310 Page: 1
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: SHAFT LAC BRIGHT (SAFETY) RED HMIS CODES: H F R P
PRODUCT CODE: 310 2*3 0
=================== SECTION I - MANUFACTURER IDENTIFICATION ==================
MANUFACTURER'S NAME: ELLIS PAINT CO.
ADDRESS : 3150 E. PICO BLVD.
LOS ANGELES, CA 90023-3683
EMERGENCY PHONE(CHEMTREC) : (800) 424-9300 DATE PRINTED : 08/16/06
INFORMATION PHONE : (323) 261-8114 NAME OF PREPARER : N/A
========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ===========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mmHG @TEMP(F) PERCENT
----------------------------------------------------------------------------------
VM&P NAPHTHA,MEDIUM ALIPHATIC 64742-89-8 9.8 68 15
OSHA PEL: 300 ppm, ACGIH TLV: 300 ppm
MINERAL SPIRITS, MED. ALIPHATIC SOLVENT NAPHTHA64742-88-71.1 68 13
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
~ METHYL PROPYL KETONE 107-87-9 28 68 9.16
OSHA PEL: 200 ppm, ACGIH TLV: 200 ppm
PIGMENT RED 3: C.I. #12120 2425-85-6 NA NA 5
OSHA PEL: NE, ACGIH TLV: NE
~ TOLUENE 108-88-3 21.8 68 1.95
OSHA PEL: 200 ppm, ACGIH TLV: 100 ppm
~ XYLENE 1330-20-7 6.1 68 1.77
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
~ ETHYL BENZENE 100-41-4 10 68 0.40
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
~Indicates toxic chemical(s) subject to the reporting requirements of section
313 of Title III and of 40 CFR 372.
================ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS =============
BOILING RANGE (Deg F): 220 - 330 DENSITY: 7.86 lb/gl
VAPOR DENSITY: HEAVIER THAN AIR SPECIFIC GRAVITY (H2O=1): 0.94
COATING V.O.C.: 3.31 lb/gl MATERIAL V.O.C.: 3.31 lb/gl
COATING V.O.C.: 397 g/l MATERIAL V.O.C.: 397 g/l
SOLUBILITY IN WATER: Insoluble EVAPORATION RATE: SLOWER THAN ETHER
APPEARANCE AND ODOR: Red liquid with mild odor
================== SECTION IV - FIRE AND EXPLOSION HAZARD DATA ===============
FLASH POINT (Deg F): 40 METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: 1 UPPER: 8
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
Use approved self-contained breathing apparatus. Do not use direct stream of
water.
UNUSUAL FIRE AND EXPLOSION HAZARDS
Flammable liquid! Fire-exposed containers should be cooled with water to prevent
pressure build-up which could result in container rupture. Shut-off any leak if
safe to do so and remove sources of ignition.
310 Page: 2
========================= SECTION V - REACTIVITY DATA ========================
STABILITY: STABLE
CONDITIONS TO AVOID
IMPORTANT WARNING: To avoid spontaneous combustion, soaked, soiled rags, spray
booth filters,overspray waste and dry dust sweepings must be properly discarded
in water filled containers and disposed of in accordance with local disposal
regulations. Avoid also excessive heat, sparks or open flames.
INCOMPATIBILITY (MATERIALS TO AVOID)
Strong oxidizing agents
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
Thermal decomposition may yield carbon dioxide and/or carbon monoxide.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
===================== SECTION VI - HEALTH HAZARD DATA ========================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Inhalation: May cause nasal and respiratory irritation, dizziness, weakness,
fatigue, nausea and headache. High concentrations may result in narcosis.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Eye contact: May cause severe irritation, redness, tearing and blurred vision.
Skin contact: May cause moderate irritation.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Skin absorption: May cause irritation, defatting and dermatitis.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Ingestion: May cause gastrointestinal irritation, nausea, vomiting and diarrhea.
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: May cause eye, nose and skin irritation, headache, dizziness and nausea.
Ingestion may result in vomiting; aspiration of liquid into the lungs may result
in aspiration pneumonitis. Chronic: Long term exposure may lead to central
nervous system depression and dermatitis.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: Yes OSHA REGULATED: No
This material contains a cobalt compound, which is classified as a possible
carcinogen for humans (2B) by IARC.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
Pre-existing eye, skin and respiratory disorders may be aggravated.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: REMOVE TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS DIFFICULT.
SPLASH (EYES): FLUSH EYES IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. SPLASH (SKIN): WASH AFFECTED AREAS WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. INGESTION: DO NOT INDUCE VOMITING. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE
LUNGS. GET MEDICAL ATTENTION IMMEDIATELY.
============ SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE =============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
PROVIDE VENTILATION. LARGE SPILLS MAY BE SCOOPED UP. SMALL SPILLS MAY BE PICKED
UP WITH ABSORBENT MATERIALS.
310 Page: 3
WASTE DISPOSAL METHOD
Place in tightly closed containers. Incinerate or dispose of in accordance with
local, state and federal regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Store away from heat, sparks and open flames. Keep containers tightly closed
when not in use. Use with adequate ventilation.
OTHER PRECAUTIONS
Do not take internally. Avoid prolonged contact. Ground equipment to prevent
accumulation of static charge.
====================== SECTION VIII - CONTROL MEASURES =======================
RESPIRATORY PROTECTION
Use self-contained breathing apparatus where vapor concentration may be above
TLV limits.Below TLV limits, use a combination vapor and particulate respirator
for spray application or a vapor respirator for non-spray applications.
VENTILATION
Adequate volume and pattern to keep air contaminant concentration below current
applicable OSHA or ACGIH's TLV limits.
PROTECTIVE GLOVES
Chemical resistant gloves
EYE PROTECTION
Chemical goggles, safety glasses
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Eye bath and safety shower
WORK/HYGIENIC PRACTICES
Wash hands thoroughly before eating or using the washroom. Smoke in smoking
areas only.
==================== SECTION IX - REGULATORY INFORMATION =====================
CALIFORNIA PROPOSITION 65
This product contains a chemical known to the State of California to cause birth
defects or other reproductive harm.
Contains: Benzene - Toluene -
This product contains a chemical known to the State of California to cause
cancer.
Contains: Benzene -
========================== SECTION X - DISCLAIMER ============================
The information contained herein is based on the data available to us and is
believed to be correct. However, Ellis Paint Co. makes no warranty expressed or
implied regarding the accuracy of these data or the results to be obtained from
the use thereof. Ellis Paint Co. assumes no responsibility for injury from the
use of the product described herein.
|