MX-5501 Page: 1
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: MAXIMUS SOLVENBORNE POLYURETHANE - BLACK HMIS CODES: H F R P
PRODUCT CODE: MX-5501 2*3 0
=================== SECTION I - MANUFACTURER IDENTIFICATION ==================
MANUFACTURER'S NAME: ELLIS PAINT CO.
ADDRESS : 3150 E. PICO BLVD.
LOS ANGELES, CA 90023-3683
EMERGENCY PHONE(CHEMTREC) : (800) 424-9300 DATE PRINTED : 05/15/07
INFORMATION PHONE : (323) 261-8114 NAME OF PREPARER : N/A
=========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ==========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mmHG @TEMP(F) PERCENT
----------------------------------------------------------------------------------
~ PARACHLOROBENZOTRIFLUORIDE 98-56-6 5.3 68 67.97
OSHA PEL: NE, ACGIH TLV: NE
UCAR N-PENTYL PROPIONATE 624-54-4 1.5 68 2
CARBON BLACK (as unbound particles of carbon)1333-86-4 NA NA 1.41
ACGIH TLV: 3.5 mg/m3
~ XYLENE 1330-20-7 6.1 68 0.84
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
~ ETHYL BENZENE 100-41-4 10 68 0.38
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
~ STYRENE 100-42-5 4.5 68 0.22
OSHA PEL: 100 PPM, ACGIH TLV: 50 PPM
~ METHYL ALCOHOL 67-56-1 96 68 0.07
ACGIH TLV: 200 ppm OSHA PEL: 200 ppm
~Indicates toxic chemical(s) subject to the reporting requirements of section
313 of Title III and of 40 CFR 372.
================ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS =============
BOILING RANGE (Deg F): 148 - 329 DENSITY: 10.41 lb/gl
VAPOR DENSITY: HEAVIER THAN AIR SPECIFIC GRAVITY (H2O=1): 1.25
COATING V.O.C.: 1.09 lb/gl MATERIAL V.O.C.: 0.40 lb/gl
COATING V.O.C.: 131 g/l MATERIAL V.O.C.: 48 g/l
SOLUBILITY IN WATER: Insoluble EVAPORATION RATE: SLOWER THAN ETHER
APPEARANCE AND ODOR: Black liquid with mild odor
================== SECTION IV - FIRE AND EXPLOSION HAZARD DATA ===============
FLASH POINT (Deg F): 54 METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: .9 UPPER: 36
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL
SPECIAL FIREFIGHTING PROCEDURES
Use approved self-contained breathing apparatus. Cool fire exposed containers
with water.
UNUSUAL FIRE AND EXPLOSION HAZARDS
Keep away from heat, electrical equipment, sparks and open flame. Closed
containers may explode when exposed to extreme heat due to pressure build-up.
========================= SECTION V - REACTIVITY DATA ========================
STABILITY: STABLE
MX-5501 Page: 2
CONDITIONS TO AVOID
Excessive heat, sparks or open flames.
INCOMPATIBILITY (MATERIALS TO AVOID)
Strong oxidizing agents, isocyanates and acids.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
Thermal decomposition may yield CO and/or CO2, oxides of nitrogen,amines & other
aliphatic fragments.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
===================== SECTION VI - HEALTH HAZARD DATA ========================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Inhalation: Excessive inhalation of vapors may cause nasal and respiratory
irritation, dizziness, weakness, fatigue, nausea and headache. High
concentrations may result in narcosis.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Skin contact may cause irritation. Symptoms of skin irritation may be reddening,
swelling, scaling or blistering. Eye contact may cause tearing, reddening and
swelling of the eyes.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Skin absorption may cause systemic effects similar to those identified under
inhalation effects.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Ingestion: May cause gastrointestinal irritation, nausea, vomiting and diarrhea.
Aspiration of material into lungs can cause chemical pneumonitis which can be
fatal.
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: May cause eye, nose and skin irritation, headache, dizziness and nausea.
Ingestion may result in vomiting; aspiration of liquid into the lungs may result
in aspiration pneumonitis. Chronic: Long term exposure may lead to central
nervous system depression and dermatitis.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: Yes OSHA REGULATED: No
This material contains styrene, which is classified as a possible carcinogen for
humans (2B) by IARC. This material contains ethylbenzene which is classified as
"possibly carcinogenic to humans" (2B) by IARC. This material contains carbon
black, which is classified as a possible carcinogen for humans (2B) by IARC.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
Pre-existing eye, skin and respiratory disorders may be aggravated.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION IF NECESSARY.
SPLASH(EYES): FLUSH EYES IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. SPLASH(SKIN): WASH AFFECTED AREAS THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND WASH THOROUGHLY BEFORE REUSE. FOR SEVERAL
EXPOSURES GET UNDER SAFETY SHOWER AFTER REMOVING CLOTHING, THEN GET MEDICAL
ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GIVE 1 TO 2 CUPS OF MILK OR WATER
TO DRINK. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSING PERSON.
CONSULT PHYSICIAN IMMEDIATELY.
MX-5501 Page: 3
============ SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE =============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
ELIMINATE ALL SOURCES OF IGNITION. ABSORB WITH INERT MATERIAL (SAND,
VERMICULITE, ETC.), SWEEP OR SCOOP UP AND PUT IN DISPOSAL CONTAINER. FLUSH AREA
OF SPILL WITH WATER.
WASTE DISPOSAL METHOD
Waste must be disposed of in accordance with federal, state and local
environmental control regulations. Incineration is the preferred method. Empty
containers must be handled with care due to product residue and flammable
solvent vapor. Decontaminate containers prior to disposal. DO NOT HEAT OR CUT
EMPTY CONTAINER WITH ELECTRIC OR GAS TORCH.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Keep away from heat, sparks and open flame. Ground containers during storage and
transfer operations. Store in tightly closed containers to prevent moisture
contamination. Do not reseal if contamination is suspected. Avoid contact with
skin and eyes.
OTHER PRECAUTIONS
Do not take internally. Avoid prolonged contact. Ground equipment to prevent
accumulation of static charge.
====================== SECTION VIII - CONTROL MEASURES =======================
RESPIRATORY PROTECTION
Use self-contained breathing apparatus where vapor concentration may be above
TLV limits.Below TLV limits, use a combination vapor and particulate respirator
for spray application or a vapor respirator for non-spray applications.
VENTILATION
Exhaust ventilation sufficient to keep the airborne concentration of the
solvents, HDI and polyisocyanate below their respective TLV's must be utilized.
PROTECTIVE GLOVES
Chemical resistant gloves. Cover as much of the skin area as possible with
appropriate clothing.
EYE PROTECTION
Safety glasses, splash goggles or face shield . Contact lenses should not be
worn.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Safety showers and eyewash stations should be provided.
WORK/HYGIENIC PRACTICES
Wash hands thoroughly before eating or using the washroom. Smoke in smoking
areas only.
==================== SECTION IX - REGULATORY INFORMATION =====================
CALIFORNIA PROPOSITION 65
This product contains a chemical known to the State of California to cause
cancer.
Carbon Black - Ethylbenzene -
MX-5501 Page: 4
========================== SECTION X - DISCLAIMER ============================
The information contained herein is based on the data available to us and is
believed to be correct. However, Ellis Paint Co. makes no warranty expressed or
implied regarding the accuracy of these data or the results to be obtained from
the use thereof. Ellis Paint Co. assumes no responsibility for injury from the
use of the product described herein.
|