Extremely
Flammable
Aerosol
Level 3
HARMFUL EXTREMELY
FLAMMABLE
MATERIAL SAFETY DATA SHEET
SECTION 1 - PRODUCT IDENTIFICATION
Aerosol Lithium Spray Lubricant 27512
Product: Code:
800-327-8583
Star brite Distributing
Manufacturer: Telephone:
800-424-9300 or
4041 S. W. 47 Avenue Ft. Lauderdale, FL Emergency
Address:
703-527-3887
33314
SECTION 2 - PRODUCT COMPONENTS
Component Name OSHA PEL ACGIH TLV Wt. % CAS Number
1) *Acetone 1000 ppm 500 ppm 25-30 67-64-1
2) Lithium Complex Grease --- --- 25-30 ---
3) *Xylene 100 ppm 100 ppm 20-25 1330-20-7
4) Mineral Spirits 100 ppm 100 ppm 5-10 64742-88-7
5) Isopropanol 400 ppm 200 ppm 1-5 67-63-0
6) Petroleum products, liquefied 1,000 ppm 800 ppm 68476-86-8
gas, sweetened
SECTION 3 - PHYSICAL AND CHEMICAL CHARACTERISTICS1
ND 0.858
Boiling Point: Specific Gravity:
ND No
Vapor Pressure: Water Soluble:
ND No
Vapor Density (Air = 1): Water Reactive:
ND ND
Volume % Volatile: pH:
ND
Appearance and Odor:
SECTION 4 - FIRE AND EXPLOSION INFORMATION
O潞 F ND
Flash Point (Method): Auto-ignition Temp.:
ND ND
Flammable Limits, LEL: UEL:
>30鈥? Yes
Flame Extension: Flashback:
Foam, dry chemical, carbon dioxide.
Extinguishing Media:
Use SCBA. Water is not suitable as an extinguishing
Special Firefighting Procedures:
media, but may be useful for cooling nearby
containers.
Unusual Fire and Explosion Hazards: Aerosol containers may burst when exposed to
temperatures in excess of 120潞F.
SECTION 5 - REACTIVITY DATA
Yes Heat, sparks, open flame.
Stable: Conditions to Avoid:
Strong oxidizers like chlorine or concentrated oxygen.
Incompatibility:
Hazardous Decomposition Products: Combustion may produce carbon monoxide, other
undetermined oxides, smoke and fumes.
Polymerization: No None known
Conditions to Avoid:
10/27/2006
SECTION 6 - HEALTH HAZARDS
Yes
No
Primary Routes of Entry: Oral: Carcinogenic Listing: NTP:
Yes No
Inhalation: IARC:
Yes ACGIH: No
Skin Absorb.:
HMIS Rating: 1 2 Flammability: 2 Reactivity: 0
Health:
Signs/Symptoms of Exposure:
Emergency First Aid Procedures
Flush with running water for 15 minutes, holding lid open to expose
Eye Contact:
eye surface. Contact physician.
Remove contaminated clothing and shoes. Wash with mild soap and
Skin Contact:
water, apply skin cream for irritation. Contact physician if irritation
persists.
Remove to fresh air at once. Apply artificial respiration if necessary.
Inhalation:
Contact physician immediately.
Do not induce vomiting. Contact physician immediately.
Ingestion:
Chronic Hazards: Health studies have shown that many petroleum hydrocarbons pose
human health risks that may vary from person to person. Prolonged
or repeated occupational overexposure to solvents has been linked
to permanent brain and nervous system damage. Intentional misuse
by deliberate concentration and inhalation may be harmful or fatal.
As a precaution, exposure to liquids or vapors should be minimized.
SECTION 7 - SPECIAL PRECAUTIONS/SPILL & LEAK PROCEDURES
Keep containers closed when not in use. Do not use or store
Precautions for Storage and
near open flame or strong oxidizers.
Handling:
Avoid breathing vapors or mists; prolonged or repeated skin
Other Precautions:
contact.
Spill or Leak Precautions: ** DANGER! LEAKING AEROSOLS CAN BE AN EXTREME
FIRE AND EXPLOSION HAZARD! Remove ignition sources.
Move leaking cans outdoors and empty into suitable container
by depressing valve button. Small liquid spills may be taken up
with absorbent material.
Comply with all applicable regulations.
Waste Disposal Method:
SECTION 8 - SPECIAL PROTECTION & PRECAUTIONS
None required in normal use but an effective NIOSH/MSHA
Respiratory Protection:
approved respirator should be used at any time when vapor
concentrations exceed established standards.
Adequate to maintain level below established standards.
Ventilation Type Required:
Yes Rate: >60 fpm Mech. (General) No
Local Exhaust:
Chemical resistant
Gloves:
Face shield or safety glasses recommended.
Eye Protection:
None required in normal use.
Other Clothing/Equipment:
Basic good housekeeping. Wash hands before eating or
Work/Hygienic Practices:
10/27/2006
smoking. Smoke only in designated areas.
SECTION 9 - SHIPPING/LABELING INFORMATION
Call for information
1
Values given in this section are for non-aerosolized product
Abbreviations
Not Applicable Million Parts per Cubic Foot
NA mppcf
Not Available Parts per Million
N AV ppm
mg/m3
Not Determined Milligrams per Cubic Meter
ND
None Established Chemical Abstract Service
NE CAS
National Toxicology Program Self Contained Breathing Apparatus
NTP SCBA
Initial Boiling Point Feet per Minute, Face Velocity
IBP fpm
Tagliabue Closed Cup
TCC
Cleveland Open Cup
COC
International Agency for Research on Cancer
IARC
Occupational Safety and Health Administration
OSHA
American Conference of Governmental Hygienists
ACGIH
The data on this sheet represent typical values. Since application variables are a major factor in product performance, this information should serve only as a
general guide. Star brite assumes no obligation or liability for use of this information. UNLESS Star brite AGREES OTHERWISE IN WRITING, Star brite
MAKES NO WARRANTIES, EXPRESS OR IMPLIED, AND DISCLAIMS ALL IMPLIED WARRANTIES INCLUDING WARRANTIES OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR USE OR FREEDOM FROM PATENT INFRINGEMENT. Star brite WILL NOT BE LIABLE
FOR ANY SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES. Your only remedy for any defect in this product is the replacement of the
defective product, or a refund of its purchase price, at our option.
Prepared by: Jeffrey Tieger
Date: 6/18/05
10/27/2006
|