MATERIAL SAFETY DATA SHEET
MSDS Ref. No: 4223
SPEEDBALL 2000 Power
Date Prepared: 03/14/2005
Cleaner Ready-to-Use
Date Revised: 03/14/2005
1. PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME/USE: SPEEDBALL 2000 Power Cleaner Ready-to-Use
PRODUCT CODE: 4223320, 4223110, 4223520, 4223550
MANUFACTURER
The Butcher Company Butcher Telephone Number: 800-225-9475
8310 16th St. Emergency Telephone (24 hours): 800-228-5635
Sturtevant, WI 53177-0902 CHEMTREC (U.S./Can.): 800-424-9300
CHEMTREC (Int'l): +1 703-527-3887
2. COMPOSITION / INFORMATION ON INGREDIENTS
INGREDIENT(S) CAS# % BY WEIGHT
Polyglycol aliphatic ether, NJ Trade Secret Registry #11173400-5068P NA 1-3
Aromatic alcohol, NJ Trade Secret Registry #11173400-5069P NA 1-3
Ethanolamine 141-43-5 1-3
See Section 8 for Exposure Limits NA - Not Applicable
OSHA REGULATORY STATUS: This product is classified as hazardous under OSHA regulations.
WHMIS CLASS: Class D- Division 2B
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Clear, Gold Liquid . Citrus Odor. May Cause Eye Irritation.
POTENTIAL HEALTH EFFECTS (See Section 11 for Toxicological Information)
PRIMARY ROUTE(s) OF EXPOSURE: X Eye X Skin Contact Skin Absorption
X Inhalation X Ingestion
EFFECTS OF ACUTE EXPOSURE
EYES: May cause eye irritation. Symptoms may include redness and pain.
SKIN: Non-irritating to the skin.
INHALATION: High concentrations of vapor or mist may cause nose, throat and respiratory tract irritation. Symptoms may include
coughing.
INGESTION: May cause mouth, throat and stomach irritation. Symptoms may include nausea, vomiting and diarrhea. May also cause central
nervous system effects including headache, dizziness and weakness.
EFFECTS OF CHRONIC EXPOSURE: Prolonged or repeated contact may cause skin irritation.
Page 1 of 5
SPEEDBALL 2000 Power Cleaner Ready-to-Use
MEDICAL CONDITIONS AGGRAVATED: May aggravate pre-existing eye, skin and respiratory conditions.
4. FIRST AID MEASURES
EYES: Flush eyes with plenty of water while holding eyelids apart. After initial flushing, remove any contact lenses and continue flushing for at
least 15 minutes. Do not put any medication in the victim's eyes unless instructed by a physician. Get medical attention.
SKIN: Flush with water, then wash with soap and water. Remove saturated clothing. Get medical attention if irritation develops.
INHALATION: Remove to fresh air. If not breathing, give respiration; if breathing is difficult, give oxygen (by trained personnel only). Get
medical attention if symptoms persist.
INGESTION: Do not induce vomiting. Drink large quantities of water. Get immediate medical attention. Never give anything by mouth to an
unconscious person.
5. FIRE FIGHTING MEASURES
FLASH POINT AND METHOD: > 93掳C (200掳F)TCC
FLAMMABLE LIMITS: Not applicable.
AUTOIGNITION TEMPERATURE: Not applicable.
EXTINGUISHING MEDIA: Use extinguishing media appropriate for surrounding fire.
HAZARDOUS COMBUSTION PRODUCTS: Normal products of combustion (carbon monoxide and carbon dioxide).
FIRE AND EXPLOSION HAZARDS: None known.
FIRE FIGHTING INSTRUCTIONS: This product is not flammable. As in any fire, MSHA/NIOSH approved self-contained breathing
apparatus (SCBA) and full protective gear should be worn.
6. ACCIDENTAL RELEASE MEASURES
See Section 8, Exposure Controls/Personal Protection and Section 3, Hazard Identification. Floors may be slippery. Use care to avoid falling.
Contain and isolate spill. Keep non-essential personnel from entering spill area. Use mop, absorbent, or wet vacuum to collect material for proper
disposal. Rinse area with water.
7. HANDLING AND STORAGE
HANDLING: Follow label use directions. Do not mix with other chemicals unless instructed by label directions. Avoid contact with eyes. Wash
thoroughly after handling. Remove saturated clothing. Wash clothing and equipment before reuse.
STORAGE: Keep container closed when not in use. Store away from incompatible materials. (See Section 10, Stability and Reactivity).
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
PERSONAL PROTECTIVE EQUIPMENT (PPE)
EYE: Where eye contact is possible, wear safety glasses with side shields or chemical splash goggles (ANSI Z87.1 approved).
SKIN: Where prolonged or repeated contact is possible, chemical-resistant clothing (e.g., gloves) is recommended.
RESPIRATORY: No respiratory protection is required if ventilation is adequate.
ENGINEERING CONTROLS: Good general room ventilation is expected to be adequate.
Page 2 of 5
SPEEDBALL 2000 Power Cleaner Ready-to-Use
EXPOSURE LIMITS:
INGREDIENT(S) OSHA PEL/STEL ACGIH TLV/STEL
Polyglycol aliphatic ether, NJ Trade Secret Registry #11173400-5068P NA NA
Aromatic alcohol, NJ Trade Secret Registry #11173400-5069P NA NA
Ethanolamine 3 ppm 8 mg/m3 / 3 ppm 7.5 mg/m3 /
6 ppm 15 mg/m3 6 ppm 15 mg/m3
NA - Not Available
9. PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Liquid
ODOR: Citrus
APPEARANCE: Clear, Gold
pH: 11.0 to 11.9
PERCENT VOLATILE BY WEIGHT: 95
VAPOR PRESSURE: Not Available
VAPOR DENSITY: Not Available
BOILING POINT: Not Available
FREEZING/MELTING POINT: Not Available
SOLUBILITY IN WATER: Complete
EVAPORATION RATE: Not Available
SPECIFIC GRAVITY: 1.00
VISCOSITY: Water Thin
OCTANOL/WATER PARTITION COEFFICIENT: Not Available
ODOR THRESHOLD: Not Available
10. STABILITY AND REACTIVITY
STABILITY (CONDITIONS TO AVOID): Stable.
POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION: None known.
INCOMPATIBLE MATERIALS: Strong acids (e.g., hydrochloric) and oxidizers (e.g., bleach).
11. TOXICOLOGICAL INFORMATION
ACUTE DATA: This product causes mild eye irritation. It was found to be non-irritating to skin. Based on acute toxicity testing, it is not
considered to be toxic by skin absorption or ingestion. The following data are available for this product and its ingredients:
PRODUCT/INGREDIENT ORAL LD 50 (rat) DERMAL LD 50 (rabbit) INHALATION LC 50 (rat)
SPEEDBALL 2000 Power Cleaner Ready-to-Use >5000 mg/kg >2000 mg/kg Not Available
Polyglycol aliphatic ether, NJ Trade Secret Registry #11173400- 2600 - 3100
>2000 - mg/kg Not Available
5068P mg/kg
Aromatic alcohol, NJ Trade Secret Registry #11173400-5069P 1230 - mg/kg 2000 - mg/kg 1000 - ppm (8-hr)
Ethanolamine 1720 - mg/kg 1018 - mg/kg Not Available
SENSITIZATION DATA: No data available.
CHRONIC DATA:
Prolonged overexposure to high concentrations of ethanolamine by inhalation and ingestion has caused liver and kidney effects in laboratory
animals. Prolonged overexposure to benzyl alcohol by ingestion and inhalation has caused central nervous system effects in humans and
laboratory animals.
REPRODUCTIVE/TERATOGENIC DATA: No data available.
CARCINOGENIC/MUTAGENIC DATA: Not listed as carcinogenic by NTP, IARC, or ACGIH or regulated as a carcinogen by OSHA.
Page 3 of 5
SPEEDBALL 2000 Power Cleaner Ready-to-Use
SYNERGISTIC MATERIALS: No data available.
12. ECOLOGICAL INFORMATION
No data available.
13. DISPOSAL CONSIDERATIONS
Disposal of this material should be in accordance with local, state or provincial and federal regulations. The unused product, as manufactured, is a
RCRA non-hazardous waste in accordance with 40 CFR 261. The product has not been evaluated by the Toxicity Characteristic Leachate
Procedure (TCLP). According to RCRA, it is the responsibility of the waste generator to ensure proper disposal.
14. TRANSPORT INFORMATION
DOT/TDG HAZARDOUS MATERIAL DESCRIPTION: Not regulated
15. REGULATORY INFORMATION
Not meant to be all-inclusive---selected regulations represented.
UNITED STATES
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT)
311/312 HAZARD CATEGORIES: Under 40 CFR 370.2, this product meets the following hazard categories: Immediate, Delayed.
313 REPORTABLE INGREDIENTS: Ingredients in this product are not currently subject to notification.
CERCLA (COMPREHENSIVE RESPONSE, COMPENSATION, AND LIABILITY ACT)
CERCLA REGULATORY: Not reportable under CERCLA.
TSCA (TOXIC SUBSTANCE CONTROL ACT)
TSCA STATUS: This product complies with all TSCA inventory requirements.
MASSACHUSETTS, NEW JERSEY, PENNSYLVANIA RIGHT-TO-KNOW:
INGREDIENT(S) CAS NO. STATE LISTING
Water 7732-18-5 Not Listed
Polyglycol aliphatic ether, NJ Trade Secret Registry #11173400-5068P NA Not Listed
Aromatic alcohol, NJ Trade Secret Registry #11173400-5069P NA MA, PA
Ethanolamine 141-43-5 MA, NJ, PA
NA - Not Applicable
CANADA
WHMIS (WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM): Class D-Division 2B, eye irritant. This product has
been classified in accordance with the hazard criteria of the Canadian Controlled Products Regulations (CPR) and the MSDS contains all the
information required by the CPR.
16. OTHER INFORMATION
NFPA CODES:
HMIS RATING
-1
HEALTH
0
0
FLAMMABILITY
1 0
0
REACTIVITY
---
-
PERSONAL PROTECTION
APPROVED BY: EH&S/Regulatory Affairs
MSDS STATUS
Revision No: 2
Page 4 of 5
SPEEDBALL 2000 Power Cleaner Ready-to-Use
Revision #: 3
This MSDS replaces the October 11, 2002 MSDS. Any changes in information are as follows:
In Section 1
Product Code Prepared By Date Prepared
Product Code
APPROVAL DATE: 03/14/2005
The information on this data sheet represents our current data and best opinion as to the proper use in handling of the product under normal
foreseeable conditions. Any use of this product which is not in conformance with this data sheet or product label, or which involves using the
product in combination with any other product or any other process is the responsibility of the user.
Page 5 of 5
|