0
0 0
0
MATERIAL SAFETY DATA SHEET
I. PRODUCT IDENTIFICATION
Acrylic Liquid Color
PAREXLAHABRA , INC.
4125 E. LaPalma Ave Suite 250 Anaheim, CA 92807
714-778-2266 877-547-8822
Effective date: December 1, 2006
II. HAZARDOUS INGREDIENTS
Chemical Names CAS Numbers ACGIH TLV OSHA PEL Other
Ethylene glycol 000107-21-1 127 mg/m鲁
Diethylene glycol 000111-46-6
Yellow iron oxide 051274-00-1 5 mg/m鲁 10 ppm (Fe)
Surfactant NJTSR Trade Secret
No. 56705700001-
5043P
Talc, Magnesium 014807-96-6 2 mg/m鲁 20 mppcf
silicate hydrate
Surfactant NJTSR Trade Secret
No. 56705700001-
5030P
Surfactant NJTSR Trade Secret
No. 56705700001-
5057P
Surfactant NJTSR Trade Secret
No. 56705700001-
5043P
Red iron oxide 001309-37-1 5 mg/m鲁 10 mg/m鲁
Manganese dioxide 001313-13-9 0.2 mg/m鲁 (Mn) 5 mg/m鲁 (Mn)
Kaolin 001332-58-7 2 mg/m鲁 5 mg/m鲁 resp.
Aluminum oxide 001344-28-1 10 mg/m鲁 5 mg/m鲁 resp.
III. PHYSICAL AND CHEMICAL PROPERTIES
Vapor Pressure 17 mm Hg @ 68 F
Vapor Density (Air + 1) is lighter than air
Specific Gravity 1.8
Boiling Point >212 F
pH @ 100.0% 8.0 to 9.0
Viscosity 80-95 KU @ 77 F
Evaporation Rate Is slower than Butyl Acetate
Other Properties: Red> Liquid-paste. Glycol odor. Solubility in water: Dispersible.
IV. FIRE FIGHTING MEASURES
Flash Point: Not applicable Lower Explosive Limit: Not applicable
Flash Point: Not applicable Upper Explosive Limit: Not applicable
Extinguishing Media: Use water spray or fog, alcohol foam, dry chemical or CO2
Page 1 of 3
ParexLahabra, Inc., Liquid Color
Fire Fighting Procedures: As in any fire, wear self-contained positive-pressure breathing apparatus,
(MSHA/NIOSH approved or equivalent) and full protective gear. Containers
can build up pressure if exposed to heat (fire). Cool with water spray.
V. HEALTH HAZARDS INFORMATION
COLORANTS MAY CAUSE EYE, SKIN AND RESPIRATORY TRACT IRRITATION.
POTENTIAL HEALTH EFFECTS
Eye Contact: According to test results on colorant base mixtures, this product is
classified as a moderate eye irritant. May cause tearing, reddening and/or
swelling.
Skin Contact: Frequent or prolonged contact may cause irritation. Colorants may cause
irritation.
Inhalation: Colorants may cause irritation.
Ingestion: Moderately toxic. May be harmful if swallowed. Ingestion of ethylene glycol
may cause abdominal discomfort or pain, nausea, vomiting, dizziness,
drowsiness, irritability, and central nervous system effects. Swallowing
large volumes of ethylene glycol causes severe kidney damage and may be
fatal. Ingestion of excessive amounts of diethylene glycol causes kidney
damage which may be fatal (estimated human oral lethal dose, 1.0 to 1.2
g/kg) and may cause liver effects. Causes smarting and burning
sensations, inflammation, burns, and painful blisters of the mouth, throat,
and digestive tract.
General: Ethylene glycol may aggravate an existing kidney disease. Repeated skin
contact with ethylene glycol may, in a very small proportion of cases cause
sensitization with the development of allergic contact dermatitis. The
incidence is significantly less than 1% with the undiluted material.
Repeated inhalation of ethylene glycol mist may produce signs of central
nervous system involvement, particularly dizziness and drowsiness.
Prolonged inhalation of iron oxide dust is known to produce a condition
known as siderosis. On X-rays it appears to be a benign pneumoconiosis
and is not associated with pulmonary fibrosis or disability unless there is
concurrent exposure to other fibrosis producing materials such as silica.
Overexposure to crystalline silica dust may cause lung effects (silicosis) and
may cause lung cancer (IARC, OSHA) base on animal testing.
Long term excessive exposure to talc dust may cause talcosis, a pulmonary
fibrosis, which in turn may lead to severe and permanent damage to the
lungs. Short term exposures may cause lung irritation. Because this
product is a free-flowing paste, dust inhalation is not an expected route of
exposure.
FIRST AID MEASURES
FIRST AID
Eye Contact: In case of contact, immediately flush eyes with plenty of water for at least
15 minutes. Obtain medical attention without delay, preferably from an
ophthalmologist.
Skin Contact: Flush skin with plenty of water. Remove contaminated clothing. Obtain
medical attention if irritation develops or persists.
Inhalation: Remove to fresh air. If not breathing, give CPR. If breathing is difficult, give
oxygen. Get immediate attention.
Ingestion: If swallowed give two glasses of water and induce vomiting immediately as
directed by medical personnel. Never give anything by mouth to an
unconscious person. Get medical attention immediately.
VI. STABILITY AND REACTIVITY
Stability This product is stable under normal storage conditions.
Hazardous Polymerization Will not occur under normal conditions.
Conditions to Avoid: Not applicable
Incompatibility with Other Materials: Oxidizing materials. Strong acids.
Page 2 of 3
ParexLahabra, Inc., Liquid Color
VII. SPILL, LEAK, AND DISPOSAL PROCEDURES
Steps To Be Taken In Case Ventilate area. Absorb spill with inert material and place in a chemical
Material Is Released or Spilled: waste container.
Handling And storing Precautions:
Handling: Avoid contact with eyes, skin, and clothing. Use with adequate ventilation.
Avoid breathing vapor or mist.
Storage: Store in a cool, dry place. Keep container closed when not in use.
NOTE: Dispose of all waste in accordance with federal, state, and local regulations.
VIII. SPECIAL PROTECTION INFORMATION
Engineering Controls: Use adequate ventilation.
Respiratory Protection: In case of overexposure, use appropriate NIOSH-approved respiratory
protective equipment.
Eye Protection: Use chemical splash goggles.
Skin Protection: Use impermeable gloves to minimize skin contact.
Other Protective Equipment: A safety shower and eye wash fountain should be readily available. To
identify additional Personal Protective Equipment (PPE) requirements, it is
recommended that a hazard assessment in accordance with the OSHA PPE
Standard (29CFR1910.132) be conducted before using this product.
Work practices, hygienic practices: Wash hands thoroughly before eating and practice good personal hygiene.
The information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of these data or the results to be
obtained from the use thereof. ParexLahabra, Inc. assumes no responsibility for personal injury or property damage to venders, users, or third parties caused by the material. Such
venders or users assume all risks associated with the use of the material.
Page 3 of 3
ParexLahabra, Inc., Liquid Color
|