Material Safety Data 24 Hour Assistance:
1-847-367-7700
Sheet
Rust-Oleum Corp.
www.rustoleum.com
Section 1 - Chemical Product / Company Information
Parks Nanoshield Waterbased Gloss
Product Name: Revision Date: 04/09/2007
Floor
Identification
137233
Number:
Product Use/Class: Crystal Clear Waterbased Finish
Rust-Oleum Corporation Rust -Oleum Corporation
Supplier: Manufacturer:
11 Hawthorn Parkway 11 Hawthorn Parkway
Vernon Hills, IL 60061 Vernon Hills, IL 60061
USA USA
Preparer: Regulatory Department
Section 2 - Composition / Information On Ingredients
Chemical Name CAS Number Weight % Less Than ACGIH TLV-TWA ACGIH TLV-STELOSHA PEL-TWA OSHA PEL -CEILING
polyurethane dispersion PROPRIETARY25.0 N.E. N.E. N.E. N.E.
Glycol Ether DB 112-34-5 10.0 200 ppm N.E. N.E. N.E.
Triethylamine 102-71-6 5.0 1 PPM SKIN N.E. 25 PPM N.E.
Dipropylene Glycol Monobutyl Ether29911-28-2 1.0 N.E. N.E. N.E. N.E.
Section 3 - Hazards Identification
*** Emergency Overview ***: Use ventilation necessary to keep exposures below recommended exposure limits, if
any.
Effects Of Overexposure - Eye Contact: Causes eye irritation.
Effects Of Overexposure - Skin Contact: Substance may cause slight skin irritation.
Effects Of Overexposure - Inhalation: Low hazard for usual industrial handling or commercial handling by trained
personnel.
Effects Of Overexposure - Ingestion: Substance may be harmful if swallowed.
Effects Of Overexposure - Chronic Hazards: No Information.
Primary Route(s) Of Entry: Skin Contact, Skin Absorption, Inhalation, Ingestion, Eye Contact
Section 4 - First Aid Measures
First Aid - Eye Contact: Hold eyelids apart and flush with plenty of water for at least 15 minutes. Get medical
attention.
First Aid - Skin Contact: Wash with soap and water. Get medical attention if irritation develops or persists.
First Aid - Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give
oxygen. Get immediate medical attention.
First Aid - Ingestion: Swallowing less than an ounce will not cause significant harm. For larger amounts, do not
induce vomiting, but give one or two glasses of water to drink and get medical attention.
Section 5 - Fire Fighting Measures
Flash Point: 205 F Lower Explosive Limit: 0.6 %
() Upper Explosive Limit : 17.0 %
Extinguishing Media: Carbon Dioxide, Dry Chemical, Foam, Water Fog
Unusual Fire And Explosion Hazards: FLASH POINT IS TESTED TO BE GREATER THAN 200 DEGREES F.
Special Firefighting Procedures: Water may be used to cool closed containers to prevent buildup of steam.
Section 6 - Accidental Release Measures
Steps To Be Taken If Material Is Released Or Spilled: Dispose of according to local, state (provincial) and federal
regulations. Do not incinerate closed containers.
Section 7 - Handling And Storage
Handling: Wash hands before eating. Wash thoroughly after handling. Avoid contact with eyes.
Storage: Keep from freezing. Keep container closed when not in use.
Section 8 - Exposure Controls / Personal Protection
Engineering Controls: Prevent build-up of vapors by opening all doors and windows to achieve cross -ventilation.
Use process enclosures, local exhaust ventilation, or other engineering controls to control airborne levels below
recommended exposure limits.
Respiratory Protection: A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2 requirements
must be followed whenever workplace conditions warrant a respirator's use.
Skin Protection: Nitrile or Neoprene gloves may afford adequate skin protection. Use gloves to prevent prolonged
skin contact.
Eye Protection: Use safety eyewear designed to protect against splash of liquids.
Other protective equipment: Refer to safety supervisor or industrial hygienist for further information regarding
personal protective equipment and its application.
Hygienic Practices: Wash thoroughly with soap and water before eating, drinking or smoking.
Section 9 - Physical And Chemical Properties
Boiling Range: 192 - 999 F Vapor Density: Heavier than air
Odor: Odor Threshold:
Ammonia-like ND
Appearance: Evaporation Rate:
Slightly cloudy, particle free Slower than ether
Solubility in H2O: Good
Freeze Point: Specific Gravity:
ND
Vapor Pressure: PH:
ND 8.0 - 8.5
Physical State: Liquid
(See section 16 for abbreviation legend)
Section 10 - Stability And Reactivity
Conditions To Avoid: Avoid contact with strong acid and strong bases.
Incompatibility: Incompatible with strong oxidizing agents, strong acids and strong alkalies.
Hazardous Decomposition: When heated to decomposition, it emits acrid smoke and irritating fumes. By open
flame, carbon monoxide and carbon dioxide.
Hazardous Polymerization: Will not occur under normal conditions.
Stability: This product is stable under normal storage conditions.
Section 11 - Toxicological Information
Product LD50: ND Product LC50: ND
Chemical Name LD50 LC50
polyurethane dispersion N.E. N.E.
Glycol Ether DB 6.56 g/kg RAT N.E.
Triethylamine 0.46 G/KG RAT 1000 PPM 4H/RAT
Dipropylene Glycol Monobutyl Ether 4400 mg/kg oral RAT N.E.
Section 12 - Ecological Information
Ecological Information: Product is a mixture of listed components.
Section 13 - Disposal Information
Disposal Information: Dispose of material in accordance to local, state and federal regulations and ordinances. Do
not allow to enter storm drains or sewer systems.
Section 14 - Transportation Information
DOT Proper Shipping Name: NON REGULATED
DOT Technical Name: --- Packing Group: ---
DOT Hazard Class: NON HAZARDOUS Hazard Subclass: ---
DOT UN/NA Number: NON REGULATED Resp. Guide Page: 127
Section 15 - Regulatory Information
CERCLA - SARA Hazard Category
This product has been reviewed according to the EPA `Hazard Categories' promulgated under Sections 311and
312 of the Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under
applicable definitions, to meet the following categories:
IMMEDIATE HEALTH HAZARD, CHRONIC HEALTH HAZARD, FIRE HAZARD
SARA Section 313:
Listed below are the substances (if any) contained in this product that are subject to the reporting requirements of
Section 313 of Title III of the Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
Chemical Name CAS Number
Glycol Ether DB 112-34-5
Triethylamine 102-71-6
Toxic Substances Control Act:
Listed below are the substances (if any) contained in this product that are subject to the reporting requirements of
TSCA 12(B) if exported from the United States:
U.S. State Regulations: As follows -
New Jersey Right-to-Know:
The following materials are non-hazardous, but are among the top five components in this product.
Chemical Name CAS Number
Water 7732-18-5
Water 7732-18-5
WATER 7732-18-5
Pennsylvania Right-to-Know:
The following non-hazardous ingredients are present in the product at greater than 3%.
Chemical Name CAS Number
Water 7732-18-5
Water 7732-18-5
WATER 7732-18-5
California Proposition 65:
This product contains no known chemcials known by the State of California to cause cancer
WARNING! This product contains a chemical(s) known to the state of California to cause birth defects or other
reproductive harm.
International Regulations: As follows -
CANADIAN WHMIS:
This MSDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16
headings.
CANADIAN WHMIS CLASS: D2B
Section 16 - Other Information
HMIS Ratings:
Health: 1 Flammability: 1 Reactivity: 0 Personal Protection: X
VOLATILE ORGANIC COMPOUNDS, g/l: 271
REASON FOR REVISION:
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
The information contained on this MSDS has been checked and should be accurate. However, it is the
responsibility of the user to comply with all Federal, State, and Local laws and regulations.
|