDS AGAIN.DISCOMFT OCCURS GET MED ATTN
IMEMD.DR:INGEST/VOMIT CAN LEAD TO ASPIRATION(SUP)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:116F,47C
Autoignition Temp:Autoignition Temp Text:NP
Lower Limits:0.7 (SUPPLE)
Upper Limits:6.1 (SUPPLE)
Extinguishing Media:"ALCOHOL' FOAM,FOAM,CO2,DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATH APPARATUS &
PROTECTIVE CLOTHING.DONT DIRECT DIRECT STREAM OF WATER INTO BURNING
POOLS AS IT MAY CAUE FROTHING & INCR FIRE INTENSITY.
Unusual Fire/Explosion Hazard:SPRAY EXPOSED AEROSOL CONTAINERS
W/WATERSPRAY TO AVOID RUPTURING.FLAME EXTENSION IS>30",BURNBACK IS
4".NFPA 30B:AEROSOL LEVEL 3.
================== Accidental Release Measures ==================
Spill Release Procedures:DUE TO NATURE OF AEROSOL PKG LARGE SPILL
UNLIKELY.SMALL SPILLS ABSORB W/INERT MATL & TRANSFER ALL MATL INTO
PROPERLY LABELED CNTNR FOR DISPOSAL.WEAR APPROPRIATE PROTECTIVE
CLOTHING.
Neutralizing Agent:NONE
====================== Handling and Storage ======================
Handling and Storage Precautions:STORAGE TEMPS:INDOOR,MAX 120F/MIN
20F.DONT STORE NEAR HEAT/HOT SURFACE/SPARKS/OPEN FLAME.USE ONLY
W/SUFFICIENT VENTILATION.
Other Precautions:KEEP OUT OF REACH OF CHILDREN.READ ENTIRE LABEL
BEFORE USING THIS PRODUCT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS OF
USE.NIOSH/MSHA APPROVED RESPIRATOR IN POORLY VENTILATED AREAS &/OR
FOR EXPO ABOVE ACGIH TLV OR OSHA PEL.
Ventilation:GEN MECHANICAL VENTI NORMALLY ADEQUATE.LOC VENTI
RECOMMENDED TO CONTROL EXPO FRM OPERATIONS THAN CAN GENERATE
MIST/VAP.
Protective Gloves:NEOPRENE RUBB,POLYVINYL ALCOHOL GLOVES
Eye Protection:CHEMICAL SPLASH GOGG SHOULD BE WORN
Other Protective Equipment:GENERAL DUTY WORK CLOTHES & PROTECTIVE
SHOES.
Work Hygienic Practices:WASH CONTAMIN CLOTH & CLEAN SHOES BEFORE
USE.WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FLAMM LIMITS FOR D-LIMONENE. HEALTH:HEAD,EXCITATION,CNS
DEPRESS,ANESTHESIA.ALLERGIC RESP RX.INGEST:GI
IRRIT,NAU,VOMIT,DIARR,ASPIRATION INTO LUNGS-DMG,FATAL.COMPRESSED
LIQ MAY CAUSE FREEZE BURNS. 1STAI D:INTO LUNGS-CAUSES DMG,FATAL.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:=190.6C, 375.F
Melt/Freeze Pt:M.P/F.P Text:NP
Decomp Temp:Decomp Text:NP
Vapor Pres:1.66
Vapor Density:4.8
Spec Gravity:0.838-0.843
pH:NA
Viscosity:NON-VISCOUS
Evaporation Rate & Reference:0.2, BUACT=1
Solubility in Water:EMULSIFIABLE
Appearance and Odor:COLORLESS, ORANGE ODOR, CLARITY-TRANSPARENT
Percent Volatiles by Volume:85
Corrosion Rate:NP
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,ACIDS AND ALKALIS,IODINE,PENTAFLUOROETHYLENE,REDUCIGN
AGENTS,MATL REACTIVE W/HYDROXYL COMPOUNDS.
Stability Condition to Avoid:AVOID HEAT,HOT SURFACES,SPARKS,OPEN
FLAMES.
Hazardous Decomposition Products:OXIDES OF CARBON AND ACRID SMOKE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.PROD COTNAINS CHEMS KNOWN TO STATE OF
CALIFORNIA TO CAUSE CANCER:ETHYLENE
OXIDE,1,4-DIOXANE,ACETALDEHYDE,FORMALDEHYDE AS TRACE CONTAM INANTS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|