MSDS NO. 05104
MATERIAL SAFETY DATA SHEET
USG庐 No. 1 Pottery Plaster Page 1 of 4
United States Gypsum Company Product Safety: 1 (800) 507-8899
125 South Franklin Street Version Date: October 1, 1999
Chicago, Illinois 60606-4678 Version 3
SECTION I
PRODUCT IDENTIFICATION
PRODUCT(S): USG庐 No. 1 Pottery Plaster
CHEMICAL FAMILY: Calcium Sulfate Hemihydrate (Plaster of Paris, CaSO4鈥⒙? H2O)
SECTION II
INGREDIENTS
3 3
MATERIAL WT% TLV (mg/m ) PEL( mg/m ) CAS NUMBER
Plaster of Paris >95 10 15(T)/5(R) 26499-65-0
Crystalline Silica <5 0.1(R) 0.1(R) 14808-60-7
(T) 鈥? Total (R) 鈥? Respirable
All ingredients of this product are included in the U.S. Environmental Protection Agency鈥檚 Toxic Substances Control Act
Chemical Substance Inventory. All components of this product are included in the Canadian Domestic Substances List
(DSL) or the Canadian Non-Domestic Substances List (NDSL).
INFORMATION FOR HANDLING AND IDENTIFICATION OF CHEMICAL HAZARDS
NFPA Ratings: Health: 0 Fire: 0 Reactivity: 0 Other: N/A
HMIS Ratings: Health: 0 Fire: 0 Reactivity: 0
Personal Protection: Use eye and skin protection. Use NIOSH/MSHA-approved respiratory protection when necessary.
0 = Minimal Hazard 1 = Slight Hazard 2 = Moderate Hazard 3 = Serious Hazard 4 = Severe Hazard
SECTION III
PHYSICAL DATA
Appearance and Odor: Off white to gray powder; low odor.
Meltng Point: 1450掳C 鈥? decomposes
Solubility In Water: 0.15%
Specific Gravity (H2O=1): 2.3 鈥? 2.6
pH: 7.5 鈥? 8.5
Hardening Time: Varies. Check usage and/or product specification data for each product.
SECTION IV
FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): Non-combustible.
Extinguishing Media: Use extinguishing media appropriate for surrounding fire.
Special Fire Fighting Procedures: None
Unusual Fire and Explosion Hazards: None
MSDS NO. 05104
MATERIAL SAFETY DATA SHEET
USG庐 No. 1 Pottery Plaster Page 2 of 4
Special Fire Fighting Protective
Equipment: None
SECTION V
HEALTH HAZARD DATA
This product can release nuisance dust in handling or during use. Eye, skin, nose, throat, and upper respiratory
irritation may occur with prolonged dust exposures.
EFFECTS OF OVEREXPOSURE:
ACUTE:
EYES: Direct contact can cause mechanical irritation of eyes. If burning, redness, itching, pain or other symptoms
persist or develop, consult physician.
SKIN: When mixed with water, this material hardens and then slowly becomes hot. DO NOT attempt to make a cast
enclosing any part of the body using this material. Failure to follow these instructions can cause severe burns that may
require surgical removal of affected tissue or amputation of limb. Direct, prolonged or repeated contact with the skin
may cause irritation. Rubbing of this product against the skin can result in abrasions. Rinse with water until free of
material to avoid abrasions, then wash skin thoroughly with mild soap and water. May dry skin.
INHALATION: Inhalation of dusts from this product may irritate the nose, throat, lungs, and upper respiratory tract.
Persons subjected to large amounts of this dust will be forced to leave area because of nuisance conditions such as
coughing, sneezing and nasal irritation. Labored breathing may occur after excessive inhalation. If respiratory
symptoms persist, consult physician.
INGESTION: Unlikely to occur, but may cause gastric disturbances if swallowed. Plaster of paris is non-toxic, however,
ingestion of a sufficient quantity could lead to mechanical obstruction of the gut, especially the pyloric region. See
Emergency and First Aid - Ingestion below.
CHRONIC: This material displays no specific toxic properties.
INHALATION: Prolonged and repeated exposure to respirable crystalline silica can result in lung disease (i.e., silicosis)
and/or lung cancer.
EYES: None known.
SKIN: None known.
INGESTION: No known effects.
EMERGENCY AND FIRST AID PROCEDURES:
EYES: Flush thoroughly with water for 15 minutes. If irritation persists, consult physician.
SKIN: Wash with mild soap and water. A commercially available hand lotion may be used to treat dry skin areas. If
skin has become cracked, take appropriate action to prevent infection and promote healing.
INHALATION: Remove to fresh air. Leave the area of dust exposure and remain away until coughing and other
symptoms subside. Other measures are usually not necessary, however if conditions warrant, contact physician.
INGESTION: No harmful effects expected. No specific recommendations. If gastric disturbance occurs, call physician.
This product contains gypsum plaster. Plaster of paris hardens when wetted and, if ingested, may result in obstruction
of the gut, especially the pyloric region.
TARGET ORGANS: Eyes, skin, and respiratory system.
MEDICAL CONDITIONS WHICH MAY BE AGGRAVATED: Pre-existing upper respiratory and lung diseases such as,
but not limited to, bronchitis, emphysema and asthma.
PRIMARY ROUTES OF ENTRY: Inhalation: eyes and/or skin contact.
CARCINOGENICITY OF INGREDIENTS:
MATERIAL IARC NTP
Crystalline Silica Group 1 Anticipated
The average concentration of respirable crystalline silica measured in USG plaster of paris was less than 0.1 Wt.%.
In June, 1997, the International Agency for Research on Cancer (IARC) classified crystalline silica (quartz and
cristobalite) as a human carcinogen. In making the overall evaluation, the IARC Working Group noted that
carcinogenicity in humans was not detected in all industrial circumstances studied. Carcinogenicity may be dependent
MSDS NO. 05104
MATERIAL SAFETY DATA SHEET
USG庐 No. 1 Pottery Plaster Page 3 of 4
on inherent characteristics of the crystalline silica or on external factors affecting its biological activity or distribution of
its polymorphs.
IARC states that crystalline silica inhaled in the form of quartz or cristobalite from occupational sources is carcinogenic
to humans (Group 1).
SECTION VI
REACTIVITY DATA
STABILITY: Stable
INCOMPATIBILITY: Acids
HAZARDOUS POLYMERIZATION: Will not occur
HAZARDOUS DECOMPOSITION: Above 1450掳C could produce CaO and SO2.
SECTION VII
SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Sweep up material from spillage into a waste container for disposal, avoid creating excessive dust. If washed down,
may plug drains. If already mixed with water, scrape up and place in container. Avoid dusting conditions, minimize
airborne dust. Wear appropriate protective equipment.
WASTE DISPOSAL METHOD:
Dispose of material in accordance with Federal, State and Local regulations. Slurry may plug drains.
SECTION VIII
SPECIAL PROTECTION INFORMATION
No TLV assigned to this mixture, see Ingredients Section. Minimize exposures in accordance with good hygiene
practice.
RESPIRATORY PROTECTION:
Not typically necessary under normal conditions of use. Provide general ventilation and local exhaust ventilation to
meet TLV requirements of individual ingredients and to control dusting conditions. Avoid creating dust. Wear a
NIOSH/MSHA-approved dust respirator in poorly ventilated areas and/or if TLV is exceeded.
VENTILATION:
Ventilate to keep exposures below TLV. General ventilation is expected to be satisfactory. Use local exhaust
ventilation if necessary to control dust.
PERSONAL PROTECTIVE EQUIPMENT:
Gloves or protective clothing are usually not necessary but may be desirable in specific work situations. Wear gloves
and protective clothing to prevent repeated or prolonged skin contact. Wear eye protection (safety glasses or goggles)
to avoid particulate irritation of the eye.
SECTION IX
SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
During handling wear the appropriate respiratory, eye and skin protection if warranted per environmental conditions.
Keep dry. Dew point conditions or other conditions causing presence of liquid will harden this material during storage.
MSDS NO. 05104
MATERIAL SAFETY DATA SHEET
USG庐 No. 1 Pottery Plaster Page 4 of 4
鈭? WARNING!
When mixed with water, this material hardens and then slowly becomes hot. DO NOT attempt to make a cast
enclosing any part of the body using this material. Failure to follow these instructions can cause severe burns that may
require surgical removal of affected tissue or amputation of limb. Dust may cause eye, nose, throat, or respiratory
irritation. Avoid dust inhalation and exposure to dust. If dusty, wear a NIOSH/MSHA-approved dust respirator. Use
proper ventilation to reduce dust exposure. Wear eye protection. If eye contact occurs, flush thoroughly with water for
15 minutes. If irritation persists, call physician. Do not ingest. If ingested and any discomfort occurs, call physician.
Product safety information: (800) 507-8899.
KEEP OUT OF REACH OF CHILDREN.
END
|