MATERIAL SAFETY DATA SHEET
NOVUS Inc. Medical Emergencies (800) 228-5635 x 334
Transportation Emergencies (800) 424-9300
12800 Highway 13 South, Suite 500
(Outside U.S. call (703) 527-3887 collect)
Savage, MN 55378
Business phone # (952) 944-8000
SECTION 1 - PRODUCT IDENTIFICATION AND USE
NOVUS I.D.
PRODUCT NAME(S): NOVUS Plastic Polish #1 (P/N 7020, 7024, 7026, & 7050) 7010
NUMBER:
CHEMICAL NAME: PRODUCT USE:
Clean and restore plastic surfaces.
NA
SECTION 2 - HAZARDOUS INGREDIENTS
% BY LD50 (SPECIES &
CAS # LC50 (SPECIES)
INGREDIENT EXPOSURE LIMITS
WEIGHT ROUTE)
Isopropyl Alcohol** 1-5 67-63-0 400 ppm (1,2) NE NE
500 ppm (4)
NOTES: (1) ACGIH TLV (TWA) (2) - OSHA PEL (TWA) (3) - ACGIH STEL (4) - OSHA STEL (5) - MFR/SUPPLIER TLV
LD 50 VALUES ARE VIA ORAL ROUTE UNLESS OTHERWISE INDICATED
** REGULATED CHEMICAL REPORTABLE PER SECTION 313, TITLE III SARA AND 40 CFR372
SECTION 3 - PHYSICAL DATA
PHYSICAL STATE: APPEARANCE: ODOR:
Liquid White opaque liquid Slight odor
VAPOR PRESSURE % VOLATILE: VAPOR DENSITY
<33 <5 NE
(mmHg): (AIR=1):
EVAPORATION BOILING POINT FREEZING POINT
<1 99 NE
RATE (BuAc=1): (deg C): (deg C):
pH: DENSITY (g/ml): SOLUBILITY IN
NE Complete
1.006
WATER:
SECTION 4 - FIRE AND EXPLOSION DATA
NFPA RATING:
FLAMMABILITY IF YES, UNDER
110B
YES NO X WHICH CONDITIONS:
Use media suitable for surrounding materials.
EXTINGUISHING MEDIA:
SPECIAL FIRE FIGHTING PROCEDURES: No special procedures required.
UPPER FLAMMABILITY LIMIT: LOWER FLAMMABILITY LIMIT:
FLASH POINT (PMCC) deg F: NE
>200 NE
(% BY VOLUME) (% BY VOLUME)
AUTOIGNITION HAZARDOUS COMBUSTION PRODUCTS: Carbon Dioxide and Carbon Monoxide.
NE
TEMPERATURE (deg C):
EXPLOSION SENSITIVITY TO IMPACT: SENSITIVITY TO STATIC DISCHARGE:
NE NE
DATA
SECTION 5 - REACTIVITY DATA
CHEMICAL STABILITY: IF NO, UNDER
YES X NO WHICH CONDITIONS:
INCOMPATIBILITY WITH OTHER SUBSTANCES:
Strong oxidizers.
YES X NO IF SO, WHICH ONES?
REACTIVITY, AND Product is not considered highly reactive.
UNDER WHICH CONDITIONS?
HAZARDOUS DECOMPOSITION
Carbon Dioxide and Carbon Monoxide.
PRODUCTS:
PN 0216 REV. NA - NOT APPLICABLE UN - UNAVAILABLE NE - NOT ESTABLISHED
1/07
PRODUCT NAME(S): NOVUS Plastic Polish #1 (P/N 7020, 7024, 7026, & 7050)
SECTION 6 - TOXICOLOGICAL PROPERTIES
ROUTE OF ENTRY: SKIN CONTACT X SKIN ABSORPTION EYE CONTACT X INHALATION X INGESTION X
X
EFFECTS OF ACUTE EXPOSURE TO PRODUCT:
May be mildly irritating to the eyes, nose, and throat. May cause mild skin irritation in
certain individuals.
EFFECTS OF CHRONIC EXPOSURE TO PRODUCT:
Prolonged inhalation of mist may cause mild respiratory irritation.
EXPOSURE LIMITS: IRRITANCY OF PRODUCT: SENSITIZATION TO PRODUCT: CARCINOGENICITY:
Mild: Eyes, skin, and respiratory
See section 2. NE
None reported or anticipated
TERATOGENICITY: REPRODUCTIVE TOXICITY: MUTAGENICITY: SYNERGISTIC PRODUCTS:
NE NE NE NE
SECTION 7 - PREVENTIVE MEASURES
PERSONAL PROTECTIVE EQUIPMENT
CLOTHING (SPECIFY): Not normally required; however, in situations RESPIRATORY (SPECIFY): Not normally required. For symptoms of
of extended skin contact, neoprene or other chemical resistant gloves overexposure, wear NIOSH - approved respirator for organic vapors.
are recommended.
EYE (SPECIFY): OTHER (SPECIFY): If possible, eye wash and safety shower
Not normally required; however, the use of safety
should be available.
glasses is recommended.
ENGINEERING CONTROLS (SPECIFY):
Local exhaust may be necessary under some useage/handling conditions.
Specific needs should be addressed by health/safety personnel.
LEAK/SPILL PROCEDURE:
Wear personal protective equipment. Remove heat and ignition sources, ventilate area, clean up with inert absorbant.
WASTE DISPOSAL:
Waste may be burned in an approved incinerator or disposed of according to local, state, provincial, and federal regulations.
HANDLING PROCEDURES/EQUIPMENT AND STORAGE REQUIREMENTS:
Store in closed container in cool, dry location, away from
direct sunlight or sources of intense heat.
OTHER INFORMATION:
SPECIAL SHIPPING INFORMATION:
KEEP FROM FREEZING HMIS Rating:
NOT REGULATED BY D.O.T. 110B
SECTION 8 - FIRST AID MEASURES
SYMPTOMS / EFFECTS OF OVEREXPOSURE: Respiratory irritation. High concentrations may cause headache, dizziness, and nausea.
Prolonged or repeated exposure may lead to skin irritation and dermatitis. Eye contact may be
irritating and may cause damage.
EYES:
Immediately flush eyes with large amounts of water for at least 15 minutes while holding the eyelids open. Get prompt medical attention.
SKIN:
Remove contaminated clothing. Wash skin thoroughly with soap and water. Get medical attention if irritation persists.
INHALATION:
Move victim to fresh air and treat symptomatically. Seek medical attention if irritation persists.
INGESTION:
Contact local poison control center or physician IMMEDIATELY!
SECTION 9 - MSDS PREPARATION INFORMATION
THIS MATERIAL SAFETY DATA SHEET IS OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT AS A PRODUCT SPECIFICATION. NO
WARRANTY, EITHER EXPRESSED OR IMPLIED, IS HEREBY MADE. THE RECOMMENDED INDUSTRIAL HYGIENE AND SAFE HANDLING
PROCEDURES ARE BELIEVED TO BE GENERALLY APPLICABLE. HOWEVER, EACH USER SHOULD REVIEW THESE RECOMMENDATIONS
IN THE SPECIFIC CONTENT OF THE INTENDED USE AND DETERMINE WHETHER THEY ARE APPROPRIATE.
PREPARED BY: DATE:
NOVUS Inc. CHEMISTRY DEPARTMENT 1-17-07
PN 0216 REV. 1/07
MATERIAL SAFETY DATA SHEET
NOVUS Inc. Medical Emergencies (800) 228-5635 x334
Transportation Emergencies (800) 424-9300
12800 Highway 13 South, Suite 500
Outside U.S. call (703) 527-3887 collect
Savage, MN 55378
Business Phone (952) 944-8000
SECTION 1 - PRODUCT IDENTIFICATION AND USE
NOVUS I.D.
PRODUCT NAME(S): NOVUS Plastic Polish #2 (P/N 7030, 7032, 7033, & 7072) 7011
NUMBER:
CHEMICAL NAME: PRODUCT USE:
Clean and restore plastic surfaces.
NA
SECTION 2 - HAZARDOUS INGREDIENTS
% BY LD50 (SPECIES &
CAS # LC50 (SPECIES)
INGREDIENT EXPOSURE LIMITS
WEIGHT ROUTE)
Odorless Mineral Spirits 7-13 64742-48-9 400 ppm (5) NE NE
10 mg/m3 (1)
Silica, Amorphous, Diatomaceous Earth 1-5 61790-53-2 NE NE
3 mg/m3 respirable (1)
3-7 68855-54-9 NE NE
.05 mg/m3 (2)
Crystalline Silicas 0 - 4.3 14808-60-7 NE LCLo (inhl-human)
300mg/m3/10 years
14464-46-1 respirable fraction
intermittent
Morpholine 1-5 110-91-8 20 ppm (1,2) Rat: 1050 mg/kg Rat: 12,000 ppm
30 ppm (3,4) Rabbit, skin: 500 mgkg (8 hr.)
Oleic Acid 1-5 112-80-1 NE Rat: 20 ml/kg NE
Non-Hazardous:
Water 60 - 70 7732-18-5
NOTES: (1) ACGIH TLV (TWA) (2) - OSHA PEL (TWA) (3) - ACGIH STEL (4) - OSHA STEL (5) - MFR/SUPPLIER TLV
LD 50 VALUES ARE VIA ORAL ROUTE UNLESS OTHERWISE INDICATED
SECTION 3 - PHYSICAL DATA
PHYSICAL STATE: APPEARANCE: ODOR:
Liquid Tan opaque liquid Slight solvent odor
VAPOR PRESSURE % VOLATILE: VAPOR DENSITY
<75 < 20 NE
(mmHg): (AIR=1):
EVAPORATION BOILING POINT FREEZING POINT
<1 80 NE
RATE (BuAc=1): (deg C): (deg C):
pH: DENSITY (g/ml): SOLUBILITY IN
NE Appreciable
1.01
WATER:
SECTION 4 - FIRE AND EXPLOSION DATA
FLAMMABILITY IF YES, UNDER NFPA Rating: 110
YES NO X WHICH CONDITIONS:
Carbon Dioxide, Dry Chemical, or Foam.
EXTINGUISHING MEDIA:
SPECIAL FIRE FIGHTING PROCEDURES: Use water spray or fog to cool fire exposed containers.
UPPER FLAMMABILITY LIMIT: LOWER FLAMMABILITY LIMIT:
FLASH POINT (PMCC) deg F: NE
>200 NE
(% BY VOLUME) (% BY VOLUME)
AUTOIGNITION HAZARDOUS COMBUSTION PRODUCTS: Carbon Dioxide and Carbon Monoxide.
NE
TEMPERATURE (deg C):
EXPLOSION SENSITIVITY TO IMPACT: SENSITIVITY TO STATIC DISCHARGE:
NE No
DATA
SECTION 5 - REACTIVITY DATA
CHEMICAL STABILITY: IF NO, UNDER
YES X NO WHICH CONDITIONS:
INCOMPATIBILITY WITH OTHER SUBSTANCES:
Strong oxidizers.
YES X NO IF SO, WHICH ONES?
REACTIVITY, AND Product is not considered highly reactive.
UNDER WHICH CONDITIONS?
HAZARDOUS DECOMPOSITION
Carbon Dioxide and Carbon Monoxide.
PRODUCTS:
PN 0217 REV. 1/07 NA - NOT APPLICABLE UN - UNAVAILABLE NE - NOT ESTABLISHED
PRODUCT NAME(S): NOVUS Plastic Polish #2 (P/N 7030, 7032, 7033, & 7072)
SECTION 6 - TOXICOLOGICAL PROPERTIES
ROUTE OF ENTRY: SKIN CONTACT X SKIN ABSORPTION EYE CONTACT X INHALATION INGESTION
X
X X
EFFECTS OF ACUTE EXPOSURE TO PRODUCT:
May cause respiratory irritation. Exposure to high concentrations may cause headache, dizziness, and nausea. Eye contact may cause burning
and irritation. Skin contact is a possible route of entry. Also, see information on crystalline silica (next entry).
EFFECTS OF CHRONIC EXPOSURE TO PRODUCT:
Prolonged or repeated skin contact may lead to drying, irritation, and dermatitis. This product may contain crystalline silica, which is known to cause
cancer by inhalation. If this product is used with mechanical polishing, dusts may be created that can be a chronic inhalation hazard. See Section 7
for measures to prevent exposure.
EXPOSURE LIMITS: IRRITANCY OF PRODUCT: SENSITIZATION TO PRODUCT: CARCINOGENICITY:
see note below under "Other
Mild: Eyes, skin, and respiratory
See section 2. NE
Information"
TERATOGENICITY: REPRODUCTIVE TOXICITY: MUTAGENICITY: SYNERGISTIC PRODUCTS:
NE NE NE
NE
SECTION 7 - PREVENTIVE MEASURES
PERSONAL PROTECTIVE EQUIPMENT
CLOTHING (SPECIFY): RESPIRATORY (SPECIFY):
Wear chemical resistant gloves and clothing
If TLV or PEL is exceeded, wear a NIOSH approved respirator for
as needed to prevent skin contact.
organic vapors. For mechanical polishing, wear dust mask.
EYE (SPECIFY): OTHER (SPECIFY): If possible, eye wash and safety shower
Wear chemical safety goggles.
should be available.
ENGINEERING CONTROLS (SPECIFY):
Local exhaust may be necessary under some useage/handling conditions.
Specific needs should be addressed by health/safety personnel.
LEAK/SPILL PROCEDURE:
Wear personal protective equipment. Remove heat and ignition sources, ventilate area, clean up with inert absorbant.
WASTE DISPOSAL:
Waste may be burned in an approved incinerator or disposed of according to local, state, provincial, and federal regulations.
HANDLING PROCEDURES/EQUIPMENT AND STORAGE REQUIREMENTS:
Store in closed container in cool, dry location, away from
direct sunlight or sources of intense heat.
SPECIAL SHIPPING INFORMATION: OTHER INFORMATION: HMIS Rating: 1 1 0 B
Diatomaceous Earths may contain crystalline silica, which is considered carcinogenic by
KEEP FROM FREEZING inhalation (IARC, NTP, California). However, with hand application respirable dusts are not
NOT REGULATED BY D.O.T. created. Use of mechanical polishing may necessitate respiratory PPE to limit exposure.
SECTION 8 - FIRST AID MEASURES
SYMPTOMS / EFFECTS OF OVEREXPOSURE: Respiratory irritation. High concentrations may cause headache, dizziness, and nausea.
Prolonged or repeated exposure may lead to skin irritation and dermatitis. Eye contact is irritating
and may cause damage.
EYES:
Immediately flush eyes with large amounts of water for at least 15 minutes while holding the eyelids open. Get prompt medical attention.
SKIN:
Remove contaminated clothing. Wash skin thoroughly with soap and water. Get medical attention if irritation persists.
INHALATION:
Move victim to fresh air and treat symptomatically. Seek medical attention if irritation persists.
INGESTION:
Contact local poison control center or physician IMMEDIATELY!
SECTION 9 - MSDS PREPARATION INFORMATION
THIS MATERIAL SAFETY DATA SHEET IS OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT AS A PRODUCT SPECIFICATION. NO
WARRANTY, EITHER EXPRESSED OR IMPLIED, IS HEREBY MADE. THE RECOMMENDED INDUSTRIAL HYGIENE AND SAFE HANDLING
PROCEDURES ARE BELIEVED TO BE GENERALLY APPLICABLE. HOWEVER, EACH USER SHOULD REVIEW THESE RECOMMENDATIONS
IN THE SPECIFIC CONTENT OF THE INTENDED USE AND DETERMINE WHETHER THEY ARE APPROPRIATE.
PREPARED BY: DATE:
NOVUS Inc. CHEMISTRY DEPARTMENT 1-17-07
PN 0217 REV. 1/07
MATERIAL SAFETY DATA SHEET
NOVUS Inc. Medical Emergencies (800) 228-5635 x 334
Transportation Emergencies (800) 424-9300
12800 Highway 13 South, Suite 500
(Outside U.S. call (703) 527-3887 collect)
Savage, MN 55378
Business phone # (952) 944-8000
SECTION 1 - PRODUCT IDENTIFICATION AND USE
PRODUCT NAME(S): NOVUS I.D.
pro NOVUS Plastic Polish #3 (P/N 7080, 7081, 7082, & 7085) 7107
NUMBER:
CHEMICAL NAME: PRODUCT USE:
Clean and restore plastic surfaces.
NA
SECTION 2 - HAZARDOUS INGREDIENTS
% BY LD50 (SPECIES &
CAS # LC50 (SPECIES)
INGREDIENT EXPOSURE LIMITS
WEIGHT ROUTE)
Dipropylene Glycol Monomethyl Ether 3-7 34590-94-8 100 ppm (1,2) Rat: 5.4 mg/kg NE
50 ppm (4) Rabbit, skin: >20 mgkg
10 mg/m 3(1)
Alumina (dust, as nuisance particulate, total) 10-30 1344-28-1 Rat: 3160 ml/kg NE
15 mg/m 3(2)
Non-Hazardous:
Water 60 - 80 7732-18-5
NOTES: (1) ACGIH TLV (TWA) (2) - OSHA PEL (TWA) (3) - ACGIH STEL (4) - OSHA STEL (5) - MFR/SUPPLIER TLV
LD 50 VALUES ARE VIA ORAL ROUTE UNLESS OTHERWISE INDICATED
SECTION 3 - PHYSICAL DATA
PHYSICAL STATE: APPEARANCE: ODOR:
Liquid White, opaque - gel like Lemon
VAPOR PRESSURE % VOLATILE: VAPOR DENSITY
NE <8 NE
(mmHg): (AIR=1):
EVAPORATION BOILING POINT FREEZING POINT
<1 NE NE
RATE (BuAc=1): (deg C): (deg C):
pH: DENSITY (g/ml): SOLUBILITY IN
7 Appreciable
1.188
WATER:
SECTION 4 - FIRE AND EXPLOSION DATA
NFPA RATING:
FLAMMABILITY IF YES, UNDER
110B
YES NO X WHICH CONDITIONS:
EXTINGUISHING MEDIA: Water Spray, Carbon Dioxide, Dry Chemical, or Universal Foam.
SPECIAL FIRE FIGHTING PROCEDURES: None
LOWER FLAMMABILITY LIMIT:
UPPER FLAMMABILITY LIMIT:
FLASH POINT (PMCC) deg F: NE
>200 NE
(% BY VOLUME)
(% BY VOLUME)
AUTOIGNITION HAZARDOUS COMBUSTION PRODUCTS: Carbon Dioxide and Carbon Monoxide.
NE
TEMPERATURE (deg C):
EXPLOSION SENSITIVITY TO IM- SENSITIVITY TO STATIC DISCHARGE:
NE No
PACT:
DATA
SECTION 5 - REACTIVITY DATA
CHEMICAL STABILITY: IF NO, UNDER
YES X NO WHICH CONDITIONS:
INCOMPATIBILITY WITH OTHER SUBSTANCES:
NO X
YES IF SO, WHICH ONES?
REACTIVITY, AND Product is not considered reactive.
UNDER WHICH CONDITIONS?
HAZARDOUS DECOMPOSITION
Carbon Dioxide and Carbon Monoxide.
PRODUCTS:
PN 0209 REV. 1/07 NA - NOT APPLICABLE UN - UNAVAILABLE NE - NOT ESTABLISHED
PRODUCT NAME(S): NOVUS Plastic Polish #3 (P/N 7080, 7081, 7082, & 7085)
SECTION 6 - TOXICOLOGICAL PROPERTIES
ROUTE OF ENTRY: SKIN CONTACT X SKIN ABSORPTION EYE CONTACT INHALATION INGESTION
X X X
EFFECTS OF ACUTE EXPOSURE TO PRODUCT: Eye contact may cause mild discomfort with slight irritation of the conjunctiva, seen as
redness and watering. Swallowing may cause abdominal discomfort, nausea, and
diarrhea.
EFFECTS OF CHRONIC EXPOSURE TO PRODUCT:
Mild skin irritation with prolonged exposure.
EXPOSURE LIMITS: IRRITANCY OF PRODUCT: SENSITIZATION TO PRODUCT: CARCINOGENICITY:
None known
See section 2. Mild: Eyes and skin NE
TERATOGENICITY: REPRODUCTIVE TOXICITY: MUTAGENICITY: SYNERGISTIC PRODUCTS:
NE NE NE NE
SECTION 7 - PREVENTIVE MEASURES
PERSONAL PROTECTIVE EQUIPMENT
CLOTHING (SPECIFY): RESPIRATORY (SPECIFY):
Wear chemical resistant gloves and clothing
Not normally required.
as needed to prevent prolonged skin expo-
sure.
EYE (SPECIFY): OTHER (SPECIFY): If possible, eye wash and safety shower
Safety glasses suggested if handling poses exposure should be available.
risk.
ENGINEERING CONTROLS (SPECIFY):
Specific needs should be addressed by health/safety personnel.
LEAK/SPILL PROCEDURE:
Cover with absorbent material or flush with hot water. Collect and dispose following government regulations.
WASTE DISPOSAL:
Follow all local, state, provincial, and federal regulations.
HANDLING PROCEDURES/EQUIPMENT AND STORAGE Use good manufacturing practices. Freezing may adversely affect
REQUIREMENTS: product appearance, but not functionality.
SPECIAL SHIPPING INFORMATION: OTHER INFORMATION:
Keep from freezing. Not regulated by D.O.T. HMIS Rating:
110B
SECTION 8 - FIRST AID MEASURES
SYMPTOMS / EFFECTS OF OVEREXPOSURE:
May include mild redness and itching.
EYES:
Flush eyes with large amounts of water for at least 15 minutes while holding the eyelids open. Seek medical attention if irritation
persists.
SKIN:
Remove contaminated clothing. Wash skin thoroughly with soap and water. Get medical attention if irritation persists.
INHALATION:
Move victim to fresh air and treat symptomatically. Seek medical attention if irritation persists.
INGESTION:
Contact physician or other medical source.
SECTION 9 - MSDS PREPARATION INFORMATION
THIS MATERIAL SAFETY DATA SHEET IS OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT AS A PRODUCT SPECIFICATION.
NO WARRANTY, EITHER EXPRESSED OR IMPLIED, IS HEREBY MADE. THE RECOMMENDED INDUSTRIAL HYGIENE AND SAFE
HANDLING PROCEDURES ARE BELIEVED TO BE GENERALLY APPLICABLE. HOWEVER, EACH USER SHOULD REVIEW THESE
RECOMMENDATIONS IN THE SPECIFIC CONTENT OF THE INTENDED USE AND DETERMINE WHETHER THEY ARE APPROPRIATE.
DATE:
PREPARED BY:
NOVUS Inc. CHEMISTRY DEPARTMENT 1-17-07
P N 0209 REV. 1/07
|