Page 1
MATERIAL SAFETY DATA SHEET
Printed: 8/29/06
ISOPHORONE
PRODUCT IDENTIFICATION AND USE
MANUFACTURER: ARKEMA CANADA INC.
700 THIRD LINE
OAKVILLE, ONTARIO
L6J 5A3
EMERGENCY PHONE NUMBER: (905) 827-9841 (ARKEMA)
(613) 996-6666 (CANUTEC)
PRODUCT IDENTIFIER: ISOPHORONE
PRODUCT CODE: AP30430
PRODUCT USE: CHEMICAL INTERMEDIATE.
WHMIS CLASSIFICATION: D2B - TOXIC MATERIAL CAUSING OTHER TOXIC EFFECTS.
B3 - COMBUSTIBLE LIQUID.
HAZARDOUS INGREDIENTS
% W/W CAS # TLV
ISOPHORONE 60-100 78-59-1 ACGIH TWA = 5 PPM
LD50: 1,500 鈥? 3,450 MG/KG (ORAL-RATS) (CEILING)
LD50: 1,700-3,160 MG/KG (DERMAL-RATS)
LC50: 7.0 MG/L (4 HR 鈥? INHALATION - RATS)
ADDITIONAL INGREDIENT INFORMATION (WHMIS NOT CONTROLLED):
NA
PHYSICAL DATA
PHYSICAL STATE: LIQUID
ODOUR AND APPEARANCE: SLIGHT YELLOW LIQUID WITH CAMPHOR ODOUR.
ODOUR THRESHOLD: 0.2 PPM
SPECIFIC GRAVITY/DENSITY (G/ML): 0.923 @ 20掳C
VAPOUR PRESSURE: 41 PA @ 20掳C
VAPOUR DENSITY (AIR=1): 5.7
VOLATILITY/VOL(%): NE
SOLUBILITY IN H20: 12 G/L @ 20掳C
EVAPORATION RATE: NE
BOILING POINT: 215掳C
FREEZING POINT: -8.1掳C
PH: NE
LOG KOW: 1.66 (LOG POW)
SHIPPING INFORMATION
THIS PRODUCT IS NOT TDG REGULATED.
FIRE AND EXPLOSION HAZARD
FLAMMABILITY: COMBUSTIBLE
CONDITIONS: WILL BURN ABOVE FLASHPOINT
MEANS OF EXTINCTION: WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY
CHEMICAL. DO NOT USE WATER JET.
FLASHPOINT: 85掳C
UPPER EXPLOSION LIMIT (% V): 3.8%
LOWER EXPLOSION LIMIT (%V): 0.8%
NA - NOT APPLICABLE NE - NOT ESTABLISHED
Page 2
MATERIAL SAFETY DATA SHEET
Printed: 8/29/06
ISOPHORONE
AUTO-IGNITION TEMPERATURE: 460掳C
HAZARDOUS COMBUSTION PRODUCTS: OXIDES OF CARBON.
EXPLOSION DATA: CLOSED CONTAINERS MAY EXPLODE WHEN SUBJECTED TO
HEAT FROM SURROUNDING FIRE. COOL EXPOSED
CONTAINERS WITH WATER.
SENSITIVITY TO IMPACT: NO
SENSITIVITY TO STATIC DISCHARGE: NO
REACTIVITY
CHEMICAL STABILITY: STABLE
INCOMPATIBLE MATERIALS: STRONG OXIDIZERS, STRONG BASES.
CONDITIONS OF REACTIVITY: NE
HAZARDOUS DECOMPOSITION NE
PRODUCTS:
HEALTH HAZARD INFORMATION
ROUTE OF ENTRY
SKIN CONTACT: MAY CAUSE SLIGHT IRRITATION.
SKIN ABSORPTION: NE
EYE: MAY CAUSE IRRITATION.
INGESTION: MAY CAUSE IRRITATION
INHALATION: MAY CAUSE HEADACHE, DIZZINESS AND NAUSEA
ACUTE OVER EXPOSURE EFFECTS: NE
CHRONIC OVER EXPOSURE EFFECTS: PROLONGED INHALATION MAY CAUSE LUNG AND LIVER
INJURY.
SENSITIZATION: DOES NOT MEET WHMIS CRITERIA.
CARCINOGENICITY: ACGIH A3 鈥? ANIMAL CARCINOGEN. CAUSES CANCER IN
ANIMALS UNDER UNCOMMON CONDITIONS THAT MAY NOT BE
RELEVANT TO WORKER EXPOSURE.
TERATOGENICITY: DOES NOT MEET WHMIS CRITERIA.
MUTAGENICITY: DOES NOT MEET WHMIS CRITERIA.
REPRODUCTIVE TOXICITY: DOES NOT MEET WHMIS CRITERIA.
PREVENTIVE MEASURES
PERSONAL PROTECTIVE EQUIPMENT: WEAR SAFETY GOGGLES AND USE IMPERVIOUS
GLOVES. WHERE AIRBORNE EXPOSURE IS LIKELY,
WEAR A NIOSH APPROVED RESPIRATOR.
SPECIFIC ENGINEERING CONTROLS: LOCAL EXHAUST IS RECOMMENDED.
LEAK AND SPILL PROCEDURES: SOAK UP WITH AN ABSORBENT MATERIAL AND PLACE IN
A CLOSED CONTAINER.
WASTE DISPOSAL: HAZARDOUS WASTE. DO NOT ALLOW PRODUCT TO
ENTER THE ENVIRONMENT. CONSULT FEDERAL OR
LOCAL AUTHORITIES FOR APPROVED DISPOSAL
METHODS.
HANDLING PROCEDURES AND EQUIPMENT: KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAMES.
WASH BEFORE EATING, DRINKING, USING TOBACCO
PRODUCTS OR REST ROOMS.
STORAGE REQUIREMENTS: KEEP IN A CLOSED, LABELED CONTAINER IN A
VENTILATED AREA. STORE BELOW 50掳C.
NA - NOT APPLICABLE NE - NOT ESTABLISHED
Page 3
MATERIAL SAFETY DATA SHEET
Printed: 8/29/06
ISOPHORONE
FIRST AID MEASURES
EYE FLUSH EYES WITH LARGE AMOUNT OF WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. SEEK MEDICAL ATTENTION IF IRRITATION OCCURS OR PERSISTS.
SKIN WASH SKIN WITH WATER AND SOAP. SEEK MEDICAL ATTENTION IF IRRITATION
OCCURS OR PERSISTS.
INGESTION DO NOT GIVE LIQUIDS IF PERSON IS UNCONSCIOUS OR VERY DROWSY. DO NOT
INDUCE VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION.
INHALATION REMOVE PERSON TO FRESH AIR IMMEDIATELY. IF BREATHING HAS STOPPED, APPLY
ARTIFICIAL RESPIRATION AND ADMINISTER OXYGEN IF NECESSARY. SEEK MEDICAL
ATTENTION.
PREPARATION DATE
PREPARED BY: TECHNICAL DEPARTMENT.
PHONE NUMBER OF PREPARER: 905-827-9841
DATE PREPARED (MM/DD/YY): 04/04/02
DATE REVISED (MM/DD/YY): 08/29/06
MINIMUM CONTACT WITH THIS AND ALL CHEMICALS IS RECOMMENDED AS A GOOD GENERAL POLICY TO
FOLLOW.
THE INFORMATION PRESENTED HEREIN HAS BEEN COMPILED FROM SOURCES CONSIDERED TO BE
DEPENDABLE AND IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, SINCE DATA, SAFETY
STANDARDS, AND GOVERNMENT REGULATIONS ARE SUBJECT TO CHANGE AND THE CONDITIONS OF
HANDLING AND USE, OR MISUSE ARE BEYOND OUR CONTROL, ARKEMA CANADA MAKES NO WARRANTY
EXPRESSED OR IMPLIED, WITH RESPECT TO COMPLETENESS OR CONTINUING ACCURACY OF THE
INFORMATION CONTAINED HEREIN AND DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. USER
SHOULD SATISFY HIMSELF THAT HE HAS ALL CURRENT DATA RELEVANT TO HIS PARTICULAR USE.
NA - NOT APPLICABLE NE - NOT ESTABLISHED
|