MATERIAL SAFETY DATA SHEET
SECTION 1 鈥? SUPPLIER INFORMATION
Product Name: Star brite 140 WT Gear Oil GL1
Product Number: 16000, 16005, 160G55
Supplier鈥檚 Name & Address: Star brite
4041 S.W. 47 Avenue
Ft. Lauderdale, FL 33314
Information Phone Number: 954-587-6280
Emergency Phone Number: Chemtrec 800-424-9300 or 703-527-3887
Date Prepared: June 18, 2005
SECTION II 鈥? HAZARDOUS INGREDIENT INFORMATION
HAZARD RATING RATING
4 鈥? Extreme Health 鈥? 1
3 鈥? High Flammability 鈥? 2
2 鈥? Moderate Reactivity 鈥? 0
1 鈥? Slight CAS # - None-Mixture
0 鈥? Insignificant
Toxic and Hazardous Ingredients:
Ingredient CAS No. Exposure Limit TLV % by Wt.
Alkenylamine Not determined 0.1 鈥? 0.2
1,2,4 鈥? Trimethylbenzene 95-63-6 25 ppm 123 mg/m鲁 0.01 鈥? 0.04
SECTION III 鈥? PHYSICAL/CHEMICAL CHARACTERISTICS
Chemical Name: Petroleum Hydrocarbon and Additives
Formula: Not applicable
Form: Liquid
Appearance: Heavy liquid
Odor: Typical strong
Color: Amber
Specific Gravity: 0.897
Boiling Point: >344掳 C (651掳 F)
Melting Point (pour point) -12掳 C (-10掳 F)
Solubility in Water (by weight %) Negligible
Volatile (by weight %) Negligible
Evaporation Rate: Negligible
Vapor Pressure (mm Hg @ 20掳 C): Negligible
Vapor Density (air=1): Negligible
pH (as is): Not applicable
Viscosity SUS @ 100掳 F: 2,000
SECTION IV 鈥? FIRE AND EXPLOSION DATA
Special Fire Fighting Procedures: Do not use water, except as fog.
Unusual Fire & Explosion Hazards: None
Flashpoint (method used ASTM D92): 200掳 C (392掳 F)
Flammable Limits %: Not applicable
Extinguishing Agents: Dry chemical or water fog or CO2 or foam
SECTION V 鈥? REACTIVITY DATA
Stability: Stable
Conditions to avoid: None
Incompatibility: Strong oxidants
Hazardous Polymerization: Will not occur
Hazardous Decomposition Products: Thermal, unless otherwise specified carbon monoxide & carbon dioxide.
Product Number: 16000,16005,160G55
Product Name: Star brite 140 WT Gear Oil GL1 Prepared Date: June 18, 2005
SECTION VI 鈥? HEALTH HAZARD DATA/FIRST AID
EMERGENCY FIRST AID PROCESURES:
Eyes: Immediately flush with large quantities of water for at least 15 minutes and call a physician if any complications
arise.
Skin Contact: Wash thoroughly with soap and water. Do not wear heavily contaminated clothing before laundering. Prolonged
skin contact may cause dermatitis or irritation.
Inhalation: Remove victim to fresh air. Respiratory support if necessary. Seek medical attention.
If Swallowed: Do NOT Induce Vomiting. Seek medical aid.
SECTION VII 鈥? PRECAUTIONS FOR SAFE HANDLING
Precautions to be taken in Handling and Storage: Do not apply high heat or flame to container. Keep separate from strong
oxidizing agents.
Maximum Storage Temperature: 49掳 C (120掳 F)
SECTION VIII 鈥? SPECIAL PROTECTION AND CONTROL MEASURES
Ventilation Type Required (Local, mechanical, special): Is required when work place exposures exceed TLV. High mist can
result in fire or explosion.
Respiratory Protection (Specify Type): Normally none required. If high vapor or mist concentrations, use
respirator approved for organic vapors and mist.
Protective Gloves: Neoprene or nitrate rubber.
Eye Protection: Chemical safety goggles with side shields or face shield.
Other Protective Equipment: Launder soiled clothes before reuse.
SECTION IX 鈥? HANDLING OF SPILLS AND LEAKS
Procedures for Clean-up: Remove sources of heat or ignition, provide adequate ventilation, contain leak. Absorb small
spills with suitable material. Report spills as required to appropriate authorities.
Waste Disposal: Determine whether material is hazardous waste in your locality. Dispose of in compliance with all
Federal, State and Local regulations.
SECTION X 鈥? TOXICOLOGICAL/ECOLOGICAL INFORMATION
Permissible Concentrations: Oil mist mineral 5mg/m鲁 (OSHA and NIOSH)
Chronic Effects of Overexposure: Prolonged and/or frequent contact may cause dermatitis or filliculitis.
Acute Toxicological Properties: Low risk of inhalation, low irritant. Generally low toxicity, may be mildly irritating to the eyes.
SECTION XI 鈥? TRANSPORTATION DATA
Call for information
SECTION XII 鈥? REGULATORY INFORMATION
All components listed on TSCA inventory.
SECTION XIII 鈥? USER INFORMATION
The information and data herein are believed to be accurate and have been complied from sources believed to be reliable. It is offered
for your consideration, investigation, and verification. Buyer assumes all risk of use, storage and handling of the product in
compliance with applicable Federal, State and Local laws and regulations.
Product Number: 16000,16005,160G55
Product Name: Star brite 140 WT Gear Oil GL1 Prepared Date: June 18, 2005
CONT. - SECTION XIII 鈥? USER INFORMATION
Relating to any party鈥檚 use of or reliance on information and data contained herein regardless of whether it is claimed that the
information and data are inaccurate, incomplete or otherwise misleading, this information relates to the material designated and may
not be valid for such material used in combination with any other materials or in any process.
New and used motor oils have been tested for potential carcinogenicity in laboratory mice. Only used motor oil were shown to cause
skin cancer when repeatedly applied to mice without any effort to remove the material between applications. Strict compliance to the
occupational control procedures outlined in the data sheet is believed to be adequate protection from such hazards.
|