===================== Product Identification =====================
MSDS NAME:CLAY DRAIN PIPE
Status Code:A
MSDS Number: CJMYF
=== Responsible Party ===
Company:GLADDING, MCBEAN
Address:601 7TH ST
City:LINCOLN
State:CA
ZIP:95648
Country:US
Info Phone Num:916-971-2390
Emergency Phone Num:916-645-3341
Preparer's Name:NORMITA G. CALLISON
CAGE:TO106
=== Contractor Identification ===
Company:GLADDING, MCBEAN
Address:601 7TH ST
Box:City:LINCOLN
State:CA
ZIP:95648
Country:US
Phone:916-971-2390
CAGE:TO106
============= Composition/Information on Ingredients =============
Name:CLAY/SHALE (ALUMINUM SILICATES) (VARIOUS CAS NUMBERS)
> Wt:70.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Name:GROG
> Wt:29.
OSHA PEL:15 MG/M3
ACGIH TLV:10 MG/M3
Name:BARIUM CARBONATE
CAS:513-77-9
RTECS #:CQ8600000
< Wt:1.
OSHA PEL:0.5 MG/M3
ACGIH TLV:0.5 MG/M3
Name:QUARTZ; (CRYSTALLINE SILICA (QUARTZ))
CAS:14808-60-7
RTECS #:VV7330000
OSHA PEL:see Table Z-3
ACGIH TLV:0.1 MG/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE CNTCT: DIRECT CNTCT W/DUST
MAY CAUSE IRRIT BY MECH ABRASION. SKIN CNTCT: DIRECT CNTCT MAY
CAUSE IRRIT BY MECH ABRASION. SKIN ABSORPTION: NOT EXPECTED TO BE
SIGNIFICANT EXPOS ROUTE. INGEST: EXPECTED TO BE PRACTICALLY
NON-TOX. INGEST OF LG AMTS MAY CAUSE GI IRRIT & BLOCKAGE. INHAL:
DUSTS MAY IRRIT NOSE, THROAT & RESP TRACT BY MECH ABRASION. COUGH,
SNEEZING, & SHORTNESS OF BREATH MAY OCCUR FOLLOWING EXPOS IN
EXCESS OF APPROP EXPOS LIMS. USE OF NATRL SAND & GRAVEL FOR
CONSTRUCTION PURPOSES IF NOT BELIEVED TO CAUSE ADDNL ACUTE TOX
EFTS. HOWEVER, RPTD OVEREXP TO VERY HIGH LEVELS OF RESPIR ABLE
CRYSTALLINE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE QUARTZ: IARC
MONOGRAPHS, VOL 68, 1997:GROUP 1. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998:REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
Effects of Overexposure:HLTH HAZS: SILICA (QUARTZ, CRISTOBALITE,
TRIDYMITE) FOR PERIODS AS SHORT AS SIX MONTHS HAVE CAUSED ACUTE
SILICOSIS. ACUTE SILICOSIS IS RAPIDLY PROGRESSIVE, INCURABLE LUNG
DISEASE THAT IS TYPICALLY FAT AL. SYMPS INCL (BUT ARE NOT LIMITED
TO):SHORTNESS OF BREATH, COUGH, FEVER, WT LOSS & CHEST PAIN.
SUBCHRONIC & CHRONIC EFTS: PULM DISEASES: EXCESSIVE EXPOS TO
PARTICULATES (DUST) OVER EXTENDED PERIOD O F TIME MAY RSLT IN
DEVELOPMENT OF SILICOSIS & OTHER PULM DISEASE. SEE ALSO: AMERICAN
SOCIETY FOR TESTING & MATLS (ASTM ) "STD PRACTICE E-1132-86, "STD
PRACTICE FOR HLTH REQS RELATING TO OCCUP EXPOS TO QUARTZ DUST."
Medical Cond Aggravated by Exposure:EXCESS DUST EXPOS MAY AGGRAVATE ANY
EXISTING RESP DISORDERS OR DISEASES. POSS COMPLICATIONS OF
ALLERGIES RSLTG IN IRRIT TO SKIN, EYES & RESP PASSAGE MAY OCCUR
FROM EXCESS EXPOS TO DUSTS.
======================= First Aid Measures =======================
Eyes: IMMED FLUSH EYE(S) W/PLENTY OF CLEAN WATER FOR AT LEAST
15 MIN WHILE HOLDING EYELID(S) OPEN. OCCASNLY LIFT EYELID(S) TO
ENSURE THOROUGH RINSING. BEYOND FLUSHING, DO NOT ATTEMPT TO REMOVE
MATL FR OM EYE(S). CNTCT PHYSICIAN IF IRRIT PERSISTS OR LATER
DEVELOPS. SKIN: WASH W/SOAP & WATER. CONTACT PHYSICIAN IF IRRIT
PERSISTS OR LATER DEVELOPS. INGEST: IF PERSON IS CONSCIOUS, GIVE
LARGE QTY OF WATE R & INDUCE VOMIT; HOWEVER, NEVER ATTEMPT TO MAKE
UNCON PERSON DRINK OR VOMIT. GET IMMED MED ATTN. INHAL: REMOVE TO
FRESH AIR. DUST IN THROAT & NASAL PASSAGES SHOULD CLEAR SPONT.
CNTCT PHYSICIAN IF IRR IT PERSISTS OR LATER DEVELOPS.
===================== Fire Fighting Measures =====================
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:NONE. USE NIOSH APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:USE ADEQ VENT, DUSTLESS VACUUM OR CLEANUP
SYSTEMS FOR HNDLG, STORAGE & CLEAN-UP SO AIRBORNE DUST DOES NOT
EXCEED PEL. PRACTICE GOOD HOUSEKEEPING. DO NOT PERMIT DUST TO
COLLECT ON WALLS, FLOORS, SILLS, LEDGES, MACHINERY OR EQUIP.
MAINTAIN, CLEAN & FIT TEST RESPS I/A/W OSHA STDS. MAINTIAN & TEST
VENT & DUST COLLECTION EQUIP. WASH/VACUUM CLTHG WHICH BECOMES
DUSTY. SEE ALSO CTL MEASURES.
====================== Handling and Storage ======================
Handling and Storage Precautions:NONE FOR NORMAL HNDLG & STORAGE OF
INTACT SEWER PIPE. FOR SFTY REASONS, STORE LG DIAMETER PIPE ON
RUNNERS & NAIL WOOD BLOCK AT EACH END OF RUNNERS. PROD IS NOT
INTENDED OR DESIGNED FOR USE AS ABRASIVE BLASTING MEDIUM OR FOR
FOUNDRY APPLICATIONS & SHOULD NOT BE USED FOR THOSE PURPOSES.
(SUPDAT)
Other Precautions:RESPIRABLE DUST & QUARTZ LEVELS SHOULD BE MONITORED
REGULARLY. DUST & QUARTZ LEVELS IN EXCESS OF APPROP EXPOS LIMS
SHOULD BE REDUCED BY FEASIBLE ENGINEERING CONTROLS, INCLUDING (BUT
NOT LIMITED TO) W ET SANDING, WET SUPPRESSION, VENT & PROCESS
ENCLOSURES. NIOSH APPRVD RESPS MUST BE WORN WHEN SUCH CO NTROLS ARE
(SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF VENTILATION IS INADEQUATE OR SIGNIFICANT
PRODUCT EXPOSURE IS LIKELY, USE A RESPIRATOR WITH DUST/
MIST-FILTERS, NIOSH/MSHA APPROVED.
Ventilation:ADEQUATE VENTILATION
Protective Gloves:NEOPRENE GLOVES. WASH OFF AFTER EACH USE. REPLACE AS
NECESSARY.
Eye Protection:SPLASH PROOF CHEMICAL GOGGLES.
Other Protective Equipment:USE PROTECTIVE EQUIPMENT ACCORDANCE WITH
29CFR SECTION 1910.132-134. USE RESPIRATORS WITHIN USE LIMIATIONS
OR ELSE USE SUPPLIED AIR RESPIRATORS.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
ABBREVIATION: N/A = NOT APPLICABLE. N/AV = NOT AVAILABLE. N/K =
UNKNOWN. N/P = NOT PROVIDED. N/R = NOT RELEVANT. N/D = NOT
DETERMINED. N/E = NOT ESTABLISHED.
================== Physical/Chemical Properties ==================
Spec Gravity:2.6 (H*2O=1)
Solubility in Water:0
Appearance and Odor:VITRIFIED SOLID, ESSENTIALLY ODORLESS, WIDE RANGE
OF COLORS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE KNOWN.
=================== Toxicological Information ===================
Toxicological Information:OTHER INFO: (OTHER FORMS OF CRYSTALLINE
SILICA) ARE EQUAL TO ONE-HALF OF LIMS FOR QUARTZ. PARTICULATES OR
DUST: TLV = 10MG/M3 (TOTAL PARTICULATE) OR 3MG/M3 (RESPIRABLE
PARTICULATE), NOT OTHERWISE CLAS SIFIED; OSHA PEL = 15MG/M3 (TOTAL
PARTICULATE, NOT OTHERWISE REGULATED). OSHA PEL = 5MG/M3
(RESPIRABLE PARTICULATE, NOT OTHERWISE REGULATED). RESPIRABLE
CRYSTALLINE SILICA (QUARTZ): TLV = 0.1 MG/M3; O SHA PEL = 10 MG/M3
DIVIDED BY (%SIO*2 + 2); OSHA PROPOSED PEL 0.1 MG/M3. RESPIRABLE
DUST CONTAINING SILICA: OSHA PEL = 10MG/M3 DIVIDED BY (%SIO*2 +2).
TOTAL DUST CONTAINING SILICA: OSHA PEL = 30MG/M3 DIVIDED BY
(ECOLOGICAL INFO)
===================== Ecological Information =====================
Ecological:TOXICOLOGICAL INFO: (%SIO*2 +2). ACGIH & OSHA HAVE
DETERMINED THAT ADVERSE EFTS ARE NOT LIKELY TO OCCUR IN WORKPLACE
PROVIDED EXPOSURE LEVELS DO NOT EXCEED APPROP TLVS/PELS. HOWEVER,
BECAUSE OF THE WI DE VARIATION IN INDIVIDUAL SUSCEPTIBILITY, LOWER
EXPOS LIMITS MAY BE APPROP FOR SOME INDIVIDUALS, INCLUDING PERSONS
W/PRE-EXISTING MED CONDITIONS SUCH AS THOSE DESCRIBED.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULATIONS . THIS MATERIAL IS CLASSED AS A
NON-HAZARDOUS SOLID WASTE FOR DISPOSAL.
=================== MSDS Transport Information ===================
Transport Information:DOT HAZARD CLASSIFICATION: NOT REGULATED. UN/NA
CODE: NONE. PLACARD REQUIRED: NONE. LABELING REQUIREMENT: NONE.
===================== Regulatory Information =====================
Federal Regulatory Information:COMMUNITY RIGHT-TO-KNOW = THIS PRODUCT
IS NOT SUBJECT TO THE REPORTING REQUIREMENTS OF THE EMERGENCY
PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (EPCRA) (40 CFR
370 AND 372).
State Regulatory Information:CALIRONIA PROPOSITION 65 WARNING: DRY
CUTTING, SANDING OR GRINDING OF VITRIFIED CLAY SEWER PIPE AND CLAY
PRODUCTS WILL EXPOSE YOU TO RESPIRABLE CRYSTALLINE SILICA WHICH IS
"KNOWN IN THE STATE OF CALIF ORNIA TO CAUSE CANCER AND TO OTHER
SUBSTANCES WHICH ARE KNOWN OT THE STATE OF CALIFORNIA TO CAUSE
CANCER, BIRTH DEFECTS AND OTHER REPRODUCTIVE HARM."
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|