===================== Product Identification =====================
MSDS NAME:SUPER SUPREME TRAFFIC BLACK PAINT, STBK2R
NIIN:00N091626
Status Code:A
MSDS Number: CJMXQ
=== Responsible Party ===
Company:FOX VALLEY SYSTEMS INC
Address:640 INDUSTRIAL DR
City:CARY
State:IL
ZIP:60013
Country:US
Info Phone Num:847-639-5744
Emergency Phone Num:847-639-5744
Resp. Party Other MSDS Num.:95MSDS34
CAGE:1BF99
=== Contractor Identification ===
Company:FOX VALLEY SYSTEMS INC
Address:640 INDUSTRIAL DR
Box:City:CARY
State:IL
ZIP:60013
Country:US
Phone:847-639-5744
CAGE:1BF99
============= Composition/Information on Ingredients =============
Name:ACETONE
CAS:67-64-1
RTECS #:AL3150000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:2400 MG/M3;1000 PPM
ACGIH TLV:1780 MG/M3;750 PPM
ACGIH STEL:2380 MG/M3;1000 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:2-BUTOXYETHANOL
CAS:111-76-2
RTECS #:KJ8575000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:240 MG/M3;50 PPM
ACGIH TLV:121 MG/M3;25 PPM
Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Minumum % Wt:1.
Maxumum % Wt:5.
ACGIH TLV:1900 MG/M3;800 PPM
Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Minumum % Wt:1.
Maxumum % Wt:5.
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3
Name:ISOBUTANE
CAS:75-28-5
RTECS #:TI4300000
Minumum % Wt:15.
Maxumum % Wt:20.
Name:REFINED SOLVENT NAPHTHA; (MINERAL SPIRITS)
CAS:8032-32-4
RTECS #:OI6180000
Minumum % Wt:1.
Maxumum % Wt:5.
ACGIH TLV:1370 MG/M3;300 PPM
Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Minumum % Wt:5.
Maxumum % Wt:15.
OSHA PEL:1800 MG/M3;1000 PPM
Name:TOLUENE
CAS:108-88-3
RTECS #:XS5250000
Minumum % Wt:10.
Maxumum % Wt:20.
OSHA PEL:see Table Z-2
ACGIH TLV:188 MG/M3;50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (VM & P
NAPHTHA)
CAS:64742-89-8
Minumum % Wt:5.
Maxumum % Wt:15.
Name:XYLENE
CAS:1330-20-7
RTECS #:ZE2100000
Minumum % Wt:3.
Maxumum % Wt:10.
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:651 MG/M3;150 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:ETHYLBENZENE
CAS:100-41-4
RTECS #:DA0700000
Minumum % Wt:1.
Maxumum % Wt:2.
OSHA PEL:435 MG/M3;100 PPM
ACGIH TLV:434 MG/M3;100 PPM
ACGIH STEL:543 MG/M3;125 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: MAY CAUSE IRRITATION,
REDNESS, TEARING, BLURRED VISION AND CONJUNCTIVITIS. SKIN:
PROLONGED OR REPEATED CONTACT MAY CAUSE MODERATE IRRITATION AND
DEFATTING DERMATITIS. INHALATION: EXCESSIV E INHALATION OF VAPORS
MAY CAUSE HEADACHES, NAUSEA, DROWSINESS AND IRRITATION OF MUCOUS
MEMBRANE OF NOSE AND THROAT. INGESTION: MAY CAUSE NAUSEA. ANIMAL
STUDIES HAVE CLEARLY DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON
CNS, HEMATOPOIETIC TISSUES, BLOOD KIDNEYS AND LIVER ASSOCIATED WITH
ADMINISTRATION OF ETHYLENE GLYCOL MONOBUTYL ETHER (EGBE).
(EXTRACTED FROM (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CARBON BLACK: IARC MONOGRAPHS, VOL 65,
PG 149, 1996:GROUP 2B.
Effects of Overexposure:HLTH HAZS: DHHS (NIOSH) PUB NO. 90-118) .
TOLUENE APPEARS ON NAVY LISTING OF OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFORMATION & SAFE
HANDLING & EXPOSURE INFORMATION . WARNING: THIS PROD CNTNS CHEM
KNOWN TO STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS/OTHER REPROD
HARM. CAN BE ABSORBED THRU SKIN. TIME WEIGHTED AVERAGE (TWA)-THE
EMPLOYEE'S AVERAGE AIRBORNE EXPOSURE IN ANY 8-HR WORK SHIFT OF
40-HR WORK WEEK WHICH SHALL NOT BE EXCEEDED. (SUPDAT)
======================= First Aid Measures =======================
Eyes: FLUSH WITH WATER FOR AT LST 15 MINS, LIFTING UPPER &
LOWER LIDS OCCASNLY. OBTAIN MED ATTN. SKIN: WASH CONTAMD AREA
THOROUGHLY WITH SOAP & WATER. APPLY MOISTURIZING HAND CREAM. INHAL:
IF AFFECTED , REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS DFCLT,
ADMIN OXYG ONLY IF TRAINED. IF BRTHG HAS STOPPED GIVE ARTF RESP,
REFERABLY MOUTH-TO-MOUTH. KEEP PERSON WARM, QUIET & OBTAIN MED
ATTN. INGEST: ONLY INDUCE VOMIT AT INSTRUCTION OF PHYS. KEEP
PERSON WARM. QUIET & OBTAIN MED ATTN. OTHER WHEN USING PROD, DO NOT
EAT, DRINK OR SMOKE. NOTE: FOLLOWING (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point:=-28.9C, -20.F
Lower Limits:1.9%
Upper Limits:8.5%
Extinguishing Media:PRODUCT EXTREMELY FLAMMABLE. LEVEL 2 AEROSOL - NFPA
30B. FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP AND POSSIBLE EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:SPRAY MIST OR VAPORS FROM CAN PER 400
CUBIC FEET OF AIR MAY REACH LOWER EXPLOSIVE LIMIT AND COULD BE
IGNITED BY A FLAME OR SPARK.
================== Accidental Release Measures ==================
Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. WIPE UP WITH INERT MATERIAL. DO NOT FLUSH INTO DRAINS. REMOVE
RESIDUE WITH SUITABLE SOLVENT CLEANER IMMEDIATELY.
====================== Handling and Storage ======================
Handling and Storage Precautions:CONTENTS UNDER PRESSURE. EXPOSURE TO
HIGH TEMPERATURES MAY CAUSE BURSTING. AVOID STORING NEAR RADIATOR,
STOVE, OPEN FLAME OR DIRECT SUNLIGHT. DO NOT INCINERATE OR PUNCTURE
CAN.
Other Precautions:DO NOT SPRAY INTO FLAMES OR ANY INCANDESCENT
MATERIALS. DO NOT SMOKE WHILE USING THIS PRODUCT OR WHERE SOLVENT
VAPORS ARE PRESENT. DOT STORAGE CATEGORY: DO NOT STORE AT
TEMPERATURE ABOVE 120F.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NORMALLY NEEDED IF LOCAL EXHAUST IS
SATISFACTORY. IF VENTILATION IS INADEQUATE, USE RESPIRATORY MASK
APPROVED BY NIOSH FOR PROTECTION AGAINST SPRAY MIST.
Ventilation:REQUIREMENTS VARY WITH RATE OF PRODUCT USE. SUPPLEMENT
VENTILATION TO KEEP BELOW OSHA & ACGIH PERMISSIBLE LEVELS OF EACH
INGREDIENT.
Protective Gloves:WEAR SOLVENT RESISTANT GLOVES WHERE THERE IS ANY RISK
OF SKIN CONT.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Supplemental Safety and Health
EFTS OF OVEREXP: SHORT TERM EXPOSURE LIMIT (STEL)-TEH EMPLOYEE'S 15-MIN
TIME WEIGHTED AVERAGE EXPOSURE WHICH SHALL NOT BE EXCEEDED AT ANY
TIME DURING WORK DAY. FIRST AID PROC: ANY FIRST AID, MED ADVIC E
SHOULD BE OBTAINED, ESPECIALLY IF SYMPTOMS PERSISTS.
================== Physical/Chemical Properties ==================
Vapor Density:HVR/AIR
Spec Gravity:1.20-1.27
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:70
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ALKALI AND ALKALINE EARTH METALS SUCH AS
SODIUM, POTASSIUM AND BARIUM, FINE POWDERS OF LIGHT METALS AND
THEIR ALLOYS SUCH AS MAGNESIUM.
Stability Condition to Avoid:HEAT, SPARKS AND FIRE.
Hazardous Decomposition Products:OR BYPRODUCTS: THERMAL DECOMPOSITION
MAY YIELD CO, CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL LAWS. DO NOT PIERCE OR BURN CAN EVEN AFTER USE.
=================== MSDS Transport Information ===================
Transport Information:DOL STORAGE CATEGORY: DO NOT STORE AT TEMPERATURE
ABOVE 120F.
===================== Regulatory Information =====================
SARA Title III Information:THESE PRODUCTS CONTAIN FOLLOWING TOXIC
CHEMICALS SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMER PLANNING & COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (40 CFR 372):
ACETONE, TOLUENE, XYLENE, ETH YLBENZENE.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|